8.1(Hazardous Large-scale Lift) Pre-lift Check List 起重吊装前安全检查表

Project Name 项目名称：Contractor 施工单位：

Date 检查时间：Pass

合格Fail 不合格

Rigging &Lifting Plan/MS 吊装方案1、If L&R MS is available 起重吊装作业方案2、If L&R MS has been formally approved or not 作业方案是否经审批2Crane

起重机

1、Safety pin on the lifting hook 吊钩保险装置

2、Qualification of crane 起重机是否取得准用证

3、All safety devices 各种安全装置3Slings

吊索具

1、Wire rope 吊装用钢丝绳

2、Safety coefficient of sling(>6) 钢丝绳及索具安全系数是否大于6倍

3、Effective protection on sharp surface 捆绑时锐利部位有有效保护

4、Correct use of sling 正确使用吊索4Technical Hand-over

Meeting before

operation.

吊装方案技术交底

1、If L&R oeperation team have attended the technical hand-over meeting for that L&R operation and if there is complete record.吊装操作人员是否接受过吊装方案技术交底，记录是否齐全。5Hanging point

吊点

1、Correct lifting point 正确的吊点6Working crew

吊装操作人员

1、Qualification 吊装操作人员资质

2、Dedicated crane operator 指定吊车操作手

3、PPE (including seat belt) 是否按规定穿戴防护用品(包括座椅安全带)7Ground condition

地面状况1、Ground condition (complying with MS or crane instruction?) 起重机作业地面状况(是否符合作业方案要求或起重机说明书要求?)

2、Pads under outrigger 支腿垫护措施

8Overload operation 超负荷作业1、Whether lifting weight is specified and correct

被吊物体重量是否明确

2、If belongs to overload operation or not

是否属于超载作业

3、Whether have a trial test before every operation

每次作业前是否经试吊检验

9Work at heights 高空作业1、Proper fall protection for WAH 高空作业防坠措施

2、Proper working platform 合适的工作平台

Signal communication 信号传递Proper and effective signal communication 正确有效的信号传递措施11

Material stacking 吊物堆放Orderliness and stability 整齐及稳定性12Working area isolation

作业区域隔离

1、Proper barricading and clear sign 正确隔离围护和醒目警示标识

2、Dedicated L&R supervisor 专人警戒13

Operation environment

作业环境

Any particular risks that need special control measures or method statement: overhead lines, poor foundation, crane movement with load, crosswork. …. 是否有任何特殊的风险需要特别的控制措施或施工方案，比如高架线，地基不牢固，吊车载物行走，交叉作业等。Note ：L&R operation is forbidden to start-up once any items of the above failed to pass inspection.注:如果所有项目中有一项检查不合格，将不允许进行吊装作业。Inspected by 检查人Inspection Item 检查项目 Pre-lift Check List （For Hazardous/Large-scale Lifts ）

起重吊装前安全检查表 (针对危险性/大型吊装)

No .

序号Inspection Content 检查内容Result 检查结果Name of Contractor Safety representative 承包商安全代表Signature

签名1 of 1