空客飞机AMMIPCTSM手册使用

SCHEDULED MAINTENANCE PROCEDURES
例行维护程序
NON-SCHEDULED MAINTENANCEห้องสมุดไป่ตู้PROCEDURES
非例行维护程序
MRB
MPD
FM CDL
MEL
TSM
AMM – General 维护手册 –概述
The AMM provides detailed information required to maintain the aircraft at line or in the hangar. AMM 维护手册提供航线和定检维护时所需的详细技术信息 This does not include workshop information which is contained in the CMM.
- 部件位置 - 系统及部件描述. - 供电 (如适用) - 与其他系统的交连 (如适用) - 系统工作/控制& 指示 - BITE 测试.
This part contains the necessary data to understand the functioning of a system. 本部分内容有助于了解系统的功能.
Any Approved Repair: 批准的修理:
D&O
S R/I D/R A/T I/C C/P AR
PB 001 PB 201
PB 301 PB 401
PB 501 PB 601 PB 701 PB 801
Keyword – Page Block (PB) 关键字 – 页段 (PB)之间的关系
Technical Data Support & Services
Presented by
Name
JobTitle
AMM 及相关手册 AMM & Associated
Products
AMM – General 飞机维护手册 – 概述
WHEN YOU WORK ON AIRCRAFT USE THE AMM 当在飞机上工作时使用 AMM
D&O
Description and Operation 系统描述&工作
MP
Maintenance Procedures 维护程序
AMM – SB List 服务通告清单
AMM – SB List 服务通告清单
AMM – SB List 服务通告清单
Keyword – Page Block (PB) 关键字 – 页段 (PB)之间的关系
Table of Contents (TOC)
Description & Operation (PB 001) 系 统描述&工作 (PB 001) The purpose of the D & O is to explain:
系统描述&工作部分是为了解释:
- the component location - the system/component description - the power supply (if applicable) - the interfaces with other systems (if applicable) - the operation/control & indicating - the BITE test.
车间附件修理的技术信息不在AMM 而在 CMM 中.
The AMM is structured into ATA chapters and further into sub-systems and units as required. AMM维护手册按需要划分成ATA章节, 分系统和主题(部件)
Reference breakdown example: 例如:
Deactivation/Reactivation index <--- MMEL/CDL (失效/恢复使用程序 <--- MMEL/CDL)
At each chapter level you will find 在各章节包括
TOC ( + Highlights on PDF) 手册内容目录 ( +更改内容重点PDF 手册)
28 - 21 - 51
Component (unit) level, breakdown allocated by Manufacturer
部件,
由飞机制造商划分
Sub-sub-system level, breakdown allocated by
Manufacturer
次Su级b-分sy系st统em, 由飞机l制ev造el商, b划re分akdown allocated by ATA 100 Spec.
分系统
按 ATA 100 规范划分
Chapter 章
level, breakdown allocated by ATA 100 Spec. 按 ATA 100 规范划分
AMM – Breakdown 内容划分
Manual Front Matter page (手册首页) Highlights (only AirN@v) 更改重点 (只在AirN@v 中) Chapter 00 – Introduction (章节00 - 手册介绍) Fleet No. / MSN cross ref table (FSN / MSN 交叉索引表) SB list (SB 清单) COC list (COC 清单)
Any Removal or Installation or Deactivation or Reactivation 拆卸/安装, 或失效/ 恢复使用
Any Adjustment or Test: 调节/测试:
Any Inspection or Check 检查/检验:
Any Cleaning or Painting: 清洁/喷漆:
Description & Operation 系统描述&工作
Any Standard Maintenance Practices:
e.g. pressurizing, jacking, energizing... 任何标准施工: 如: 增压, 顶飞机, 通电
Any task related to Service, e.g. replenishment, lubricating... 勤务工作:如: 加油, 润滑...