机电材料检验标准(中英文)
机电专业英语翻译(中英文一行一行对照翻译)
专业英语(论文)英译汉课题名称机电专业英语学生姓名学号10411044系、年级专业10级机电一班指导教师2013年12月12日Design of StructuralMechanisms结构机制设计Melinda MayA dissertation submitted for the degree of Doctor of Philosophyin the Department of Engineering Science at the University of OxfordSt Hugh’s College牛津大学圣休斯学院工程科学系哲学博士学位论文Trinity Term 20032003年夏季学期Design of Structural Mechanisms结构机制设计Abstract摘要A dissertation submitted for the degree of Doctor of Philosophyin the Department of Engineering Science at the University of OxfordSt Hugh’s College牛津大学圣休斯学院工程科学系哲学博士学位论文Trinity Term 20032003年夏季学期In this dissertation, we explore the possibilities of systematically constructing largestructural mechanisms using existing spatial overconstrained linkages with onlyrevolute joints as basic elements.在这篇论文中，我们探讨利用只以旋转接头为基本元素的现存受空间限制过约束机构来系统地构建大型结构机制的可能性。
The first part of the dissertation is devoted to structural mechanisms (networks) basedon the Bennett linkage, a well-known spatial 4R linkage.该论文的第一部分专注于以贝内特机构为基础的结构机制（网络），一个众所周知的空间4R机构。
完整的一套产品检测标准(英文) Word 文档
MTL/ SGS TEST LIST (1)(Seating)(Combines Adult and Children’s sizes,:Chairs, Barstools, Ottomans,)MTL/ SGS TEST LIST (2) (CD Storage/Rack/Cabinet/5.drawer chest/4.drawer chest)MTL/ SGS TEST LIST (3)thSupporting surface loading parametersable 13.2 Simulated Television Load ParametersTdegree.Includes weight of text fixture.MTL/ SGS TEST LIST (4)Bed (For Trundle and Regular Beds, Adult use)MTL/ SGS TEST LIST (5)（Bunk Bed）MTL/ SGS TEST LIST (6)（Tables (Combines Adult and Children’s sizes, Indoor/Outdoor, for the following styles: Dining, camping, occasional and coffee tables, desks, nightstands, work bench, potting bench, storageMTL/ SGS TEST LIST (7)(Seating)(Combines Adult and Children’s sizes,:Chairs, Barstools, Ottomans,)MTL/ SGS TEST LIST (8)(Seating)(Combines Adult and Children’s sizes,:Chairs, Barstools, Ottomans,)包装测试1．For all carton dimensions as usual:Dimensions refer to the exterior of a carton, measured in inches of Length x Width x Height. in inches (mm or m)1.1 Length (L) is the longer side of the opening,1.2 Width (W) is the shorter.1.3 Height (H) is the length between the openings on either end.1．。
常用机电材料检测标准
查、弯曲试验，老化
取样100米
单板、两板
、三板、三
试样应在交货状态下，按同一
板加中线、
工程、同一企业、同一规格型
74
家 用 和 类 似 双路、公共
用 途 固 定 式 进入线的双
电 器 装 置 的 路、有一个
开关
断开位置的
双路、连两
标志检查、绝缘电阻、通断能 号随机抽取:标有一种额定电
GB16915.12003
外观检查及手动操作试验、脱
GB10963— 1999
扣特性试验（长延时、短延时 、瞬动）、介电性能（绝缘电 阻、介电强度）、接线端子及 载流部件连接的可靠性、升温
试样应在交货状态下，按同一 工程、同一企业、同一规格型 号随机抽取6只
、耐热性、耐异常热、防锈
JBT65272006
密度、导热系数、尺寸稳定性 、抗压强度、吸水率、燃烧性 按交货状态取样，取6块400×
能、抗弯强度、氧化指数、粘 400宽，厚度大于5cm的试样 接强度
GBT202192006
初始导热系数、老化导热系数 同原料、同配方、同工艺条件
、水蒸气透过率、尺寸稳定性 、闭孔率、粘接强度、抗压强 度、燃烧性能、容重
下，每批不超过300m³送样1 次，成品管壳可送5根，1m/根
QBT14532003
常用机电材料检测标准
φ110
建筑排水用
GB/T5836.1- 拉伸屈服强度、维卡软化温度
65
PVC-U管材
2006 、纵向回缩率、落锤冲击试验
φ75
每50吨取5m
φ50
建筑排水用
66
PVC-U管件
GB/T5836.22006
维卡软化温度、烘箱试验、坠 落试验
机械标准件中英文对照
中英文对照表标准件标准件（（外购件） 1 电机 Motor (MOT) 2 伺服电机 Servomotor (sm) 3 减速箱 Redcking gear box 4 变速箱 Speed change bo x 、gearbox5 刹车刹车、、制动器制动器、、闸Brake 6 滚筒 Roller 7 电滚筒 Power roller 8 过渡滚筒罩 Shroud 9 皮带 Belt10 链轮 Sprocke t 、chain wheel11 链、链条 Chain 12 链条活扣 Chain link 13 护线链 Chainflex cables14 齿轮 Gear 15 减速齿轮 Reduction gear 16 传动齿轮 Transmission gear 17 直线轴 Linear shaft 18 直线轴承 Linear bearing19 轴承Bearing 20 滚珠轴承滚珠轴承、、球轴承Ball bearing 21 轴承端盖 Bearing end cover 22 轴承垫 Bearing gasket 23 轴套轴套、、衬套 Bus h 、bushing 24 轴承支架 Bearing rack 25 轴承座 Bearing base 26 直线轴承座 Shaft block 27 枕式带座轴承 Pillow block 28 法兰式带座轴承 Pillow handle 29 离合器离合器、、连轴器连轴器、、接合器 Clutch 30 联轴器联轴器、、联接器联接器、、连轴节 Coupling 31 万向联轴节万向联轴节、、万向轴接手Universal coupling 32 标准气缸 Standard cylinder (CYL)33 阻挡气缸 Stopper cylinder 34无杆气缸Rodless cylinder中英文对照中英文对照表表35 双杆气缸 Dual-rod cylinder 36 摆动气缸 Rotary cylinder 37 锁紧气缸 Fine lock cylinder 38 气缸套筒气缸套筒、、气缸衬筒 Cylinder linear 39 减震器减震器、、缓冲器Shock absorber 40 接头 Splin e 、joint (JT) 41 快速接头 Quick coupling socket42 管接头管接头、、管节管节、、套筒Socket 43 管子 Tube 44 塑料气管 Plastic tubing 45 插入式/螺纹接头Fitting/multiple distributor 46 电磁阀 Solenoid valve (SV)47 3、5通电磁阀3、5 Port solenoid valve48 止回阀止回阀、、逆止阀Check valve 49 节流阀 Flow control valve 50 减压阀 Regulating valve 51 压力调节阀 Pressure control valve (PCV)52 消音器消音器、、遏声器 Silencer 53 气动三联体 F.R.L. combination54 过滤器 Filter 55 铝型材 Aluminium profile 56 日光灯架 Fluorescent lamp frame 57 日光灯管 Fluorescent lamp pipe 58 双支日光灯 Double tube light 59插座Socke t 、outlet紧固件紧固件（（联接件联接件）） 1 内六角螺栓 Hexago head bolt 2 外六角螺栓 Outside hex bolt 3 基础螺栓 Foudation bolt 4 扩开螺栓 Expansion bolt 5 板手螺栓 Wrench bolt 6拉紧螺栓Tightening screw7 调整螺栓Adjuster bol t、adjusting bolt8 方头螺栓Coach bolt9 内六角螺钉The inside hex screw10 十字半圆头螺钉Taping screw11 六角头螺钉Hexagon head screw12 自攻螺钉Taping-self screw13 埋头螺钉Countersunk screw (CSK SCREW)14 紧固螺钉Fastening screw15 夹紧螺钉Clamp screw16 调整螺钉Adjusting screw17 尖头螺钉Pointed screw18 木螺钉Wood bolt19 六角螺钉Hexagon nut20 盖头螺钉Cap nut21 锁紧螺钉Locknut22 平垫圈Flat washer23 弹垫圈Spring washer24 埋头垫圈Socket washer25 锁紧垫圈Locking washer气缸垫圈、、气缸垫片Cylinder washer26 气缸垫圈27 轴用挡圈External cirdip28 孔用挡圈Internal cirdip29 铆钉Rivet30 钉子Nail销钉、、接合销Pin31 销钉32 开口销Mouth pin33 保护销Pin cover34 止动销Stop pin35 销接Pin joint36 键Key材料1 导轨Guide、slide2 不锈钢板Stainless steel plate3 扁钢Flat bar4 棒钢Bar5 型钢Profile steel6 不等边角钢Unequal angle7 防滑板Checker plate8 料架Component holder rail9 铝型材Aluminium profile10 软管Flexpipe11 钢管Steel材料1 线槽Wire ducting2 脚轮Caste r、food whell把手、、闩、挡器Catc h、handle3 把手4 曲柄Crankfixed、、food5 地脚Ancho r、fixed6 法兰Flange7 阴/阳面法兰Male/female flange (M/P)8 张紧丝杆Tension bolt其它1 棉纱Cotton2 油漆Paint3 胶水Glue常用图形求面积、、体积公式常用图形求面积1 面积Area2 表面积Surface Area3。
(完整版)机械类常用技术要求中英文
常用技术要求before the feeding control and the wind meets the tube welding, to thegood center, in the hole guaranteed that ￠204the pipeline can pass through. the进料接管和出风接管焊前对好中心，内孔保证￠204 管道能穿过。
welding uses the manual arc welding, welding rod trademark J420G. before the焊接采用手工电弧焊，焊条牌号J420G。
painting, must carry on the superficial stain removal, the eliminationwelding residual and so on, its quality scale sees JB/T5000.12 thestipulation;Prime, in Huang He the blue color (according to color model) the polyurethane finishes two. Besides various laps spread the yellowpaint, other spread the blue color. In the paint does not allow to contain the lead. Does not allow to have leaks flaws and so on paint, wrinkle paint. 涂装前要进行表面除锈、清除焊接残渣等，其质量等级见JB/T5000.12 的规定；涂底漆一层、中黄和中蓝色（按颜色样板）聚氨酯面漆二层。
除各盖板涂中黄漆外，其余均涂蓝色。
漆中不允许含铅。
不允许有漏漆、皱漆等缺陷。
验货常规英汉
外观类：功能类：工艺类：丝印花开关损坏switch function broken 外壳刮伤scratch on unit body 开关不良poor switch 外壳脏dirty on unit body 开关紧switch tight 外壳变形body distort 开关功能反switch function assembly is opposite 外壳毛边unit body sharp edge 死机unit dead 底板刮伤scratch on soleplate 电机杂音motor noise 铝划伤scratch on aluminum plate 接触不良 poor connecting 电源线脏dirty on electric wire遥控失灵remote control dead 插头脏dirty on plug开关不灵敏switch is not sensitive 胶壳杂质color dot on plastic body指示灯不亮indicate light dead 胶壳破裂plastic body broken功率高低power is high/low 胶壳色差discolor on plastic body不顺畅switch moving not smoothly 胶壳溶化plastic body melting不能关switch not shut-off 生锈rusty机体歪斜unit inclined 螺丝生锈screw rusty功率超标power is not in the range allowed 元件黑components black高压击穿high voltage test failed 裂缝crack装配不良poor assembly 发亮brightness外观检查cosmetic inspect 油污greasy dirty内部检查inner parts inspect表面不平滑unsmooth surface污渍spot色差color shade shading外观不良cosmetic defect严重缺陷critical defect主要缺陷major defect次要缺陷minor defect不合规格not up to standard尺寸偏大size is a little bigger拉链头zipper puller污点较大dirty spot污点 较小dirty dot油渍oil stain针孔needle hole回针不佳poor back-stitches起皱pucker烫工不良poor ironing毛边线头uncut thread图案错误wrong pattern染色dyeing变色color variation填充不足short shot缩水shrink mark亮斑flash mark毛刺sharp edges指印finger prints箱唛錯carton marking wrong箱烂carton damaged poor silkscreening ；the printed word is bad箱麦不清楚carton marking illegible漏日期贴missing date code漏装产品missing product inside carton胶水印glue mark外箱无密封carton unsealed彩盒无密封gift box unsecured彩盒压烂gift box crushed独立装solid pack混合装assortment pack散包装bulk pack吸塑袋blister pack彩盒刮伤gift box scratched彩盒皱gift box wrinkledisplay box pack彩盒开口彩盒凹陷gift box Dent彩盒字迹模糊gift box illegible彩盒湿gift box wet彩盒无封口gift box unsealed胶纸粘贴不良tape poor sticking彩盒色差gift box color deviation彩盒印刷不良poor printing on gift box彩盒相粘gift box adhesion彩盒胶窗烂window box film damaged窗顶白window box film stress硅胶silicon rubber随机测试test with appliances脚垫漏装base pad is plate拔出来pull out毛重gross weight净重net weight窗凹陷window box film Dent窗脱落window box film detach窗透明度不够window box film poor transparency 型号错foreign brand model错目的地贴纸wrong destination label无警告语no suffocation warning无环保贴no recycling mark工艺类：材料类：颜色类：电镀生锈rusty on chrome body 锡粒tin grain 黄色电镀不良poor chrome furnishing 金属支架metal cantilever 黑色印刷不良poor printing 塑胶件plastic body 绿色螺丝滑牙screw not dependable 操作说明书instruction manual 灰色螺丝松动screw loose 条码barcode 蓝色螺丝未锁紧screw not tightened 保修卡warrantee card 银色螺丝漏锁screw omitted locked 用户手册user manual 金色无接地电阻earthy resistance test failed 弹簧springs 红色虚焊line false weld 环保标识environment ental 紫色标签翘起回收标识recycl emarking 白色印刷脱落poor printing粉红色机内有物other object found inside unit装配有裂缝assembly has crack印刷错误wrong printing配件遗漏accessory is missed前后盖装配不良错误mistake零件脫落detached parts尺码不符off size跳针skipping can not sticked well ；labelbad stickedfront/rear cover poorassembling包装类：yellowblackgreengreybluesilvergoldenredpurplewhitepink。
检测用语中英文对照
检测用语中英文对照A.C magnetic saturation 交流磁饱和Absorbed dose 吸收剂量Absorbed dose rate 吸收剂量率Acceptanc limits 验收范围Acceptance level 验收水平Acceptance standard 验收标准Accumulation test 累积检测Acoustic emission count（emission count）声发射计数（发射计数）Acoustic emission transducer 声发射换能器（声发射传感器）Acoustic emission(AE) 声发射Acoustic holography 声全息术Acoustic impedance 声阻抗Acoustic impedance matching 声阻抗匹配Acoustic impedance method 声阻法Acoustic wave 声波Acoustical lens 声透镜Acoustic—ultrasonic 声-超声（AU）Activation 活化Activity 活度Adequate shielding 安全屏蔽Ampere turns 安匝数Amplitude 幅度Angle beam method 斜射法Angle of incidence 入射角Angle of reflection 反射角Angle of spread 指向角Angle of squint 偏向角Angle probe 斜探头Angstrom unit 埃(A)Area amplitude response curve 面积幅度曲线Area of interest 评定区Arliflcial disconlinuity 人工不连续性Artifact 假缺陷Artificial defect 人工缺陷Artificial discontinuity 标准人工缺陷A-scan A 型扫描A-scope; A-scan A 型显示Attenuation coefficient 衰减系数Attenuator 衰减器Audible leak indicator 音响泄漏指示器Automatic testing 自动检测Autoradiography 自射线照片Avaluation 评定Barium concrete 钡混凝土Barn 靶Base fog 片基灰雾Bath 槽液Bayard- Alpert ionization gage B- A 型电离计Beam 声束Beam ratio 光束比Beam angle 束张角Beam axis 声束轴线Beam index 声束入射点Beam path location 声程定位Beam path; path length 声程Beam spread 声束扩散Betatron 电子感应加速器Bimetallic strip gage 双金属片计Bipolar field 双极磁场Black light filter 黑光滤波器Black light; ultraviolet radiation 黑光Blackbody 黑体Blackbody equivalent temperature 黑体等效温度Bleakney mass spectrometer 波利克尼质谱仪Bleedout 渗出Bottom echo 底面回波Bottom surface 底面Boundary echo(first) 边界一次回波Bremsstrahlung 轫致辐射Broad-beam condition 宽射束Brush application 刷涂B-scan presenfation B 型扫描显示B-scope; B-scan B 型显示C- scan C 型扫描Calibration,instrument 设备校准Capillary action 毛细管作用Carrier fluid 载液Carry over of penetrate 渗透剂移转Cassette 暗合Cathode 阴极Central conductor method 中心导体法Characteristic curve 特性曲线Characteristic curve of film 胶片特性曲线Characteristic radiation 特征辐射Chemical fog 化学灰雾Cine-radiography 射线(活动)电影摄影术Cintact pads 接触垫Circumferential coils 圆环线圈Circumferential field 周向磁场Circumferential magnetization method 周向磁化法Clean 清理Clean- up 清除Clearing time 定透时间Coercive force 矫顽力Coherence 相干性Coherence length 相干长度（谐波列长度）Coi1，test 测试线圈Coil size 线圈大小Coil spacing 线圈间距Coil technique 线圈技术Coil method 线圈法Coilreference 线圈参考Coincidence discrimination 符合鉴别Cold-cathode ionization gage 冷阴极电离计Collimator 准直器Collimation 准直Collimator 准直器Combined colour comtrast and fluorescent penetrant 着色荧光渗透剂Compressed air drying 压缩空气干燥Compressional wave 压缩波Compton scatter 康普顿散射Continuous emission 连续发射Continuous linear array 连续线阵Continuous method 连续法Continuous spectrum 连续谱Continuous wave 连续波Contract stretch 对比度宽限Contrast 对比度Contrast agent 对比剂Contrast aid 反差剂Contrast sensitivity 对比灵敏度Control echo 监视回波Control echo 参考回波Couplant 耦合剂Coupling 耦合Coupling losses 耦合损失Cracking 裂解Creeping wave 爬波Critical angle 临界角Cross section 横截面Cross talk 串音Cross-drilled hole 横孔Crystal 晶片C-scope; C-scan C 型显示Curie point 居里点Curie temperature 居里温度Curie(Ci) 居里Current flow method 通电法Current induction method 电流感应法Current magnetization method 电流磁化法Cut－off level 截止电平Dead zone 盲区Decay curve 衰变曲线Decibel(dB) 分贝Defect 缺陷Defect resolution 缺陷分辨力Defect detection sensitivity 缺陷检出灵敏度Defect resolution 缺陷分辨力Definition 清晰度Definition，image definition 清晰度，图像清晰度Demagnetization 退磁Demagnetization factor 退磁因子Demagnetizer 退磁装置Densitometer 黑度计Density 黑度（底片）Density comparison strip 黑度比较片Detecting medium 检验介质Detergent remover 洗净液Developer 显像剂Developer，agueons 水性显象剂Developer，dry 干显象剂Developer，liquid film 液膜显象剂Developer，nonaqueous （sus- pendible）非水（可悬浮）显象剂Developing time 显像时间Development 显影Diffraction mottle 衍射斑Diffuse indications 松散指示Diffusion 扩散Digital image acquisition system 数字图像识别系统Dilatational wave 膨胀波Dip and drain station 浸渍和流滴工位Direct contact magnetization 直接接触磁化Direct exposure imaging 直接曝光成像Direct contact method 直接接触法Directivity 指向性Discontinuity 不连续性Distance- gain- size-German AVG 距离- 增益- 尺寸（DGS 德文为AVG）Distance marker; time marker 距离刻度Dose equivalent 剂量当量Dose rate meter 剂量率计Dosemeter 剂量计Double crystal probe 双晶片探头Double probe technique 双探头法Double transceiver technique 双发双收法Double traverse technique 二次波法Dragout 带出Drain time 滴落时间Drain time 流滴时间Drift 漂移Dry method 干法Dry powder 干粉Dry technique 干粉技术Dry developer 干显像剂Dry developing cabinet 干显像柜Dry method 干粉法Drying oven 干燥箱Drying station 干燥工位Drying time 干燥时间D-scope; D-scan D 型显示Dual search unit 双探头Dual-focus tube 双焦点管Duplex-wire image quality indicator 双线像质指示器Duration 持续时间Dwell time 停留时间Dye penetrant 着色渗透剂Dynamic leak test 动态泄漏检测Dynamic leakage measurement 动态泄漏测量Dynamic range 动态范围Dynamic radiography 动态射线透照术Echo 回波Echo frequency 回波频率Echo height 回波高度Echo indication 回波指示Echo transmittance of sound pressure 往复透过率Echo width 回波宽度Eddy current 涡流Eddy current flaw detector 涡流探伤仪Eddy current testiog 涡流检测Edge 端面Edge effect 边缘效应Edge echo 棱边回波Edge effect 边缘效应Effective depth penetration （EDP）有效穿透深度Effective focus size 有效焦点尺寸Effective magnetic permeability 有效磁导率Effective permeability 有效磁导率Effective reflection surface of flaw 缺陷有效反射面Effective resistance 有效电阻Elastic medium 弹性介质Electric displacement 电位移Electrical center 电中心Electrode 电极Electromagnet 电磁铁Electro-magnetic acoustic transducer 电磁声换能器Electromagnetic induction 电磁感应Electromagnetic radiation 电磁辐射Electromagnetic testing 电磁检测Electro-mechanical coupling factor 机电耦合系数Electron radiography 电子辐射照相术Electron volt 电子伏恃Electronic noise 电子噪声Electrostatic spraying 静电喷涂Emulsification 乳化Emulsification time 乳化时间Emulsifier 乳化剂Encircling coils 环绕式线圈End effect 端部效应Energizing cycle 激励周期Equalizing filter 均衡滤波器Equivalent 当量Equivalent I．Q. I. Sensitivity 象质指示器当量灵敏度Equivalent nitrogen pressure 等效氮压Equivalent penetrameter sensifivty 透度计当量灵敏度Equivalent method 当量法Erasabl optical medium 可探光学介质Etching 浸蚀Evaluation 评定Evaluation threshold 评价阈值Event count 事件计数Event count rate 事件计数率Examination area 检测范围Examination region 检验区域Exhaust pressure/discharge pressure 排气压力Exhaust tubulation 排气管道Expanded time-base sweep 时基线展宽Exposure 曝光Exposure table 曝光表格Exposure chart 曝光曲线Exposure fog 曝光灰雾Exposure，radiographic exposure 曝光，射线照相曝光Extended source 扩展源Facility scattered neutrons 条件散射中子False indication 假指示Family 族Far field 远场Feed-through coil 穿过式线圈Field，resultant magnetic 复合磁场Fill factor 填充系数Film speed 胶片速度Film badge 胶片襟章剂量计Film base 片基Film contrast 胶片对比度Film gamma 胶片γ值Film processing 胶片冲洗加工Film speed 胶片感光度Film unsharpness 胶片不清晰度Film viewing screen 观察屏Filter 滤波器/滤光板Final test 复探Flat-bottomed hole 平底孔Flat-bottomed hole equivalent 平底孔当量Flaw 伤Flaw characterization 伤特性Flaw echo 缺陷回波Flexural wave 弯曲波Floating threshold 浮动阀值Fluorescence 荧光Fluorescent examination method 荧光检验法Fluorescent magnetic particle inspection 荧光磁粉检验Fluorescent dry deposit penetrant 干沉积荧光渗透剂Fluorescent light 荧光Fluorescent magnetic powder 荧光磁粉Fluorescent penetrant 荧光渗透剂Fluorescent screen 荧光屏Fluoroscopy 荧光检查法Flux leakage field 磁通泄漏场Flux lines 磁通线Focal spot 焦点Focal distance 焦距Focus length 焦点长度Focus size 焦点尺寸Focus width 焦点宽度Focus(electron) 电子焦点Focused beam 聚焦声束Focusing probe 聚焦探头Focus-to-film distance(f.f.d) 焦点-胶片距离（焦距）Fog 底片灰雾Fog density 灰雾密度Footcandle 英尺烛光Freguency 频率Frequency constant 频率常数Fringe 干涉带Front distance 前沿距离Front distance of flaw 缺陷前沿距离Full- wave direct current（FWDC）全波直流Fundamental frequency 基频Furring 毛状迹痕Gage pressure 表压Gain 增益Gamma radiography γ射线透照术Gamma ray source γ射线源Gamma ray source container γ射线源容器Gamma rays γ射线Gamma-ray radiographic equipment γ射线透照装置Gap scanning 间隙扫查Gas 气体Gate 闸门Gating technique 选通技术Gauss 高斯Geiger-Muller counter 盖革.弥勒计数器Geometric unsharpness 几何不清晰度Gray(Gy) 戈瑞Grazing incidence 掠入射Grazing angle 掠射角Group velocity 群速度Half life 半衰期Half- wave current （HW）半波电流Half-value layer(HVL) 半值层Half-value method 半波高度法Halogen 卤素Halogen leak detector 卤素检漏仪Hard X-rays 硬X 射线Hard-faced probe 硬膜探头Harmonic analysis 谐波分析Harmonic distortion 谐波畸变Harmonics 谐频Head wave 头波Helium bombing 氦轰击法Helium drift 氦漂移Helium leak detector 氦检漏仪Hermetically tight seal 气密密封High vacuum 高真空High energy X-rays 高能X 射线Holography (optical) 光全息照相Holography，acoustic 声全息Hydrophilic emulsifier 亲水性乳化剂Hydrophilic remover 亲水性洗净剂Hydrostatic text 流体静力检测Hysteresis 磁滞Hysteresis 磁滞IACS IACSID coil ID 线圈Image definition 图像清晰度Image contrast 图像对比度Image enhancement 图像增强Image magnification 图像放大Image quality 图像质量Image quality indicator sensitivity 像质指示器灵敏度Image quality indicator(IQI)/image quality indication 像质指示器Imaging line scanner 图像线扫描器Immersion probe 液浸探头Immersion rinse 浸没清洗Immersion testing 液浸法Immersion time 浸没时间Impedance 阻抗Impedance plane diagram 阻抗平面图Imperfection 不完整性Impulse eddy current testing 脉冲涡流检测Incremental permeability 增量磁导率Indicated defect area 缺陷指示面积Indicated defect length 缺陷指示长度Indication 指示Indirect exposure 间接曝光Indirect magnetization 间接磁化Indirect magnetization method 间接磁化法Indirect scan 间接扫查Induced field 感应磁场Induced current method 感应电流法Infrared imaging system 红外成象系统Infrared sensing device 红外扫描器Inherent fluorescence 固有荧光Inherent filtration 固有滤波Initial permeability 起始磁导率Initial pulse 始脉冲Initial pulse width 始波宽度Inserted coil 插入式线圈Inside coil 内部线圈Inside- out testing 外泄检测Inspection 检查Inspection medium 检查介质Inspection frequency/ test frequency 检测频率Intensifying factor 增感系数Intensifying screen 增感屏Interal,arrival time （Δtij)/arrival time interval（Δtij）到达时间差(Δtij) Interface boundary 界面Interface echo 界面回波Interface trigger 界面触发Interference 干涉Interpretation 解释Ion pump 离子泵Ion source 离子源Ionization chamber 电离室Ionization potential 电离电位Ionization vacuum gage 电离真空计Ionography 电离射线透照术Irradiance，E 辐射通量密度，EIsolation 隔离检测Isotope 同位素Kaiser effect 凯塞(Kaiser)效应Kilo volt kv 千伏特Kiloelectron volt keV 千电子伏特Krypton 85 氪85L／D ratio L/D 比Lamb wave 兰姆波Latent image 潜象Lateral scan 左右扫查Lateral scan with oblique angle 斜平行扫查Latitude (of an emulsion) 胶片宽容度Lead screen 铅屏Leak 泄漏孔Leak artifact 泄漏器Leak detector 检漏仪Leak testtion 泄漏检测Leakage field 泄漏磁场Leakage rate 泄漏率Leechs 磁吸盘Lift-off effect 提离效应Light intensity 光强度Limiting resolution 极限分辨率Line scanner 线扫描器Line focus 线焦点Line pair pattern 线对检测图Line pairs per millimetre 每毫米线对数Linear (electron) accelerator(LINAC) 电子直线加速器Linear attenuation coefficient 线衰减系数Linear scan 线扫查Linearity （time or distance）线性（时间或距离）Linearity，anplitude 幅度线性Lines of force 磁力线Lipophilic emulsifier 亲油性乳化剂Lipophilic remover 亲油性洗净剂Liquid penetrant examination 液体渗透检验Liquid film developer 液膜显像剂Local magnetization 局部磁化Local magnetization method 局部磁化法Local scan 局部扫查Localizing cone 定域喇叭筒Location 定位Location accuracy 定位精度Location computed 定位，计算Location marker 定位标记Location upon delta-T 时差定位Location，clusfer 定位，群集Location，continuous AE signal 定位，连续AE 信号Longitudinal field 纵向磁场Longitudinal magnetization method 纵向磁化法Longitudinal resolution 纵向分辨率Longitudinal wave 纵波Longitudinal wave probe 纵波探头Longitudinal wave technique 纵波法Loss of back reflection 背面反射损失Loss of back reflection 底面反射损失Love wave 乐甫波Low energy gamma radiation 低能γ辐射Low－enerugy photon radiation 低能光子辐射Luminance 亮度Luminosity 流明Lusec 流西克Maga or million electron volts MeV 兆电子伏特Magnetic history 磁化史Magnetic hysteresis 磁性滞后Magnetic particle field indication 磁粉磁场指示器Magnetic particle inspection flaw indications 磁粉检验的伤显示Magnetic circuit 磁路Magnetic domain 磁畴Magnetic field distribution 磁场分布Magnetic field indicator 磁场指示器Magnetic field meter 磁场计Magnetic field strength 磁场强度(H)Magnetic field/field，magnetic 磁场Magnetic flux 磁通Magnetic flux density 磁通密度Magnetic force 磁化力Magnetic leakage field 漏磁场Magnetic leakage flux 漏磁通Magnetic moment 磁矩Magnetic particle 磁粉Magnetic particle indication 磁痕Magnetic particle testing/magnetic particle examination 磁粉检测Magnetic permeability 磁导率Magnetic permeability 磁导率Magnetic pole 磁极Magnetic saturataion 磁饱和Magnetic saturation 磁饱和Magnetic writing 磁写Magnetizing 磁化Magnetizing current 磁化电流Magnetizing coil 磁化线圈Magnetostrictive effect 磁致伸缩效应Magnetostrictive transducer 磁致伸缩换能器Main beam 主声束Manual testing 手动检测Markers 时标MA-scope; MA-scan MA 型显示Masking 遮蔽Mass attcnuation coefficient 质量吸收系数Mass number 质量数Mass spectrometer （M.S.）质谱仪Mass spectrometer leak detector 质谱检漏仪Mass spectrum 质谱Master/slave discrimination 主从鉴别MDTD 最小可测温度差Mean free path 平均自由程Medium vacuum 中真空Mega or million volt MV 兆伏特Micro focus X - ray tube 微焦点X 光管Microfocus radiography 微焦点射线透照术Micrometre 微米Micron of mercury 微米汞柱Microtron 电子回旋加速器Milliampere 毫安（mA）Millimetre of mercury 毫米汞柱Minifocus x- ray tube 小焦点调射线管Minimum detectable leakage rate 最小可探泄漏率Minimum resolvable temperature difference （MRTD）最小可分辨温度差（MRDT）Mode 波型Mode conversion 波型转换Mode transformation 波型转换Moderator 慢化器Modulation transfer function （MTF）调制转换功能（MTF）Modulation analysis 调制分析Molecular flow 分子流Molecular leak 分子泄漏Monitor 监控器Monochromatic 单色波Movement unsharpness 移动不清晰度Moving beam radiography 可动射束射线透照术Multiaspect magnetization method 多向磁化法Multidirectional magnetization 多向磁化Multifrequency eddy current testiog 多频涡流检测Multiple back reflections 多次背面反射Multiple reflections 多次反射Multiple back reflections 多次底面反射Multiple echo method 多次反射法Multiple probe technique 多探头法Multiple triangular array 多三角形阵列Narrow beam condition 窄射束NC NCNear field 近场Near field length 近场长度Near surface defect 近表面缺陷Net density 净黑度Net density 净(光学)密度Neutron 中子Neutron radiograhy 中子射线透照Neutron radiography 中子射线透照术Newton （N）牛顿Nier mass spectrometer 尼尔质谱仪Noise 噪声Noise 噪声Noise equivalent temperature difference （NETD）噪声当量温度差（NETD）Nominal angle 标称角度Nominal frequency 标称频率Non-aqueous liquid developer 非水性液体显像剂Noncondensable gas 非冷凝气体Nondcstructivc Examination（NDE）无损试验Nondestructive Evaluation（NDE）无损评价Nondestructive Inspection（NDI）无损检验Nondestructive Testing（NDT）无损检测Nonera**le optical data 可固定光学数据Nonferromugnetic material 非铁磁性材料Nonrelevant indication 非相关指示Non-screen-type film 非增感型胶片Normal incidence 垂直入射（亦见直射声束）Normal permeability 标准磁导率Normal beam method; straight beam method 垂直法Normal probe 直探头Normalized reactance 归一化电抗Normalized resistance 归一化电阻Nuclear activity 核活性Nuclide 核素Object plane resolution 物体平面分辨率Object scattered neutrons 物体散射中子Object beam 物体光束Object beam angle 物体光束角Object-film distance 被检体-胶片距离Object 一film distance 物体- 胶片距离Over development 显影过度Over emulsfication 过乳化Overall magnetization 整体磁化Overload recovery time 过载恢复时间Overwashing 过洗Oxidation fog 氧化灰雾P PPair production 偶生成Pair production 电子对产生Pair production 电子偶的产生Palladium barrier leak detector 钯屏检漏仪Panoramic exposure 全景曝光Parallel scan 平行扫查Paramagnetic material 顺磁性材料Parasitic echo 干扰回波Partial pressure 分压Particle content 磁悬液浓度Particle velocity 质点(振动)速度Pascal （Pa）帕斯卡（帕）Pascal cubic metres per second 帕立方米每秒（Pa?m3/s ）Path length 光程长Path length difference 光程长度差Pattern 探伤图形Peak current 峰值电流Penetrameter 透度计Penetrameter sensitivity 透度计灵敏度Penetrant 渗透剂Penetrant comparator 渗透对比试块Penetrant flaw detection 渗透探伤Penetrant removal 渗透剂去除Penetrant station 渗透工位Penetrant，water- washable 水洗型渗透剂Penetration 穿透深度Penetration time 渗透时间Permanent magnet 永久磁铁Permeability coefficient 透气系数Permeability，a-c 交流磁导率Permeability，d－c 直流磁导率Phantom echo 幻象回波Phase analysis 相位分析Phase angle 相位角Phase controlled circuit breaker 断电相位控制器Phase detection 相位检测Phase hologram 相位全息Phase sensitive detector 相敏检波器Phase shift 相位移Phase velocity 相速度Phase-sensitive system 相敏系统Phillips ionization gage 菲利浦电离计Phosphor 荧光物质Photo fluorography 荧光照相术Photoelectric absorption 光电吸收Photographic emulsion 照相乳剂Photographic fog 照相灰雾Photostimulable luminescence 光敏发光Piezoelectric effect 压电效应Piezoelectric material 压电材料Piezoelectric stiffness constant 压电劲度常数Piezoelectric stress constant 压电应力常数Piezoelectric transducer 压电换能器Piezoelectric voltage constant 压电电压常数Pirani gage 皮拉尼计Pirani gage 皮拉尼计Pitch and catch technique 一发一收法Pixel 象素Pixel size 象素尺寸Pixel，disply size 象素显示尺寸Planar array 平面阵(列)Plane wave 平面波Plate wave 板波Plate wave technique 板波法Point source 点源Post emulsification 后乳化Post emulsifiable penetrant 后乳化渗透剂Post-cleaning 后清除Post-cleaning 后清洗Powder 粉未Powder blower 喷粉器Powder blower 磁粉喷枪Pre-cleaning 预清理Pressure difference 压力差Pressure dye test 压力着色检测Pressure probe 压力探头Pressure testing 压力检测Pressure- evacuation test 压力抽空检测Pressure mark 压痕Pressure,design 设计压力Pre-test 初探Primary coil 一次线圈Primary radiation 初级辐射Probe gas 探头气体Probe test 探头检测Probe backing 探头背衬Probe coil 点式线圈Probe coil 探头式线圈Probe coil clearance 探头线圈间隙Probe index 探头入射点Probe to weld distance 探头-焊缝距离Probe/ search unit 探头Process control radiograph 工艺过程控制的射线照相Processing capacity 处理能力Processing speed 处理速度Prods 触头Projective radiography 投影射线透照术Proportioning probe 比例探头Protective material 防护材料Proton radiography 质子射线透照Pulse 脉冲波Pulse 脉冲Pulse echo method 脉冲回波法Pulse repetition rate 脉冲重复率Pulse amplitude 脉冲幅度Pulse echo method 脉冲反射法Pulse energy 脉冲能量Pulse envelope 脉冲包络Pulse length 脉冲长度Pulse repetition frequency 脉冲重复频率Pulse tuning 脉冲调谐Pump- out tubulation 抽气管道Pump-down time 抽气时间Q factor Q 值Quadruple traverse technique 四次波法Quality (of a beam of radiation) 射线束的质Quality factor 品质因数Quenching 阻塞Quenching of fluorescence 荧光的猝灭Quick break 快速断间Rad(rad) 拉德Radiance，L 面辐射率，LRadiant existence，M 幅射照度MRadiant flux；radiant power，ψe 辐射通量、辐射功率、ψe Radiation 辐射Radiation does 辐射剂量Radio frequency （r- f）display 射频显示Radio- frequency mass spectrometer 射频质谱仪Radio frequency(r-f) display 射频显示Radiograph 射线底片Radiographic contrast 射线照片对比度Radiographic equivalence factor 射线照相等效系数Radiographic exposure 射线照相曝光量Radiographic inspection 射线检测Radiographic inspection 射线照相检验Radiographic quality 射线照相质量Radiographic sensitivity 射线照相灵敏度Radiographic contrast 射线底片对比度Radiographic equivalence factor 射线透照等效因子Radiographic inspection 射线透照检查Radiographic quality 射线透照质量Radiographic sensitivity 射线透照灵敏度Radiography 射线照相术Radiological examination 射线检验Radiology 射线学Radiometer 辐射计Radiometry 辐射测量术Radioscopy 射线检查法Range 量程Rayleigh wave 瑞利波Rayleigh scattering 瑞利散射Real image 实时图像Real-time radioscopy 实时射线检查法Rearm delay time 重新准备延时时间Rearm delay time 重新进入工作状态延迟时间Reciprocity failure 倒易律失效Reciprocity law 倒易律Recording medium 记录介质Recovery time 恢复时间Rectified alternating current 脉动直流电Reference block 参考试块Reference beam 参考光束Reference block 对比试块Reference block method 对比试块法eference coil 参考线圈Reference line method 基准线法Reference standard 参考标准Reflection 反射Reflection coefficient 反射系数Reflection density 反射密度Reflector 反射体Refraction 折射Refractive index 折射率Refrence beam angle 参考光束角Reicnlbation 网纹Reject; suppression 抑制Rejection level 拒收水平Relative permeability 相对磁导率Relevant indication 相关指示Reluctance 磁阻Rem(rem) 雷姆Remote controlled testing 机械化检测Replenisers 补充剂Representative quality indicator 代表性质量指示器Residual magnetic field/field，residual magnetic 剩磁场Residual technique 剩磁技术Residual magnetic method 剩磁法Residual magnetism 剩磁Resistance （to flow）气阻Resolution 分辨力Resonance method 共振法Response factor 响应系数Response time 响应时间Resultant field 复合磁场Resultant magnetic field 合成磁场Resultant magnetization method 组合磁化法Retentivity 顽磁性Reversal 反转现象Ring-down count 振铃计数Ring-down count rate 振铃计数率Rinse 清洗Rise time 上升时间Rise-time discrimination 上升时间鉴别Rod-anode tube 棒阳极管Roentgen(R) 伦琴Roof angle 屋顶角Rotational magnetic field 旋转磁场Rotational magnetic field method 旋转磁场法Rotational scan 转动扫查Roughing 低真空Roughing line 低真空管道Roughing pump 低真空泵S SSafelight 安全灯Sampling probe 取样探头Saturation 饱和Saturation，magnetic 磁饱和Saturation level 饱和电平Scan on grid lines 格子线扫查Scan pitch 扫查间距Scanning 扫查Scanning index 扫查标记Scanning directly on the weld 焊缝上扫查Scanning path 扫查轨迹Scanning sensitivity 扫查灵敏度Scanning speed 扫查速度Scanning zone 扫查区域Scattared energy 散射能量Scatter unsharpness 散射不清晰度Scattered neutrons 散射中子Scattered radiation 散射辐射Scattering 散射Schlieren system 施利伦系统Scintillation counter 闪烁计数器Scintillator and scintillating crystals 闪烁器和闪烁晶体Screen 屏Screen unsharpness 荧光增感屏不清晰度Screen-type film 荧光增感型胶片SE probe SE 探头Search-gas 探测气体Second critical angle 第二临界角Secondary radiation 二次射线Secondary coil 二次线圈Secondary radiation 次级辐射Selectivity 选择性Semi-conductor detector 半导体探测器Sensitirity va1ue 灵敏度值Sensitivity 灵敏度Sensitivity of leak test 泄漏检测灵敏度Sensitivity control 灵敏度控制Shear wave 切变波Shear wave probe 横波探头Shear wave technique 横波法Shim 薄垫片Shot 冲击通电Side lobe 副瓣Side wall 侧面Sievert(Sv) 希(沃特)Signal 信号Signal gradient 信号梯度Signal over load point 信号过载点Signal overload level 信号过载电平Signal to noise ratio 信噪比Single crystal probe 单晶片探头Single probe technique 单探头法Single traverse technique 一次波法Sizing technique 定量法Skin depth 集肤深度Skin effect 集肤效应Skip distance 跨距Skip point 跨距点Sky shine(air scatter) 空中散射效应Sniffing probe 嗅吸探头Soft X-rays 软X 射线Soft-faced probe 软膜探头Solarization 负感作用Solenoid 螺线管Soluble developer 可溶显像剂Solvent remover 溶剂去除剂Solvent cleaners 溶剂清除剂Solvent developer 溶剂显像剂Solvent remover 溶剂洗净剂Solvent-removal penetrant 溶剂去除型渗透剂Sorption 吸着Sound diffraction 声绕射Sound insulating layer 隔声层Sound intensity 声强Sound intensity level 声强级Sound pressure 声压Sound scattering 声散射Sound transparent layer 透声层Sound velocity 声速Source 源Source data label 放射源数据标签Source location 源定位Source size 源尺寸Source-film distance 射线源-胶片距离Spacial frequency 空间频率Spark coil leak detector 电火花线圈检漏仪Specific activity 放射性比度Specified sensitivity 规定灵敏度Standard 标准Standard 标准试样Standard leak rate 标准泄漏率Standard leak 标准泄漏孔Standard tast block 标准试块Standardization instrument 设备标准化Standing wave; stationary wave 驻波Step wedge 阶梯楔块Step- wadge calibration film 阶梯楔块校准底片Step- wadge comparison film 阶梯楔块比较底片Step wedge 阶梯楔块Step-wedge calibration film 阶梯-楔块校准片Step-wedge comparison film 阶梯-楔块比较片Stereo-radiography 立体射线透照术Subject contrast 被检体对比度Subsurface discontinuity 近表面不连续性Suppression 抑制Surface echo 表面回波Surface field 表面磁场Surface noise 表面噪声Surface wave 表面波Surface wave probe 表面波探头Surface wave technique 表面波法Surge magnetization 脉动磁化Surplus sensitivity 灵敏度余量Suspension 磁悬液Sweep 扫描Sweep range 扫描范围Sweep speed 扫描速度Swept gain 扫描增益Swivel scan 环绕扫查System exanlillatien threshold 系统检验阈值System inclacel artifacts 系统感生物System noise 系统噪声Tackground，target 目标本底Tandem scan 串列扫查Target 耙Target 靶Television fluoroscopy 电视X 射线荧光检查Temperature envelope 温度范围Tenth-value-layer(TVL) 十分之一值层Test coil 检测线圈Test quality level 检测质量水平Test ring 试环Test block 试块Test frequency 试验频率Test piece 试片Test range 探测范围Test surface 探测面Testing，ulrasonic 超声检测Thermal neutrons 热中子Thermocouple gage 热电偶计Thermogram 热谱图Thermography，infrared 红外热成象Thermoluminescent dosemeter(TLD) 热释光剂量计Thickness sensitivity 厚度灵敏度Third critiical angle 第三临界角Thixotropic penetrant 摇溶渗透剂Thormal resolution 热分辨率Threading bar 穿棒Three way sort 三档分选Threshold setting 门限设置Threshold fog 阈值灰雾Threshold level 阀值Threshotd tcnet 门限电平Throttling 节流Through transmission technique 穿透技术Through penetration technique 贯穿渗透法Through transmission technique; transmission technique 穿透法Through-coil technique 穿过式线圈技术Throughput 通气量Tight 密封Total reflection 全反射Totel image unsharpness 总的图像不清晰度Tracer probe leak location 示踪探头泄漏定位Tracer gas 示踪气体Transducer 换能器/传感器Transition flow 过渡流Translucent base media 半透明载体介质Transmission 透射Transmission densitomefer 发射密度计Transmission coefficient 透射系数Transmission point 透射点Transmission technique 透射技术Transmittance，τ 透射率τTransmitted film density 检测底片黑度Transmitted pulse 发射脉冲Transverse resolution 横向分辨率Transverse wave 横波Traveling echo 游动回波Travering scan; depth scan 前后扫查Triangular array 正三角形阵列Trigger/alarm condition 触发/报警状态Trigger/alarm level 触发/报警标准Triple traverse technique 三次波法True continuous technique 准确连续法技术Trueattenuation 真实衰减Tube current 管电流Tube head 管头Tube shield 管罩Tube shutter 管子光闸Tube window 管窗Tube-shift radiography 管子移位射线透照术Two-way sort 两档分选Ultra- high vacuum 超高真空Ultrasonic leak detector 超声波检漏仪Ultrasonic noise level 超声噪声电平Ultrasonic cleaning 超声波清洗Ultrasonic field 超声场Ultrasonic flaw detection 超声探伤Ultrasonic flaw detector 超声探伤仪Ultrasonic microscope 超声显微镜Ultrasonic spectroscopy 超声频谱Ultrasonic testing system 超声检测系统Ultrasonic thickness gauge 超声测厚仪Ultraviolet radiation 紫外辐射Under development 显影不足Unsharpness 不清晰Useful density range 有效光学密度范围UV-A A 类紫外辐射UV-A filter A 类紫外辐射滤片Vacuum 真空Vacuum cassette 真空暗盒Vacuum testing 真空检测Vacuum cassette 真空暗合Van de Graaff generator 范德格喇夫起电机Vapor pressure 蒸汽压Vapour degreasing 蒸汽除油Variable angle probe 可变角探头Vee path V 型行程Vehicle 载体Vertical linearity 垂直线性Vertical location 垂直定位Visible light 可见光Vitua limage 虚假图像Voltage threshold 电压阈值Voltage threshold 阈值电压Wash station 水洗工位Water break test 水膜破坏试验Water column coupling method 水柱耦合法Water column probe 水柱耦合探头Water path; water distance 水程Water tolerance 水容限Water-washable penetrant 可水洗型渗透剂Wave 波Wave guide acoustic emission 声发射波导杆Wave train 波列Wave from 波形Wave front 波前Wave length 波长Wave node 波节Wave train 波列Wedge 斜楔Wet slurry technique 湿软磁膏技术Wet technique 湿法技术Wet method 湿粉法Wetting action 润湿作用Wetting action 润湿作用Wetting agents 润湿剂Wheel type probe; wheel search unit 轮式探头White light 白光White X-rays 连续X 射线Wobble 摆动Wobble effect 抖动效应Working sensitivity 探伤灵敏度Wrap around 残响波干扰Xeroradiography 静电射线透照术X-radiation X 射线X-ray controller X 射线控制器X-ray detection apparatus X 射线探伤装置X-ray film 射线胶片X-ray paper X 射线感光纸X-ray tube X 射线管X-ray tube diaphragm X 射线管光阑Yoke 磁轭Yoke magnetization method 磁轭磁化法Zigzag scan 锯齿扫查Zone calibration location 时差区域校准定位Zone location 区域定位。
发电机检测中英文对照
发电机的检测(中英文对照 )1.INSPECT GENERATOR BRUSH HOLDER ASSEMBLY检查发电机碳刷装置(a)Using vernier calipers,measure the exposed brush legth. 。
用游标卡尺测出露在外面的碳刷的长度Standard exposed length:标准长度9.5 to 11.5 mm (0.374 to 0.453 in.)9.5 to 11.5 mm (0.374 to 0.453 in.)Minimum exposed length:最小长度1.5 mm ( 0.059 in.)1.5 mm ( 0.059 in.)If the exposed length is less than the minimum, neplace the generator brush holder assembly.如果碳刷长度小于最小值，替换发电机的碳刷装置。
2.INSPECT GENERATOR REGULATOR ASSEMBLY检查发电机调节器装配(a)Using an ohmmeter, check the continuity between terminals F an B（ a）使用欧姆表，检查 F 与 B 之间的是否连通。
Standard:标准 .When the positive and negative poles between terminals F and B are exchanged, thereis continuity in one direction but no continuity in the other direction..当 F 和 B 之间的正极和负极被交换时，有在一个方向是连通的，但是在另一个方向的没有连通的。
If the continuity is not as specified, replace the generator regulator assembly.如果不是规定的连通值，替换发电器调节器装配(b)Using an ohmmeter, check the continuity between terminals F and E.（ b）使用欧姆表，检查 F 与 E 之间是否连通。
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
机电材料检验标准
1.目的：
Purpose :
建立进料抽样检验标准，以确保进料质量能合乎既定之规范。
To establish the inspection standard of incoming sampling。
2.范围：
Scope :
2.1.有披覆之导线;裸导线; CABLE.
Conducting wire with shield cover; naked cable; cable
2.2.Bonding wire;
2.3.CONNECTOR, SOCKET, SWITCH, PIN HEADER, RELAY, SHORT PLUG,
WIRE(SILVER), COPPER WIRE, FUSE, FACK, BATTERY
2.4.水晶振荡子(CRYSTAL)、振荡器（O.S.C.）
--有引脚者。
(Lead wire.)
--无引脚但有焊端(Termination.)
--素芯片（Blank crystal）。
2.5.陶磁基片类（CERAMIC SUBSTRATE）
Ceramic substrate.
2.6.MIRROR类零件
Mirror.
3.权责：
Expediency :
3.1.平时IQC依照进料抽样检验标准作进料检验，VQA可视质量状况呈检
验单位主管同意后，对特定料号于检验基准书上作检验项目及抽样数之更改。
Ordinary IQC follow inspection standard of incoming sampling to do income inspection, VQA can ask inspection department director for modifying the sampling item the according as quality state, after getting the director approve, to modify the inspection items and sampling quantity of inspection instruction for specially designate P/N.
4.相关文件：
Relevance documents:
4.1.抽样计划AG-0801-M405-XX
Incoming inspection sampling plan
4.2.进料管制AG-0801-M402-XX
Incoming control
5.作业规定要点
The essentials of assignments regulations
5.1.材料名称:有披覆之导线;裸导线; CABLE
Material: Conducting wire with shield cover; naked cable; cable 5.1.1.抽样计划: 抽样计划．各site VQA 可因应实际情况不同，调整相
关抽样计划，经 site VQA主管同意后实行．
Sampling Plan.Base on the different situation, site VQA
could revise this sampling plan and get the approval by site
VQA head before implement
5.1.1.1.正常检验抽样标准AQL 0.65%, LEVEL 1，若线材为卷装则抽1
卷作特性检验，而待验批在20卷(含)以下另抽3卷，20卷以上
另抽5卷作一般外观检验。
(For Automotive Part Requirement:
AQL 0.4% S-3)
Regular sampling standard: AQL 0.65%, Level I. To check one
reel for characteristics inspection, if the conducting
wire is in reel packing. To perform visual inspection,
sampling size is 3 reels while the shipping 20 reels,
otherwise 5 reels. (For Automotive Part Requirement: AQL
0.4% S-3,)
5.1.1.2.尺寸检验以每批抽5 pcs量测 ,以0/1判定。
如客户或VQA有需
求才执行 Dimension inspection: 0/1 arbitration
based on 5 pcs (Base on request of Customer or VQA)
5.1.1.3.焊锡性试验以5PCS检验, 0/1判定 (须经后续焊锡作业者，得
执行之)如客户或VQA有需求才执行。
Solderability test: 0/1 arbitration based on 5 pcs.(for
being used in soldering process)(Base on request of
Customer and VQA)
5.1.1.4.电测: 以5pcs检验,0/1判。
(须量测导通性), 如客户或VQA有
需求才执行。
Electric test: 0/1 arbitration based on 5
pcs.(conductivity test)(Base on request of Customer or
VQA)。