TheRotaryDrillingRig 石工专业英语
钻井常用专业术语中英文翻译
刹车片 刹车踏板 刹车钢圈 刹车平衡器 水刹车 猫头绳 锚头 猫头绳小钩 猫头轴 泥浆泵 泵房 泥浆管线 泥浆泵凡尔 上水管线 泵排量 泵抽空 泵冲程 橡胶密封（圈） 空气包 上水凡尔 凡尔座取出器 卡瓦 安全卡瓦 吊钳 旋扣器 旋链 旋绳 链钳 管钳 方瓦钩子 钻杆钩子 液压大钳 天车 井架
rotary hose standpipe driller’s console pipe slacking block wire line stand cat walk pipe rack rotary table packing ring packing box pump cylinder sub X-over lifting sub short sub air compressor 钻具和井下作业 spud in put out of hole（POOH） kelly oil zone depth piston well drill pipe hydraulic tong joint (single) hole BHA trip run ih hole(RIH) steering tool lay down drill pipes
失水 泥浆 比重称 泥饼 泥浆杯 泥浆密度 除砂器 泥浆槽 泥浆枪 泥浆管线 泥浆漏失 泥浆池 泥浆站 泥浆筛 振动筛 捞砂筒 泥浆粘度 水基泥浆 盐水泥浆 泥浆罐
手工具 手钳 螺丝刀 扳手 锉刀 扁铲 钢锯 榔头 刮刀 手斧 套筒扳手 羊角锉
phillips screwdriver pick ring spanner scissors electrical spanner monkey wrench tool box cutting torch big hammer calliper jack tube tube cutter nut
录井钻井词汇英汉对照.doc
专业录井、钻井词汇英汉对照1. DRILLING ENGINEERING 钻井工程1.1 THE COMPENTS OF THE ROTARY DRILLING RIG钻机系统的组成1.1.1 Hoisting System 提升系统sub structure 井架底座，底部结构derrick (mask) 井架crown block 天车traveling block 游动滑车wire line (drill line) 钢丝绳，钻井大绳deadline死绳air hoist气压提升机，气压提升绞车drilling rig (drilling machine) 钻机drawwork绞车drum滚筒brake crank (handle, bar) 刹把hydraulic brake水刹车electric brake 电磁刹车mechanical friction device 机械磨擦装置cathead猫头elevator吊卡slip type casing elevator卡瓦型套管吊卡pipe elevator 钻杆吊卡 slip卡瓦safety slip 安全卡瓦collar rotary slip 环形钻铤转盘卡瓦drill pipe rotary slips 环形钻杆转盘卡瓦links连杆hook大钩hook load 大钩负荷 hook speed 大钩速度hook weight大钩悬重DF (drill floor) 钻台monkey board 二层台1.1.2 Circulating & Solids Control System 循环及固控系统drilling mud (drilling fluid) 钻井泥浆，钻井液water mud 淡水泥浆 water-base mud水基泥浆salt mud 盐水泥浆salt-base mud盐水基泥浆oil-base mud 油基泥浆oilemuision 油包水泥浆，石油乳浊液mud property 泥浆性能 mud weight out/in 泥浆密度进/出mud density out/in 泥浆密度进/出mud viscosity 泥浆粘度 mud conductivity 泥浆电导率mud resistivity 泥浆电阻 PH-value PH值water loss 失水 sand content 含砂量 gel strength 静切力mud cake 泥饼mud cake effect泥饼效应mud filtrate 泥浆滤液mud loss 泥浆漏失mud column 泥浆液柱mud sample 泥浆试样mud stability泥浆稳定性mud pump (pump) 泥浆泵pump body 泵体 pump capacity (discharge) 泵排量（泵容量） pump displacement泵排量pump output 泵排量pump efficiency 泵效率pump stroke 泵冲程pump cylinder 缸套mud pump rod 泥浆泵拉杆piston活塞mud room泵房mud lin浆管线choke line 地面管汇high pressure line 高压管线standpipe立管standpipe valve 立管闸门hose水龙带swivel水龙头swivel bail 水龙头吊环 swivel sub (joint) 水龙头接头swivel stem 水龙头中心管goosenec颈管wash pipe冲管wash pipe swivel 冲管旋转接头kelly方钻杆kelly cock 方钻杆上旋塞kelly dog nut 方钻杆下旋塞HWDP height weight drillpipe 加重钻杆DP drillpipe 钻杆DC drill collar 钻铤spiral collar螺旋钻铤pony DC (collar) 短钻铤NMDC non-monel collar 无磁钻铤tool join头sub (joint) 接头tool joint box 接头母扣tool joint pin 接头公扣X-O (crossover) subs 配合接头（转换接头）shock sub 减震接头bumper sub 缓冲器接头bit sub钻头接头flex sub 柔性短接string stabilizer (pin ×box) 钻具扶正器（公扣对母扣）near bit stabilizer (box ×box) 扶正器（母扣对母扣） centrallizer 扶正器bumpers (shock absorber) 减震器drilling junk basket 随钻打捞杯drilling jar 随钻震击器jar震击器BHA bottomhole assembly 下部钻具总成HDRT high data rate tool 高速数据传输钻具（M WD用）drill stem (drill string) 钻柱bit钻头drag bit (blade bit) 刮刀钻头cone bit (roller bit) 牙轮钻头 tri-cone bit 三牙轮钻头jet bit 喷射式牙轮钻头core drilling bit 取心钻头 milled tooth bit 铣齿钻头 insert bit 镶齿钻头gauge insert bit 保径镶齿钻头diamond bit 金刚石钻头bit cone 钻头牙轮bit size 钻头尺寸bit cost 钻头成本bit record 钻头记录bit type 钻头类型bit jets 钻头水眼bit nozzle 钻头喷嘴TFA total flow area 钻头水眼总流量面积bit consumption 钻头用量bit footage 钻头进尺 bit factor 钻头因素bit grading 钻头磨损等级bit-tooth dullness 钻头牙齿磨钝程度bit life 钻头寿命bit HHP hydraulic horsepower 钻头水马力hole opener 扩眼器underreamer 管下扩眼器annular 环空wellhead 井口flowline 架空管线shale shaker 震动筛mud tank (mud pits) 泥浆罐suction pit 进口罐setting pit 沉砂罐waste pit 泥浆坑desander 除砂器desilter 除泥器degasser 除气器mud cleaner 清洁器centrifuge 离心机agitator 搅拌机1.1.3 Rotary System 旋转系统prime mover 原动机 diesel engine 柴油机engine 引擎rotary table 转盘rotary base 转盘底座rotary chain 转盘传动链条 KB kelly bushing 方钻杆补心roller type bushing滚子方补心master bushing 转盘补心slip type casing spider 卡瓦型套管卡盘tongs 大钳，吊钳lead tongs 内钳back-up tongs 外钳hydraulic tongs 液压大钳chain tongs 链钳pipe tongs (spanner) 管钳spinning chain 旋链power tongs 动力大钳spanning wrench 旋转扳手1.1.4 Blowout Prevention System 防喷系统kick井涌blowout井喷blowout control 井控blowout control equipment井控设备blowout hookup 防喷装置BOP blowout prevention 防喷器annular ram prevention （万能）环形防喷器pipe rams （半封）闸板防喷器 blind rams 盲板全封式防喷器 shear rams 剪切闸板式全封防喷器blowout plug 防喷塞blowout preventer of three stage packer 三级密封式防喷器control console 控制台remote control console 远程控制台conductor line 导管choke line manifold 节流管线fill line 灌浆管线kill line 压井管线emergency line 紧急压井管线chokes节流阀hydraulic valve 液压阀gas buster 泥气分离器poor boy 泥气分离器choke pressure 节流压力blowout prevention procedure 防喷措施1.1.5 Motion Compensation System 运动补偿系统offshore floating rigs 海上浮式钻机drillstring compensator 钻柱补偿器sea level海平面sea floor海底deck甲板air pressure vessels 空气压力容器hydraulic cylinder assembles 液压缸总成piston rod 活塞杆standard hook assembles标准大钩总成riser隔水导管guideline tensioner 导索拉紧装置control panel 控制盘 guide base 导引底盘marine riser 海中隔水导管 moon pool 月形开口riser tensioner 隔水导管拉紧装置1.2 WELLS & DRILLING CRAFT 井与钻井工艺流程well, drilling well 井，钻井 wildcat well 预探，初探井delineation well 探边井 development well 生产井，开发井 satellite well 丛式井 injection well 注水井 direction well 定向井 deviation well 斜井 COST continental offshore stratigraphic test well（美）大陆近海地层探井to rig up 安装（钻机）to install the equipment 安装设备to get drill pipes in order 排钻具to measure & inspect drillstring仗量，检查钻具to measure the length of drill pipes &drill collars 量钻杆，量钻铤to nipple up BOP 装封井器 to spud in 开钻to turn on the pumps 开泵to circulate, circulation 循环circulate to the bottom up 完全循环reserve circulation 反循环bit break-in procedure 磨合钻头reaming扩眼drilling钻进coring drilling 取心钻进rough drilling (bouncing of drilling tool) 跳钻bit bouncing 蹩钻reverse rotation (running) 打倒车correct drift 纠斜 lost circulation 井漏 slough (cave-in) 井塌 to stop the pump 停泵 PC pipe connection 接单根make a joint 接单根 wire line survey 吊测deviation survey 测斜 to change the shaker screen 换筛布to repair the pump 修泵to break down a joint 卸一个单根to slug the pipe 往钻杆内打重泥浆POOH to pull out of hole 起钻to trip out the hole 起钻touch sticking 遇卡pulling a piston 拔活塞 to lubricate rig (drawwork) 保养钻机（绞车）to repair rig 维修钻机to cut & slip the drillline 倒大绳to clean the mud tank 清罐well logging, E-log 电测SWC sidewall coring 井壁取心DST drill stem test 钻杆中途测试 to running casing, casing 下套管surface casing 表层套管intermediate casing 技术套管liner尾管to running cementing 固井to squeeze cement 挤水泥 WOC wait on cement 侯凝to nipple up BOP 换装封井器 to install the BOP 装封井器 to test BOP 封井器试压to change bit, bit change 换钻头RIH run in hole 下钻to trip in 下钻 touchdown, touching resistance 遇阻RTO round trip operation 起下钻作业short tripping 短起下钻reaming划眼to cement plug , plug back 打水泥塞side tracking 侧钻to kick off 造斜KOD kick off depth 造斜深度KOP kick off point 造斜点to hang up 意外停机to survey the flowout 监测溢流flow check 溢流检查WOO wait on order 等指令WOW wait on weather等天气WOL wait on logging 等测井WOE wait on equipment 等设备WOFT wait on fishing tools等打捞工具to finish drilling 完钻to running the liner 挂尾管to plug-back 填井 final testing 完井测试to install the Chirstmas tree (production) 装采油树well completion 完井to prevent sticking 防卡to prevent caving 防塌to prevent loss of circulation 防漏to prevent blowout 防喷1.3 SPECIAL ENGINEERING OPERATION 特殊工程施工Coring取心1.3.1.1 Coring Equipment 取心及岩心分析设备coring drill 取心钻具 core drilling bit 取心钻头core bit 取心钻头coring crown 金刚石取心钻头 core cone bit 牙轮取心钻头 core basket 岩心爪 core barrel catcher 岩心抓取器core catcher 岩心爪 core catcher case 岩心爪外套core gripper 岩心爪 core-gripper with slip 卡瓦式岩心爪core-gripper with slipcollar 卡箍式岩心爪core-gripper with slipspring 卡簧式岩心爪core spring 岩心卡簧core barrel 岩心筒 core container 内岩心筒 core chamber 岩心室core barrel head 岩心筒上盖core barrel ring 取心筒垫圈core shoe （压力式）取心筒鞋core plunger 岩心推取杆 core pusher 岩心推取塞 core fisher 井底岩心打捞器core picker 落井岩心打捞器core bag 岩心袋core box 岩心盒core tray 岩心盒core house 岩心存储室core storage 岩心库core library 岩心库core breaker 岩心切断器 core slicer (splitter) 岩心切断器core-drying oven 岩心烘箱core cutter 岩心切片机core distillation apparatus 岩心蒸馏仪core interpreting device 岩心分析仪core laboratory 岩心分析实验室1.3.1.2 Core Drilling Operation 取心钻进作业core hole 取心井core boring 取心钻进core drilling 取心钻进cored-up mould 岩心造型coring depth 取心井深coring footage (run) 取心进尺coring weight 取心钻压 coring formation 取心地层 core grouting 取心被卡core breaking 割断岩心core breaking by hydraulic pressure 投球液压割心core breaking by mechanical loading 机械加压割心1.3.1.3 Core Analysis 岩心分析core-analysis data 岩心分析数据core data 岩心数据core log 岩心录井core graph 岩心图core cross section 岩心横剖面 core-description graph 岩心描述图core sample 岩心样core orientation 岩心方向 core inlet face 岩心入口面core outlet face 岩心出口面core diameter 岩心直径core intervals 取心井段 core footage (run) 取心进尺core recovery 岩心收获率 core porosity 岩心空隙度 core oil saturation 岩心含油饱和度 core permeability 岩心渗透率1.3.2 Directional Well Drilling & Deviation Survey 定向钻井和井斜监测directional well 定向井 directional hole 定向井directional drilling 定向钻井directional drilling contractor定向井承包商directional MWD 定向随钻测量directional drill tool 定向钻井工具 directional orientation tool 定向工具the steering tool 定向工具deflecting tool 造斜工具 directional-survey tool 定向测量工具direction finder 测向仪direction instrument 方向仪directional tool (steering tool) 随钻测斜仪inclinometer 测斜仪 single shot inclinometer 单点测斜仪syphon inclinometer 虹吸测斜仪continuous inclinometer 连续测斜仪gyroscope 陀螺仪pendulums (plumb bob) 测棰magnetic compass 磁螺盘directional turbodrill 定向涡轮钻具directional bit 定向钻头 directional-type tricone bit定向三牙轮钻头directional clinograph 方位测斜仪deviation replot 井斜图 side track 定向设计剖面图horiz projection 水平投影图 vertical projection 垂直投影图projection on a vertical plane 垂直面上的投影图deviation map 井斜图 perspective view 透视图3 dimensions visualisation三维空间透视图directional diagram 方位图deviation report 井斜报告directional data 井斜数据surveys 井斜数据deviation measurement data 井斜测量数据directional line 方向线main direction 主方向E.W.S.N 东，西，南，北directional control 方位控制directional characteristics 方位特征directional accuracy 方向性精度directional elements 定向要素direction parameter 方位参数horizontal plane 水平面vertical plane 垂直面directional angle 方位角the drift angle 井斜角the azimuth 方位角bearing (north) 方位角angle of projection投影角desired drift angle 设计的造斜角the bottom hole coordinate 井底坐标coarse coordinates 水平位移坐标the vertical depth 垂直深度KOD kick off depth 造斜深度end off deviation vertical depth 稳斜结束时的垂直深度end kick off vertical depth 结束造斜时的垂直深度final re-entry depth 恢复点的深度average angle method 平均角度法radius of curvature method 曲率半径法KOP kick off point 初试造斜点end of kick off 造斜终点end of deviation 斜井段终点re-entry point 返直点dog leg 井斜度，狗腿角dog leg scale 狗腿度比例dog leg severity 狗腿严重程度angle build up 增斜angle drop off 降斜dog leg at kick off point增斜率dog leg at re-entry point 降斜率the actual well path 井眼轨迹1.3.3 Casing 下套管casing套管casing joint 套管单根，一节套管casing starter 入井第一节套管 casing nipple 套管短节casing string 套管柱casing tally 套管记录 casing type 套管类型casing weight 套管重量 casing size 套管尺寸casing diameter 套管直径casing length 套管长度casing volume 套管容积casing grade 套管钢级casing depth 套管深度casing setting depth 套管下入深度casing accessories (hardware) 套管附件casing guide shoe 引鞋casing float shoe 套管鞋casing shoe depth 套管鞋深度casing centralizer 套管扶正器casing collar 套管接箍 casing check valve 回压凡儿casing float (collar) 回压凡儿casing sub 套管异径接头casing head 套管头casinghead spool 套管头四通casing landing 联顶节casing job下套管作业casing running(installation) 下套管casing-bearing formation好套管下入地层casing appliances 下套管工具casing connection套管连接casing elevator 套管吊卡casing slip 套管卡瓦casing spider 套管卡盘式吊卡casing suspender 套管悬挂器casing hanger 套管悬挂器casing screw protector 套管公扣护丝casing screw head 套管母扣护丝casing seal 套管密封件casing annular 套管环空casing-to-hole annular 套管井壁环空casing pressure 套管压力casing head pressure 套管头压力casing pressure test套管试压casingless completion裸眼完井casing inspection 套管探伤casing programme 套管程序casing severing 割套管casing sticking 套管被卡casing wear 套管磨损casing split 套管裂纹casing leak 套管漏casing imperfection套管缺陷casing failure 套管损坏casing damage 套管损伤casing deformation套管变形casing corrosion 套管腐蚀casing collapse 套管挤坏casing buckling 套管弯曲casing bridge plug套管桥塞casing bowl 套管打捞筒casing collar location 套管接箍测定器casing corrosion monitoring 套管腐蚀监测casing knife 套管割刀casing mandrel 胀管器casing mill 套管铣鞋casing packer 套管封隔器casing perforator 套管射孔器casing section mill 套管铣刀casing splitter 套管割刀casing withdrawal 拔套管1.3.4 Well Cementing 固井open hole 裸眼井cased hole 套管井pocket口袋the pocket volume 口袋体积normal volume 正常体积extra volume 额外体积hole description 井眼描述string / casing description 钻柱和套管描述surface cement line description 地面水泥管线描述cement 水泥number of sacks 水泥袋数cement factor 水泥系数 volume of the cement 水泥体积cement mark 水泥标号 cement brand 水泥牌号cement filtrate 水泥滤液cement slurry 水泥浆 cement paste 水泥浆cement milk 水泥浆 slurry in string 钻柱内水泥浆cement slurry volume 水泥浆体积（用量）slurry excess 水泥浆余量 slurry density 水泥浆密度 cement column 水泥浆液柱cement consistency 水泥浆稠度cement flow 水泥浆液流cement additive 水泥添加剂additive name 添加剂名称bentonite 膨润土additive volume 添加物体积cementer 粘结剂 cement accelerator 水泥促凝剂cement hardener 水泥速凝剂cement agent 粘结剂 cement concrete 水泥混凝土cement-water ratio 水灰比cement operation (jobs)固井作业cement method 固井方法first stage cementation一级注水泥two stage cementation 二级注水泥multi-stage cementation 多级注水泥liner cementation 衬管注水泥cement equipment (unit)固井设备cementing tool 固井工具 cementing pump 固井泵cementing pump skid 撬装注水泥泵组cementing tank 水泥罐cement blender 水泥搅拌器cement mixer 水泥搅拌器 cement practice 固井施工cement squeeze work 挤水泥作业cementing formulation 注水泥配方cement point 封固段 cementing through 全井封固seal liquid (spacer fluid) injection 注隔离液cementing injection 注水泥浆chasing 替浆cement displacement 替浆cementing reaction 胶结反应cement setting 水泥凝固cement curing time 水泥候凝时间cementing strength 水泥强度cemented up 注完水泥。
DRILLING PROFESSONAL WORDS(石油钻井专业英语)
1. Are you a driller?2. Are you a technician of this crew?3. What is this toolpusher's name?4. Is he a mud engineer? Yes. He is a senior engineer.5. He is a directional engineer.6. He is an assistant driller. He is not a driller. Who is the driller of this shift?7. Mr. Leo is the driller of this shift. We are all roughnecks of this shift.8. How many roughnecks and motormen are there in this shift?9. Is the driller on the drillfloor? No .He is on the mud tank.10. When did he begin to work as a rig manager? How long have you worked as a toolpusher?11. How long have you worked as a mechanist?12. He is in charge of drilling operation.13. Where do the floormen work? The work on the drillfloor.14. What is the toolpushers job? He is in charge of the shift operation.15. What is the derrickman responsible for? Who is he responsible to?16. Derrickma is responsible for attaching or detaching the elevators, for clearing, oiling,greasing, inspecting and repairing the pulley blocks, etc. He is responsible to the toolpusher.17. Who is the toolpusher responsible to? He is responsible to the drilling supervisor.18. What is the drilling supervisor responsible for? He is responsible for all drilling operations.19. The man driving the earthmover is LEO.20. The man 0perating brake bar is our driller.21. There are two roughnecks helping the driller get everything read for running in hole.22. The man who operates a brake bar is a driller.23. Here comes our superintendent.1.How long have you worked as a mud boy? I have been working as a mud boy since takingpart in job.2.In the petroleum industry, what is mud? The fluid for cooling the bit is called mud.3.Who mixes the mud? Where is the mud mixed? The floormen mix it at the mud tanks.4.What is bentonite? Bentonite is a clay .It consists of calcium, magnesium and aluminum.5.How does the mud reach the bit? It passes through the hollow string.6.What method do you take to check the quantity of salt in the mud?7.How many tons of barite can be placed there?8.On the day there was some mud in the tank .How many water was there in that one? It isabout ten cubic meters.9.Will more salt water be needed? Yes. It needs 50 cubic meters more.10.Do you know how to keep this kind of mud material? Under no conditions should this kind ofmud material be put in the sun for too long. Otherwise its properties will go bad.11.Do you know how to use these mud materials? Before using these mud materials，we mustknow their properties.12.How long will it take you to clear the mud tank? This work takes up too much time to clearthe mud tank. It will take us about three hours.13.How often do you make an experiment with the mud properties? Every four hours.14.What is the name of the special fluid? This fluid is called mud.15.Who is the person in charge of the drilling fluid? This fluid is called mud.16.How do you check the mud from the bottom of the hole? First，waiting for the mud to travelfrom the bottom up through the annulus to the surface.17.Is the specific gravity of the drilling fluid programmed to be higher or lower than the specificgravity of the cuttings? Why? It must be higher so that it can hold the cuttings in suspension if the mud circulation stops.18.If for any reason the mud circulation stops, the cuttings will be held in suspension 。
石油工程英语单词
石油钻井工程英语词汇D D R R I I L L L L I I N N G GE E N N G G I I N N E E E E R R I I N N G GE E N N G G L L I I S S H H W W O O R R D D S S A A N N D D P P H H R R A A S S E E S S中油长城钻井有限责任公司钻机管理分公司Drilling Branch of Greatwall Drilling Company .Ltd，目录第一章：石油钻井工程英语基础词汇第1节石油钻井工程基础词汇 (1)第2节石油钻井方法基础词汇 (5)第3节石油钻井技术基础词汇 (5)第4节石油钻井参数基础词汇 (6)第5节石油钻井作业现场工作人员名称 (7)第6节石油作业现场常用工具 (8)第二章：石油工程常用设备及专业术语第1节钻井设备部分 (13)第2节钻井泵类及相关设备 (16)第3节与泵操作有关的实用短语 (18)第4节钻台与底座 (19)第5节井控操作与防喷器 (19)第三章：钻井工程作业部分第1节钻井事故 (24)第2节钻头 (25)第3节钻具 (25)第4节钻井工程地面作业实用词汇与短语 (27)第5节钻井工程井口作业实用词汇与短语 (28)第四章：钻井液及相关设备第1节钻井液名称 (30)第2节钻井液设备 (31)第3节钻井液处理剂 (31)第五章：钻井相关作业第1节取芯部分 (35)第2节固井部分 (35)第3节固井水泥浆名称和参数 (37)第4节测井部分 (38)第六章：井下作业常用短语 (39)第七章：海上钻井作业 (40)第八章：定向井部分 (41)第九章：石油现场机械传动与机械设备第1节：动力与传动 (42)第2节机械加工与设备 (44)第3节油品名称 (49)第十章：地质地层与油藏工程第1节地质及地层 (50)第2节油藏工程和采油工程 (51)第十一章：石油工程作业现场生活用词第1节身体各部分名称 (52)第2节服装 (54)第3节描述天气 (56)第4节常见蔬菜名称 (57)第5节常见水果名称 (57)第6节味道和调味品调味品 (58)第7节酒类和祝酒 (59)第8节食品 (59)第9节超级市场 (60)第10节容器、单位及钱币 (61)第11节肉类 (61)第12节海鲜，鱼类 (62)第13节救火及救援 (62)第14节日常生活用品 (62)第15节星期与月份 (63)第16节数字 (64)第17节颜色 (65)第十二章：常用缩略语与换算第1节常用缩略语 Abbreviation (66)第2节钻井现场常用公英制（美国用法）换算 (67)第一章：石油钻井工程英语基础词汇第1节石油钻井工程基础词汇钻井：drill定向斜井：directional drilling欠平衡钻井：under-balance drilling海上钻井：off-shore drilling陆地钻井：on-shore drilling钻头：drill bit刮刀钻头：drag bit牙轮钻头：rock bit (镶齿钻头insert bit, 钢齿钻头steel toothed bit) 金刚石钻头：diamond bit取心钻头：coring bit钻头浮阀：float valve钻头水眼：bit nozzle(or jet)钻头水眼刺:bit nozzle washed out钻头规：bit caliper(bit gauge)钻头泥包：bit is balling钻头钝了，我建议现在起钻：bit is dull. I suggest to POOH now钻铤：DC(drill collar )光钻铤slick drill collar，螺旋钻铤spiral drill collar钻杆：DP(drill pipe )方钻杆：kelly公扣：pin end母扣：box end内平式连接：IF(internal flash)正规式连接：REG(regular)贯眼式连接：FH(full hole)加重钻杆 heavy weight drill pipe短钻杆 pop joint井下马达：downhole motor涡轮钻具：turbine震击器：drilling jar减震器：absorber下部钻具组合：BHA（bottom hole assembly）钻具扶正器：stabilizer（string stabilizer, near-bit stabilizer）钻机：drill rig钻井泥浆：drilling mud钻井液：drilling fluid钻井设备：drilling equipment油：oil原油：crude oil天然气：nature gas煤层气：coal-bed gas石油：petroleum中国石油（简称）：CNPC（China National Petroleum Corporation ）长城钻井（简称）：GWDC(Great Wall Drilling Company)采油：oil production产油层(目的层)：reservoir( or pay zone)钻进：drilling调整钻井参数以得到理想的机械钻速：play the drilling parameters to get fast ROP起钻：POOH(pull out of hole)下钻：RIH(run in hole)下套管：run casing(or RIH with casing)短起下钻：wiper trip循环泥浆：circulate泥浆：reverse circulate中途循环泥浆：break circulation分段下钻：RIH in stages通井：control trip划眼：reaming倒划眼：back reaming接单根：make connection滑、割大绳：slip and cut drilling line by ton-mile保养设备：maintain the equipment修理设备: repair (or fix) the equipment保养顶驱：service TDS保养冲管：lubricate wash pipe待工日费：standby rate今天零日费：there is no day rate today(zero day rate today)我可以为您做，但必须收费，请理解I can do for you and I have to charge(back charge) you. Please give me full understanding.不在我的职责范围之内，我要汇报领导，一有消息会马上告诉你It is out of my power and I have to report to my boss. I will let you know as soon as I get news.大鼠洞：rat hole小鼠洞：mouse hole钻具错扣：the connections are crossed钻具粘扣：thread is galled丝扣坏了：the thread is damaged起钻错扣：alternate the connections新钻具或接头磨扣：break in the new tool joint新钻头磨合：break in the new bitPDC钻头井底造型：shape the PDC bit跳钻：rough drilling( vibrated drilling, bit is bouncing) 蹩钻：rough drilling（drilling torque is abnormally high）缩径：tight hole起钻遇卡：get overpull下钻遇阻：set weight部分漏失：partially lost circulation全部漏失：totally lost circulation盲钻：blind drilling堵水眼：bit jets are blocked掉水眼：bit jets are lost憋压：the pressure is built up卸压：release pressure试压：pressure test功能测试：function test双方独自检查：double check地质：geology地质专业人员：geologist物理：physics地球物理勘探： geo-physical exploration.测井：logging电测井作业：wireline logging operation泥浆测井：mud logging井（副词“好”含意）：well拓展记忆：井眼：bore hole油气井：oil&gas well试井：well test井下：down-hole井下作业：down-hole operation第2节石油钻井方法基础词汇钻井原理：the principles of drilling顿钻钻井：percussion drilling，cable-tool drilling旋转钻井：rotary drilling大位移井：big distance( or extended ) well侧钻井：sidetracking drilling水平井：horizontal well探井：wildcat，wildcat drilling深井：deep well浅井：shallow well老井：maturing well丛式钻井：cluster well drilling煤层气井：coal-bed gas well生产井：production well报废井：abandoned well停产井：none-production well井下情况：downhole condition第3节石油钻井技术基础词汇技术规范，技术指标，技术性能： specification拉伸：tension拉伸强度：tensile strength弯曲强度：bending srength最小屈服强度： minimum torsional strength应力：stress压力：pressure应力点：stress point压力降：pressure drop压力梯度：pressure gradient回压：back pressure大气压：atmosphere压差： pressure difference静液柱压力：static fluid cloumn pressure地层压力：formation pressure坍塌压力：collapse pressure破裂压力：fractured pressure液体：liquid固体：solid气体：gas，air正的：positive负的：negative水平的：horizontal垂直的：vertical第4节石油钻井参数基础词汇钻压：WOB（weight on bit）转盘转速：RPM（rotation per minute）泵压：SPP(slurry pump pressure)泵冲：SPM（stroke per minute）排量：FR(flow rate)大钩负荷：hook load扭矩：torque反扭矩：reactive torque钻速：ROP(rate of penetration)顶驱：TDS(top drive system)钻井周期：drilling period钻井成本：drilling costs井眼尺寸：hole size垂深：TVD(total vertical depth)井深：MD(measured depth)水平位移：horizontal displacement井斜角：angle( or hole inclination)方位角：azimuth井眼环空：annulus第5节石油钻井作业现场工作人员名称甲方：oil company(operator)钻井承包商：drilling contractor第三方（分包商）the third party(sub-contractor)钻井经理：drilling manager监督：supervisor钻井监督：DSV(drilling supervisor) or Companyman地质监督：geologist泥浆工程师：mud engineer固井工程师：cementing engineer泥浆录井工：mud logger钻井队：drilling crew，drilling team钻井1班：drilling shift one总经理：general manager总工程师：chief engineer项目经理：project manager(country manager)作业经理：operation manager财务经理：financial manger会计：accountant平台经理：rig manager带班队长：tool pusherHSE监督：HSE officer司钻：driller副司钻：assistant driller井架工：derrick man钻工：roughneck（or floorman）场地工：roustabout泥浆工：mudman发动机工：motorman机械师： mechanic电工：electrician电焊工：welder司机：driver吊车司机：crane operator铲车司机：forklift operator营房经理：camp boss医生：doctor材料员：material man(storekeeper)炊事员：cook翻译：interpreter洗衣工：laundry man厨房服务生：waiter保安：watchman(or security)机械工程师：mechanic engineer第6节石油作业现场常用工具扳手：wrench螺丝起子：screwdriver多角螺丝起子：Phlilips screwdriver （cross-headed screwdriver）撬杠：bar加长撬杠：cheater bar活动板手：monkey wrench，adjustable wrench钳子：pliers钩子：hook台钳：bench vice钢挫：file榔头：hammer锤击扳手：hammer wrench搬手：spanner内六角扳手：Allen key钢锯：hacksaw砂纸：sandpaper管钳：pipe tongs(pipe wrench)链钳：chain tong千斤顶：jack黄油枪：grease gun吊车：crane牵引绳：tag line电焊条：welding rod拖拉机：tractor推土机：bulldozer硬尺：ruler游标卡尺：Vernier slide油漆：paint铅油：dope油漆刷：paint brush铅油刷：dope brush绝缘胶布：electrical tape电线：wire插头：plug电插座：outlet(receptacle or switchboard)开关：switch螺栓：bolt螺帽：nut垫片：washer钉子：nail手电钻：hand drill钻头：bit工作台：workbench工具箱：toolbox胶水：glue胶棒：glue bar护丝：thread protector手轮：hand wheel脚轰油门：throttle联接法兰：coupling flange(or adaptor flange) 安全带：safety belt安全帽：helmet工作靴：safety boot工衣：coverall棉袄：coat防护眼镜：safety goggle手套：gloves口罩：mouth mask围裙：apron洗眼台：eye washing station灭火机：fire extinguisher消防栓：fire -hydrant水龙头：water tap消防斧：fire fighting axe铲子：shovel手砂轮：emery wheel左转： turn left 右转： turn right手势：gesture信号：signal垃圾：waste garbage拖把：mop接头：sub配合接头：X-over ，cross-over提升短节：lifting sub卡瓦：slips放卡瓦：set slips母锥：box tap公锥：taper tap打捞矛：fishing spear安全接头：safety sub柔性短节：flexible joint井口盖子：wellhead cover防喷盒：mud boxBOP吊装：BOP trolley( BOP hoist)吊卡：elevator吊环：elevator links安全卡瓦：safety clamp(dog collar)钻杆架：pipe rack水龙头提环：swivel bail材料房：warehouse绳卡：bullnose clamp(guy anchor) 绳套：sling吊带：soft sling(belt)卸扣：shackle吊装工具：lifting gear维护保养：maintenance内钳：make-up tong外钳：break-out tong液压大钳：power tong液压猫头：E-zy tong兜绳：mule line四通阀：four-way valve三通：Tee软管：hose球阀：ball valve闸板阀：gate valve单流阀：back valve灌注泵：supercharge pump第二章：石油工程常用设备及专业术语第1节钻井设备部分井架：Derrick(or mast)起（放）井架：erect(lay down) Derrick底座大梁：sill钢木基础：mat铅锤：plumb水平仪：level架，台：rack立根盒：setback area坡道：V door(or ramp)猫道：catwalk二层台：monkey-board圆井盖：cellar cover天车：crown block防碰天车：crown-o-matic天车梁：crown block beam天车台：water table游动滑车：traveling block钻井大绳：drilling line引绳：guide line穿大绳：string-in drilling line金属线，电线：wire，cable钢丝绳股：strand截断：cutoff滑车，滑轮，皮带轮：pulley(hoist)手拉葫芦：hand pulley吊耳：lifting eye顶驱：top drive大钩：hook大钩弹簧：hook spring大钩销子：hook pin大钩锁紧装置：hook locking device大钩悬挂高度：hook height水龙头：swivel鹅颈管：gooseneck冲管：wash pipe水龙头盘根：swivel packing钻井水龙带: rotary hose( kelly hose) 立管：stand pipe立管管汇：stand pipe manifold高压管线：high pressure line 由壬：union低压管线：low pressure line 传感器：sensor放压管线：relief line转盘：Rotary Table转盘方瓦：master bushing方补心取出装置：bushing handling tool 方补心：kelly drive bushing方孔： square opening小鼠洞：mouse hole大鼠洞：rat hole绞车：Drawworks挂合（摘开）绞车：engage(disengage) drawworks液压绞车：hydraulic winch气动绞车：air tugger(air hoist)滚筒： drum( reel)滚筒高速气离合器： high speed clutch滚筒低速气离合器： low speed clutch锚头：cathead液压猫头：E-zy tong上扣猫头：make up cathead卸扣猫头：make out cathead牙嵌离合器：jaw clutch涡磁刹车：eddy current brake(electromagnetic brake) 猫头轴：cathead shaft猫头绳：cathead line死绳：dead line死绳固定器：dead line anchor间隙：gap死绳固定器膜片：dead line diaphragm上扣：make up上扭矩：torque sth卸扣，卸开：break out上紧，固定：tighten（fasten）松开，松扣：loosen加载：load卸载：unload盘式刹车：disc brake刹车总成：brake assembly刹车轴： brake shaft刹车带：brake band刹车片：brake block液压油箱：hydraulic power unit液动试压泵：hydraulic test pump液压大钳：hydraulic （power）tong倒档齿轮：reverse gear动力扳手：power wrench吊钳钳头：hinged jaw钳牙：die大钳锁销：latch大钳悬臂：suspension bar平衡重：counterbalance weight吊钳钳臂：tong arm第2节钻井泵类及相关设备泥浆泵：mud pump活塞：piston活塞杆：piston rod活塞皮碗：piston cup缸套：liner凡尔体：valve body凡尔座：valve seat凡尔箱：pump module阀弹簧：valve spring阀杆：valve lever阀面：valve face阀帽：valve bonnet空气包：pulsation damper充氮气：refill with nitrogen泥浆泵安全阀：pop-off valve卸压管线：release line排出阀：discharge valve 吸入阀：suction valve上水滤子：screen油尺：oil-level dipstick灌注泵：supercharge pump冷却水泵：cooling pump潜水泵：submersible pump盘根盒：stuffing box叶轮：impeller单向阀：check valve（single-pass valve）安全阀：safety valve手动阀：manual valve液动阀：hydraulic valve拉杆：tie rod，tension bar压力表：pressure gauge冲数：strokes排量：flow rate80冲(次)/分：eighty strokes per minute 泥浆罐：mud tank倒泥浆：transfer mud循环罐：active tank 储备罐：reserve tank起下钻罐：trip tank 溢流检查：flow check沉砂罐：satteling tank 锥形罐：sand trap震动筛：sahle shaker筛布：screen目数：mash除砂器: desander除泥器: desilter离心机： centrifuge泥浆分配槽：spider box缓冲罐buffer tank第3节与泵操作有关的实用短语没有压力：No pressure压力过高：The pressure is too high返回太少：Mud return is too few水太少：Water is not adequate.抢修：Rush to repair请看记录：Please check the record没作记录：No record available加化学药品：add chemicals测定比重：measure mud weight(specific gravity)测定失水：measure water loss泥饼：mud cake测定切力：measure gel strength停泵：stop pump请打手势：Please make a gesture转动一周：turn round a circle垫高一些：put something under it to raise抓紧：firmly grasp抬高：lift it up拿稳：hold firm打一下： hit once往外拉：pull outward站稳：stand firm小端：small end大端：large end光滑：smooth粗糙：coarse，rough平面：flat弯曲：bending放松：loosen绷直：stretch tight，draw tight冷却：cooling润滑：lubricate过载：overload功率不足：power is not enough.第4节钻台与底座钻台：drilling floor钻井班组记录：drilling tour record司钻监视器：driller's monitor司钻控制台：driller's console指重表：weight indicator底座：substructure井队活动房：trailer钻台上值班房：doghouse梯子：ladder第5节井控操作与防喷器溢流: kick溢流征兆: kick sign气侵：gas cut井喷： blow-out1次井控 the primary well control2次井控 the secondary well control3次井控 the tertiary well control平衡 balance超平衡over-balance欠平衡under balance漏失试验leak-off test破裂压力fracture pressure额定压力 rated pressure工作压力 working pressure防喷器组BOP stack安装（甩下）防喷器组：nipple up(nipple down) BOP stack 分流器diverter万能防喷器：annular preventer，bag preventer单闸板防喷器：single ram preventer双闸板防喷器：double ram preventer（防喷器）闸板：pipe ram变芯闸板防喷器variable bore ram全封式防喷器：blind ram剪切防喷器：shear ram内防喷器 Inside BOP投入式单流阀DIBPV（Drop in blowout preventer valve）分流关线diverter line节流管汇choke manifold节流阀choke valve旁通阀standby valve调压阀: Pressure regulator手动节流阀manual choke远程节流阀remote choke井口四通 drilling spool变径法兰：adapter flange液压控制阀 HCR(hydraulic controller)远程控制系统：koomey unit蓄能器： accmulator压井管线：kill line入口：inlet出口：outlet简易除气器：poor-boy degasser真空除气器：vaccum degasser泥浆池液面纪录仪Pit volume recorder(totallizer) 泥浆流动传感仪mud flow sensor泥浆增量 Pit gains硫化氢侵入H2S influx加重材料Weighted material氮气Nitrogen乙炔：acetylene氧气：oxygen预冲氮气压力Pre-charge nitrogen pressure地脚螺栓连接Studded connection法兰连接 Flange connection箍盘连接 Hub connection演习：drill急救演习：first aid drill消防演习：fire drill防喷演习：kick drill泄压: bleed off pressure带刻度压力表: calibrated pressure gauge带刻度容（体）积表: calibrated volume gauge套管鞋: casing shoe上部井眼段top hole section快速钻进地层fast drilling formation压实地层：consolidated formation风化地层：weathered formation钻屑携带能力cuttings carrying capacity浅层气藏shallow gas地层破裂formation to break down压力梯度pressure gradient地层压力formation pressure井口压力wellhead pressure漏失压力leak-off pressure破裂压力fractured pressure井底压力BHP( bottom hole pressure)正常压力normal pressure异常压力abnormal pressure静液压力hydrostatic pressure动态压力 dynamic pressure环空压力annular pressure关井钻杆压力SIDPP (shut in drill pipe pressure)关井套管压力SICP( shut in casing pressure)最大关井套管压力maximum allowable surface pressure, MAASP 最初循环压力 ICP( Initial circulating pressure)循环结束压力FCP(Final circulating pressure)U形管原理U-tube principle压井操作killing operation补救措施remedial actions关井后循环circulation under well closed in condition cl离子含量chloride contentDc指数 Dc exponent软关井soft shut in硬关井hard shut in第1次循环first circulation第2次循环second circulation压井泥浆比重kill mud weight抽吸swab激动surge含气地层gas bearing formation含气页岩gas bearing shale安全增量safety margin记录卡片trip sheet低循环泵速SCR(slow circulation rate)当量泥浆密度EQD(equivalent mud density)当量循环密度ECD(equivalent circulating density)司钻压井法driller’s method等待压井法wait & weight method体（容）积法volumetric method下推压井法bull-heading method不压井下钻：snub in第三章：钻井工程作业部分第1节钻井事故井喷：blow out井涌：kick井漏：lost circulation坍塌，井壁坍塌：cave in(collapse)出砂：sand production砂桥：sand bridge台阶：ledge键槽：keyseat椭圆井眼：oval shaped hole卡钻：sticking填井：pack-hole封井：packed drilling井下落物：fish大幅度活动钻具试图解卡：work the string and try to free it活动钻具以避免卡钻：move(reciprocate ) the string to avoid being stuck. 打捞：fishing鱼头：top of fish打捞工作：fishing job侧钻：side-tracking侧钻井眼：sidetracking hole水泥窜槽：cement channeling固井失败：cement failure防砂：sand control缓慢开泵并仔细观察返浆情况：slowly start pumping and closely watch the return on the shale shaker第2节钻头牙轮钻头：rock bit刮刀钻头：drag bit金钢石钻头：diamond bit镶齿钻头： insert bit铣齿钻头：milled tooth bit喷射钻头：jet bit牙轮：cone钻头装卸器：bit breaker钻头直径：bit diameter钻头寿命：bit life钻头磨损：bit wear钻头型号：bit type水眼尺寸：nozzle size水眼效率：nozzle efficiency钻头接头：bit sub第3节钻具方钻杆：kelly方钻杆旋扣器：kelly spinner方钻杆旋塞：kelly cock钻具：drilling string钻杆：drill pipe油管：tube钻具组合：drilling assembly扶正器：stabilizer扩眼器：reamer（hole opener）钻铤：drill collar无磁钻铤：NMDC(non-magnetic drill collar) 加重钻杆：HWDP(heavy weight drill pipe)近钻头扶正器：near-bit stabilizer震击器：jar减震器：shock absorber螺旋钻铤：spiral drill collar键槽破坏器：key seat reamer安全接头：safety joint钻杆刮泥器：drill pipe wiper泥浆动力钻具：mud motor钻柱：drill string涡轮：turbine涡轮钻具：turbo-drill stem立根：stand加厚：upset内加厚：IU(internal upset)外加厚：EU(external upset)内外加厚：internal-external upset丝扣：thread打捞颈：fishing neck母扣：box 公扣：pin左旋螺纹：left-hand thread右旋螺纹：right-hand thread正规接头：regular joint贯眼接头：full hole joint内平接头：internal flush joint护丝：thread protector快速护丝：easy protector打捞工具：fishing tool打捞作业：fishing operation打捞篮：junk basket卡瓦打捞筒：overshot打捞杯：junk sub牙轮打捞器：cone fisher套管打捞矛：casing spear打捞矛：fishing spear打捞公锥：male tap(fishing nipple)打捞母锥：female tap(fishing socket)倒扣工具：reversing tool(backing-up tool)铣鞋：milling shoe铣具：milling tool平底铣鞋：flat bottom mill磁力打捞工具：magnetic fishing tool打捞钩：fish hook气动工具：pneumatic tool减摩短节：friction reduction sub下套管漂浮接箍：casing floating coupling轴向加压器：hydraulic axial thruster第4节钻井工程地面作业实用词汇与短语方入：kelly-in方余：kelly-up开钻：spud in作业指令：instruction钻井设计：drilling program井身结构：well schematic岩性：lithology迟到时间：lag time(bottom up)换钻头：change bit甩钻具：laydown drill pipe发生故障：break down安装（拆卸）：rig up(rig down)接头：sub adapter机械手：mechanical arm铁钻工：iron roughneck有故障：It fucked up( something is wrong with it)已修好：it has been fixed马上去：Go there at once请下去：Please go down请上来：Please come up躲开，危险：keep away，danger.请翻译来：Ask interpretor come here，冲洗：wash down井口：well-head一根钻杆（单根）：single三根钻杆组合（立根）：thribble吊蓝：cage(basket)换班： shift change第5节钻井工程井口作业实用词汇与短语喇叭口：bell nipple出水管：mud return line(flow line)试压杯：cup tester小心滑倒：wet floor, be careful不要往井眼内掉东西：never fall down anything inside hole我来做：Let me do it带把板手来：Bring a spanner，please带点密封剂：Bring a little sealant(Teflon)，please很快就好了：lt will be finshed right away 抬一下：Let's lift it把绳子给我：Give me the rope，please不漏：no leakage电焊： welding气焊：gas welding 气割：gas cut栏杆：handrail，gangway rail，railing蒸汽：vapour压缩空气：pressurized (compressed) air注意安全：pay attention to safety别动：Don't move，Don't touch.对准：point out exactly.校正：align裸眼：open hole第四章：钻井液及相关设备第1节钻井液名称泥浆：mud钻井液：drilling fluid完井液：completion fluid修井液：work-over fluid压井液：killing fluid射孔液：perforating fluid隔离液：spacer fluid泥浆处理：mud treatment泥浆处理设备：mud treating equipment饱和盐水泥浆：saturated salt-water mud油基泥浆：oil-base mud高粘度泥浆：heavy viscous mud重泥浆：weighted mud重泥浆压钻杆：slug drill pipe起钻倒返泥浆：we have wet pipeduring POOH重晶石：barite纯碱：soda ash高岭土粉：koaline powder云母片： mica sheet增粘剂： viscosifier稀释剂： diluent (thinner)稳定剂： stabilizer (stabilizing agent)烧碱： caustic soda稀释dilution, thinning水泥凝固cement setting第2节钻井液设备离心泵：centrifugal pump振动筛跑泥浆：mud overflow shale shaker筛出：shake out混合泵：mixing pump混合漏斗：mixing hopper搅拌器：mud agitator泥浆抢：mud gun岩屑：cuttings沉淀：settle沉积物：deposit吸入：suction吸入罐：suction pit泥浆天平：mud balance游码：slide weight支点：fulcrum刀口：edge调整，校正：adjust粘度计：viscometer第3节钻井液处理剂包，袋：sack粘土：clay膨润土，般土：bentonite钠：sodium钙：calcium氯：chloride氯化钙：calcium chloride石棉：asbestos分散：dispersal表面活性剂：surface-active material铁络盐：lignite单宁：tannin羧甲基纤维素：carboxymethyl celluose CMC 木纤维：xylogen石灰：lime二氧化钙：calcium oxide粉末：powder薄片：flake溶解：dissolve延迟，妨碍：retard处理剂，添加剂：additives缓凝剂：retarder支撑剂：proppant乳化剂：emulsifier润湿剂：wetting agent稳定剂：stabilizing agent除钙剂：calcium remover降失水剂：filtration-reducing agentPH值控制剂：PH control additive润滑剂：lubricant消泡剂：defoamer agent破乳剂：emulsion breaker洗涤剂：detergent防膨胀剂：anti-swelling agent粘土稳定剂：clay stable agent稀释剂：thinner封堵剂：plugging agent抑制剂：inhibition agent暂堵剂：temporary plugging agent解堵剂：plugging removal堵漏剂：LCM (lost circulation material)水敏地层：water-sensitive formation分散：dispersal水泥浆：cement slurry流变性：rheological characteristics稳定性：stability稠化时间：thickening-time低密度水泥浆：low-density slurry油气层保护：reservoir protection高渗透性：high-permeability砾石：gravity悬浮：suspension固化：solidification.防膨胀：anti-swelling高凝高粘度：high condensation and viscosity无毒的：non-poisonous无荧光：non-fluorescence钻井液性能参数 Specificaitons of Drilling Fluid 含水：water content密度：density厚度：thickness粘度：viscosity塑性粘度：plastic viscosity含砂量：sand content屈服：yield屈服点：yield point屈服强度：yield strength剪切速率：shear rate剪切强度：shear strength剪切应力：shear stress稀释： dilute适用温度：safe temperature初始切力：initial gel strength 终切力：ten-min gel strength 触变性：thixotropy剪切稀释：shear thining液体浓度:concentration泥浆柱：mud column层流：laminar flow涡流：turbulent flow气泡：bubble第五章：钻井相关作业第1节取芯部分岩心：core取心钻头：core bit取心筒：core barrel内岩心筒：inner barrel外岩心筒：outer barrel岩心爪：core catcher取心工具：corehandling tools取心收获率：core recovery rate取样器：sample blob取样盒：sample box样品筒：sample chamber取样工：sample catcher取样间隔：sample interval井壁取心：side-wall coring井壁取心枪：side-wall coring gun取芯失败：coring failure第2节固井部分固井：cementing完井：well completion水泥：cement井口：wellhead井口压力：well head pressure井口回压：back pressure on the well head套压：casing pressure导管：conductor表层套管：surface casing技术套管：protective casing(intermediatecasing) 油层套管：production casing尾管：liner尾管悬挂器：liner hanger通径轨：rabbit封隔器：packer联顶节：landing joint套管柱casing string套管下部结构(含套管鞋、浮箍)：casing track(including casing shoe, float collar) 套管扶正器：centralizer止退环：stop collar口袋：pocket( rat hole)环空注水泥作业：top cement job碰压：bump plug隔离液：spacer分级箍：stage collar水泥粘结强度 strength of cement bond套管钳：casing tongs套管接箍：casing coupling套管头：casing head散装水泥：bulk-cement水泥浆：cement slurry插管注水泥：stab in cementing插入密封接头：stab in adapter分级注水泥：stage cementing先行水泥浆：lead cement slurry末端水泥浆：tail cement slurry促凝剂：accelerator替浆：displace with mud水泥面：top of cement固井管线：chicksan line(cementing line)灰罐：silo(bulk tank)候凝：WOC(wait-on-cement)挤水泥：squeeze cement水泥塞：plug第3节固井水泥浆名称和参数超细水泥浆：ultrafine slurry普通水泥浆：normal slurry纤维水泥浆：fiber-reinforced cement slurry膨胀水泥浆：expanding cement slurry低密度水泥浆：low-density slurry水泥体积收缩：cement volume contraction水泥浆水化期间：cement slurry hydrating period水泥胶结质量：cement sheath bonding quantity失水率：the rate of water loss析水：liberate water稠化时间：thickening time凝固强度：cementation strength渗透性：permeability，膨胀率：expansion rate压缩强度：compression strength流动性：mobility第4节测井部分电测：wireline logging测井解释：logging interpretation随钻测井：LWD(logging while drilling)测井电缆：logging cable测井工具：logging tool自然电位测井：spontaneous potential log感应电测井：induction electrical survey双感应测井：dual induction-laerolog中感应测井：medium induction log数字记录：digital record照相记录：photographic recording放射性测井：radioactivity log声波技术：acoustic wave technology仪器耐温：the temperature resistance of the instrument 仪器耐压：pressure resistance of instrument油气比：GOR (gas oil ratio)第六章：井下作业常用短语修井：work-over修井工具：work-over tool井下操作： down-hole operations.产层污染： pollution of pay zone增产措施：stimulations压裂和酸化：fracturing or acidizing酸化处理：acid treatment人工压裂： artificial fracturing重复压裂过程： repetition presses for fracturing，压裂车： fracturing truck sets压裂后反映： post-fracture response固体和液体添加泵： solid and liquid additive pump泵交联： pumping cross link交联剂： cross-linking agent排量： discharging三维压裂： three-dimension fracturing对压裂参数的监控、分析和解释：real time monitoring，analyzing and interpreting for fracturing operation parameters压裂操作：fracturing operation压裂规模：fracturing scale化学吞吐：chemical disposal乳化降粘：emulsification declining viscosity增注：augmented injection.注水：water-injection裸眼砾石填充完井：bore hole gravel packer completion.开窗铣锥：open-window mill prick，开窗斜向器：open-window inclined implement碳酸盐岩：carbonate reservoir第七章：海上钻井作业海上钻井：offshore drilling陆地钻井：on-land drilling海滩：sea beach浅海：shallow sea海底管线：sea-bottom pipe海底电缆铺设：setting cable under sea-bottom平台安装：platform installation钻井平台：drilling platform顺风：tail wind逆风：against the wind摄氏零下…度：below…degree centigrade启锚：weigh anchor抛锚：drop anchor拖航：drag对讲机：intercom，walkie-talkie上吊茏：Please get on the liftbasket救生衣：life jacket晕船：sea sick控制速度：Control the speed货已送抵：The goods has arrived货物验收：Please check and accept the good s在不远处：Not far from here不方便：lt's not convenient有危险：lt's dangerous防污染：prevent pollution没情况：Nothing happened.第八章：定向井部分定向井：directional well造斜点：ＫＯＰ（kick off point）最大井斜角：maximum hole inclination增斜段：building up section稳斜段：holding section降斜段：drop off section井眼尺寸：hole size长、中、段半径：long，medium and short radius裸井段：the open hole section水平段：horizontal section固井段：cementing section井斜角测量点：angle point水平位移：horizontal departure(displacement)井眼轨迹：wellbore trajectory优化控制：optimum control筛管：screen pipe长封固段固井：long intervals cementing丛式井：cluster well斜向器：whipstock第九章：石油现场机械传动与机械设备第1节：动力与传动柴油机：diesel发电机：generator直流（交流）电动机：DC（AC）motor交流电：A.C （alternating current）直流电：D.C （direct current）变压器：transformer传动轴：driving shaft从动轴：driven shaft空调机：air conditioner空气压缩机：air compressor应急发电机组：emergency generator消防水泵：fire pump配电间：distrubution room电动潜水泵：ESP(electrical submersible pump) 锅炉：boiler蒸汽：vapour气压不足：The airpressure is poor操作有问题：Operation is not good电压正常：Voltage is all right绝缘不好：The insulation is bad触电：electric shock温度太高：The tempreture is too high接地：ground 短路：short circuit按红色钮：Please push the red button打开：open，turn on，switch on关闭：close，turn off，switch off风扇：fan爬上去：climd up跳下来：jump down接住：catch it拿稳：hold tight平方米：square meter立方米：cubic meter加工：process三项交流电：three-phase AC气罐：air tank偶合器，联轴节：coupling链轮：sprocket链条：chain皮带：belt链条驱动：chain drive皮带驱动：belt drive第2节机械加工与设备对准，使…成一线：align周围的，环境的：ambient模糊，含糊，不明确：ambiguity退火的：annealed淬火：quench回火：temper阳极：anode阴极：cathode含水的，水的：aqueous装配：assembly增大，增加，增益：augment侧向间隙：back-lash电木，（绝缘）胶木：Bakelite批量生产：bulk production轴承：bearing锥齿轮，伞齿轮：bevel gear（刮刀，刃，叶片：blade坯料：blank吹风，爆炸，喷砂机：blast滑轮组：block and tackle浮子，摆锤：bob镗床，镗孔刀具：borer内孔加工，镗孔：boring瓶颈，薄弱环节：bottleneck平衡点，盈亏临界点：breakeven point型坯：briquette拉床，铰孔机：broacher拉削，扩孔：broaching大齿轮：bull gear碰撞，曲折，拐点：bump缓冲器，减震器：bumper擦亮，光亮：burnish去毛刺：burring凸轮，偏心轮：cam凸轮轴：camshaft铸造：cast触媒，催化剂：catalyst空化作用：cavitation内腔，空穴，（铸造）型腔：cavity陶瓷的，陶器的，陶瓷制品：ceramic铁屑，金属屑：chip凿子，扁铲：chisel钳：clamp障碍（物），阻塞（物）：clog离合器：clutch罗盘，指南针：compass凸型的：convex 凹型的：concave外形，轮廓；结构，构造：configuration锥形的，锥状的，锥体：conical传送装置，运输机，传送带：conveyor。
石油工程专业英语教学内容
第一章石油钻井工程英语基础第1节石油钻井工程基础词汇1.钻探，钻井：drill————拓展记忆钻井：drilling定向斜井directional drilling 欠平衡钻井under-balance 海上钻井off-shore陆地钻井on-land drilling 钻头：drill bit 刮刀钻头：drag bit 牙轮钻头rock bit金刚石钻头diamond bit 喷射钻头jet bit 钻铤drill collar 衣领collar钻杆：drill pipe 钻井队drilling crew 钻机drill rig 钻井泥浆drilling mud钻井液drilling fluid2.油，石油：oil————拓展记忆原有crude oil 石油petroleum 中国石油Petro-China 采油oil production采油设备oil production equipment 采油平台oil production platform 油泵oil pump3.地质：geology————拓展记忆地质专业人员geologist 物理physics地球物理勘探geo-physical probe，geo-physical exploration测井logging 测井作业logging operations 测井记录logging record4.油井：well————拓展记忆井眼hole 油井oil well 试井，油井测试well test 井下down-hole井下作业down-hole operation第2节石油钻井方法基础词汇原油crude oil 天然气natural gas 煤层气coal-bed gas 一体化设计integral design钻井drilling 钻井原理the principles of drilling顿钻钻井percussion drilling，cable-tool drilling 旋转钻井rotary drilling液体冲击fluid percussion 大位移big deviation侧钻井sidetracking drilling technology lateraldrilling水平井horizontal well 探井wildcat，wildcat drilling 深井deep well 浅井shallow well老井maturing well 欠平衡钻井under-balanced drilling 丛式钻井cluster drilling technology 煤层气井coal-bed gas well 生产井production wells 报废井abandon wells停产井non-production wells 绕障井、三维井three-dimensional wells常温井normal temperature well 注采井injection and production well 稠油井heavy oil well热洗井hot washing pipe 井况well condition石油钻井技术基础词汇技术规范，技术指标，技术性能：specification拉伸tension 拉伸强度tension strength 应力stress 压力pressure 应力点stress point压力等级pressure grade 压力降pressure drop 压力梯度pressure gradient回压back pressure 大气压atmosphere 压差differential pressure静液柱压力static fluid column pressure 特征characteristic，feature定性讨论qualitative argiment 定量使用quantitative use液体liquid 固体solid 气体gas，air 正的positive 负的negative虚线dashed line，broken line 实线full line 递减率decline rate 正比于be proportional to 水平的horizontal 垂直的vertical 油层静压the formation static pressure石油钻井参数基础词汇负荷load 扭矩torque 扭转twist 摩擦friction钻压WOB, weight on bit,weight, drilling weight钻速rate of penetration, drilling rate, the rate of drilling, average ROP 钻井周期drilling period 钻速rotary speed 地层压力预测formation pressure prediction technology地层快速预测the formation fast prediction 埋藏深度bury depth产油层，产油带，pay zone，productive formation温度梯度temperature gradient 地层压力formation pressure 坍塌压力collapse pressure破裂压力fracture pressure 平衡压力equilibrium pressure钻具（柱）压力drilling string pressure 钻头振动vibration of bit 钻井成本drilling costs井眼尺寸hole size，well size 参数计算parameters calculation几何参数geometric parameters 参数分析parameter analysis 动态参数dynamic data静态监测static data 注水参数parameter of injection 参数、变量variables 井距well space 垂直深度vertical depth 水平位移horizontal deviation 总深度total depth水平位移horizontal displacement 最大井斜角maximum hole inclination井眼环空annulus space 压力调节器pressure regulator 恢复（增加）压力the build-up pressure 初始开采primary recovery 含水地层water bearing formation 套管漏失casing leak摩擦损失friction losses 气聚阀gas-lift valve 石蜡族paraffin series含气液柱gas-laden column 增产措施stimulation treatment 流动能力flowing capacity生产速率production rate 水驱water drive 气驱gas drive 网状系统grid system水侵water influx 五点法five-spot pattern 油井产量well-productivity 径向流radial system 富气enriched gas 贫气lean gas 气顶gas cap 气驱gas drive（or gas flooding）水驱water drive (or water flooding) 地层伤害formation damage 波及系数sweep efficiency 泄油半径drainage radius 基岩处理matrix treatment 单级脱气single stage separation泄油面积drainage area 表面张力surface tension 束缚力connate water（or interstitial water）石油钻井作业现场工作人员名称1 钻井队drilling crew 队、组crew、team2 技术员technician 钻井技术员drilling technician 泥浆技术员mud technician3 监督supervisor 钻井监督drilling supervisor 副监督assisstant supervisor地质监督geology supervisor4 工程师engineer 泥浆工程师mud engineer 泥浆工mudman机械工程师mechanic engineer 引擎、发动机engine 工程engineering钻井工程drilling engineering 采油工程production engineering石油工程petroleum engineering 试油工程oil test engineering拓展记忆---------------------------工作项目project 希望工程the hope project 三峡工程the Three-Gorge Project项目经理project manager 工程管理project management 钻工：roughneck、floorman司钻driller 副司钻assistant driller 钻井队长drilling foreman 钻井领班tool pusher井架工derrick man 发动机工，机工motorman 钻台工floorman机械师technicians，mechanic 电焊工welder 电工electrician 医生doctor材料员material man，staff man 炊事员cook 翻译interpreter, tansalator洗衣工laundry man石油作业现场常用工具石油作业现场普通工具扳手wrench 螺丝起子screwdriver 多角螺丝起子Phlilips screwdriver活动扳手monkey wrench，adjustable 钳子pliers 手斧hatchet 钩子hook 台钳bench vice 榔头hammer 木锤mallet 搬手spanner 锯子saw 电动手锯jigsaw 电锯power saw钢锯hacksaw 硬尺rule 软尺tape measure 砂纸sandpaper 油漆paint 油漆刷paintbrush 绝缘胶布electrical tape 电线wire 插头plug 电插座outlet 开关switch 螺栓bolt螺帽nut 钉子nail 电钻electric drill 钻头bit 工作台workbench 工具箱toolbox胶水glue 交棒glue bar 管钳pipe tongs，pipe spanner，wrench链钳chain tongs，chain spanner，chain wrench护丝thread protector，screw protector手轮hand wheel 阀门搬手valve wrench，valve spanner 链接法兰coupling flange安全带safety belt 安全帽safety cap 工作靴working boots 千斤顶jack 吊车crane拖拉机tractor 推土机dozer 刮刀scraper1、石油作业现场专业工具接头sub 配合接头X-over，cross-over 提升短接lifting sub，lifting nipple elevator卡瓦slip 母锥box bell 公锥taper tap 短节joint 柔性短节flex joint 井口wellhead螺旋钻铤spiral collar 方钻杆kelly 钻杆架pipe rack 材料房warehouse 绳卡guy anchor 润滑器lubricator 维护保养maintenance 内钳lead tong 外钳back-up tong液压大钳hydraulic tong 兜绳mule line 四通阀four-way valve 软管hose球阀ball valve, globe valve 闸板阀ram valve, gate valve 增压泵booster pump换配件fittings change 灌注泵charge pump第二章石油工程常用设备及专业术语第1节钻井设备部分1 井架derrick 塔形井架derrick A形井架cantilever mast，mast-A 桅杆mast底座大梁sill 架，台rack 架工操作台monkey-board2 游动系统travelling systemn 天车crown block 天车梁crown block beam游动滑车travelling block 钻井大绳drilling line, wire line 金属线, 电线wire，line钢丝绳，测井电缆wire line 金属线，电线wire，line 钢丝绳股strand 截断cutoff滑车，滑轮，皮带轮pulley 吊耳eye plate3 大钩与水龙头hook and swivel 顶驱top drive 大钩hook 大钩弹簧hook spring大钩销子hook pin 大钩环hook ring 大钩锁紧装置hook locking device大钩悬挂高度hook height 水龙头swivel 鹅颈管gooseneck 冲管wash pipe水龙头盘根swivel packing 钻井水龙带drilling hose，rotary hose，kelly hose 立管stand pipe 高压管线high pressure line 低压管线low pressure line 放压管线relief line储气筒gas holder，air holder4 转盘rotary table 转盘方瓦master bushing 方补心kelly drive bushing方孔square openning 小鼠洞mouse hole 大鼠洞rat hole （井架大门处）坡板ramp5 绞车drawworks，hoist 液压绞车hydraulically-powered winch 气动绞车air operated hoist 绞车hoist，windlass，drawworks 滚筒线轴卷轴reel pool drum滚筒高速气离合器drum high air clutch 滚筒低速气离合器drum low high clutch猫头cathead 液压猫头hydraulic cathead 上扣猫头make up cathead卸扣猫头make out cathead 牙嵌离合器jaw clutch 应急牙嵌离合器emergency jaw clutch涡磁刹车eddy current brake 猫头轴cathead shaft 猫头绳cathead line猫头绳爪cat line grip 死绳dead line 死绳固定器deadline anchor死绳固定器膜片dead line diaphragm 上扣spin up，screw on 卸扣，卸开break out, screw off 上紧，固定tighten 松开，松扣loosen 加载load 卸载unload 拧紧screw 拧松unscrew 刹者brake 刹车总成brake assembly 刹车轴brake axle，brake shaft 刹车带brake band刹车片brake band lining 刹车杆brake bar 闸瓦brake block 刹把break crank，brake bar刹车鼓brake drum 离合器clutch 液压油箱hydraulic reservoir液动试压泵hydraulic test pump 液压大钳hydraulic tong 倒档齿轮reverse gear第2节钻井泵类及相关设备泥浆泵mud pump，drilling pump，slush pump 活塞piston 活塞杆piston rod活塞皮瓦piston cup 缸套liner，pumpliner 凡尔体valve body 凡尔座valve cup阀弹簧valve spring 阀杆valve lever 阀面valve face 阀帽valve bonnet泥浆泵安全阀mud relief valve 排出阀discharge valve 吸入阀suction valve潜水泵submersible pump 阀门valve 阀盖valve cap 阀座valve seat 回压阀回压阀back pressure valve 单向阀check valve single-pass valve 安全阀safety valve手动阀manual valve 液动阀hydraulic valve 冷缸cold cylinder 拉杆tie rod，tension bear 上水头intake，suction end 排出口discharge spout 高压管high pressure压力表pressure gauge 冲数strokes 排量displacement，discharge capacity，flow rate第3节井下泵类及相关设备泵筒pump barrel 柱塞plunger 关闭shut down 尾管tail pipe 抽油杆sucker rod长冲程long stroke 低泵速small pumping speed 泵充满度the fullness efficient of the pump 抽油杆sucker rod 排气方法gas bleeding method 泵效pump efficiency三维空间three dimensional space 有效生举efficient lift for the deviated抽油杆扶正工具sucker rod centralization tools 严重的管杆偏磨serious string partial wear游动阀the travelling valve 固定阀the standing valve 部分磨损、偏磨partial wear无杆泵rodless pump 小泵深抽small pump deep pumping technology挂泵深度pump setting depth 尾管长度length of liner 管柱结构the structure of pipe string防脱器dropout-prevent device 井斜角hole angle 电热杆borehole electric heating rod稠油开采heavy oil production 空心杆热载体hollow sucker rod heat carrier变扣器方补芯bushing 终端器terminal assembly 空心抽油杆hollow sucker rod整体电缆传感器continuous cable，sensor 空心光杆hollow polish rod 悬挂器hanger防喷盒stuffing box第4节采油设备采油树Christmas tree 抽油机pumping unit 往复运动reciprocating motion泵杆pumping rod 机械传动mechanical transmission 载荷能力peak polish rod load系统效率system efficiency 冲程stroke length 冲次frequency of stroke无级可调smooth regulation 沉降式抽油泵the sinking sand pump 泵下沉砂sinking砂颗粒sand particles 胶质沥青gum asphalt含蜡量paraffin content 凝固点solidification point 热流hot fluid 参水mingle water第5节与泵操作有关的使用短语没有压力no pressure 压力过高the pressure is too high 返回太少mud return is few水太少water is little 抢修rush to repair 请看记录please read the record没作记录no record 加化学小品put in chemicals 加高岭土粉put in koaline powder加云母片put in mica sheet 加增粘剂put in viscosifier 加稀释剂put in diluent（thinner）加稳定剂put in stabilizer（stabilizing agent）加烧碱put in caustic soda测定比重measure gravity，gravity test 测定失水test filtration 测定切力measure force开关switch 停泵stop the pump 请打手势please make a gesture转动一周turn round a circle 垫高一些put something under it to raise 抓紧firmly grasp抬高lift it up 拿稳hold firm 打一下strike once 往下拉pull out站稳stand firm take a firm hand 小端small end 大端large end 光滑smooth粗糙rough,coarse 平面plane，flat 弯曲winding，bending 放松loosen绷直stretch tight，draw tight 撬棍pinch bar，pry bar 充氨气nitrogen aeration 气包snubber 冷却cooling 润滑lubricate 过载overload 功率不足inadequate power，power is not enough第6节钻台与底座钻台drilling floor，derrick floor，rig floor 钻井记录drilling record司钻监视器driller’s monitor 司钻控制台driller’s console 指重表weight indicator转盘rotary table 卡瓦slip 吊卡latch elevator 底座substructure 井队活动房bunkhouse 钻台上值班房doghouse 立根盒setback （place）立根盒容量setback capacity井控设备well-control device第7节防喷器万能防喷器versatile blowout preventerBag type BOP单闸板防喷器single ram preventer 双闸板防喷器double ram preventer 闸板pipe ram全封闭式防喷器blind ram 蓄能器energy accumulator 压井管线kill line 入口inlet出口outlet 演习drill 消防演习fire drill 防喷演习BOP drill防腐涂料油管anti-corrosion coating material tubing 多功能管柱multi-function string第三章钻井工程作业部分第1节钻井事故泄漏leak 漏失fluid loss 出砂sand production 井喷blow out 井涌kick，flow off井漏lost of circulation，circulation lost坍塌，井壁坍塌caving，cave in，collapse出砂sand production，sand flow 桥塞bridge plug 砂桥sand bridge 井堵well clogging卡钻sticking 卡钻杆sticking the pipe 卡钻具sticking the drill stem 打捞fishing打捞工作fishing job 侧钻side-tracking 侧钻井眼sidetracking hole水泥窜槽cement channeling 固井失败cement failure 防砂sand control，sand-proof第2节钻头牙轮钻头rock bit，tooth-wheel bit 刮刀钻头drag bit 金刚石钻头diomand bit镶齿钻头tungsten carbide bit，insert bit 喷射钻头jet bit 铣齿钻头milled bit 牙轮cone钻头装卸器bit breaker 钻头直径bit diameter 钻头寿命bit life 钻头规格bit gauge钻头磨损bit wear 钻头型号bit type 水眼尺寸nozzle size 水眼效率nozzle efficiency钻头接头bit sub第3节钻具方钻杆kelly 方钻杆旋转短节kelly spinner 方钻杆考克（旋塞）kelly cock 接头sub钻头接头bit sub 钻具drill stem，drilling string 钻杆drill pipe 管子tube，pipe钻具组合drilling assembly 扶正器stabilizer，centering guide 翼状扶正器wing stabilizer扩眼器reamer drill collar 无磁钻铤drill collar 加重钻杆heavy weight drill pipe近钻头扶正器near-bit stabilizer 绕性接头flexible joint 震击器jar 减震器shock absorber 螺旋钻铤spiral drill collar 键槽破坏器key seat reamer 安全接头safety joint钻杆刮泥器drill pipe wiper 配合接头crossover sub 减震器shock sub井下钻具组合BHA-bottom hole assembly泥浆动力钻具mud motor 管线tubeline 钻柱drill string 涡轮tubine涡轮钻具turbo-drill stem 斜度taper，slope 塔式钻具tapered drill stem 接头 a joint，sub 管接头a joint of pipe 立根stand，a stand，thribble 加厚upset 内加厚internal upset外加厚external upset 内外加厚internal-external upset 丝扣thread 母扣box 公扣pin左旋螺纹left-hand thread 右旋螺纹right-hand thread 正规接头regular joint贯眼接头full hole joint 内平接头internal flush joint 护丝thread protector丝扣油thread dope，thread oil 打捞篮junk basket 打捞工具fishing tool打捞管柱fishing string 打捞公锥fishing nipple 打捞颈fishing neck 打捞头fishing head 打捞作业fishing operation 打捞母锥fishing socket 牙轮打捞器cone fisher倒扣工具reversing tool 卡瓦打捞筒slip socket 铣鞋milling shoe 铣具milling tool平底铣鞋flat bottom mill 磁力打捞工具magnetic fishing tool 套管打捞矛casing spear打捞矛fishing spear 打捞钩fish hook 套管打捞筒casing bowl 动力扳手power wrench动力大钳power tong 大钳活动牙块hinged jaw 大钳锁销latch 大钳悬臂suspension unit 气动工具pneumatic tool 打捞震击器fishing jars 打捞缓冲器fishing bumper sub打捞环die collar 打捞筒overshot 打捞短节junk sub 卡瓦slips 刮井器scatcher刮眼器扩井器wiper 油位检查丝堵oil lever check plug 油位oil lever油尺oil-lever dipstick 加油孔lubrication hole 盘根盒stuffing box 井筒工具well bore tool 配套工具matching tools 滚轮扶正器idler wheel centralizer 减磨短节friction reduction sub 轴线加压hydraulic thruster 扶正器centralizer 防脱器、装置anti-slip device减磨扭矩接箍torque-reduction sub 减扭接头torque reduction sub轴向水力加压工具hydraulic thruster 下套管漂浮接箍casing floating coupling轴向加压器hydraulic thruster第4节钻井工程地面作业实用词汇与短语方入kelly-in 方余kelly-up 开钻spud in，starting drilling 作业指令working instruction起钻POOH=pull out of the hole 下钻run in the hole 起下钻make a trip 短起下钻short trip 通井wiper trip 起下循环一周round a trip 循环时间round time，circulating time换钻头change bit 甩钻具laydown 填井pack-hole封井packed drilling发生故障break down 接单根connection 放卡瓦set slip，setting slip，起卡瓦pull slip扩眼openning 划眼reaming 二层台double monkey board，runround 顶部驱动器top drive 吊环bail 吊卡elevator 安全卡瓦safety slips 接头sub adapter 短节sub substitute井下震击器downhole（bumper）jar，down well shaker 打捞工具fishing tool三片卡瓦three slips，three pieces 补芯bushing 方补芯kelly drive bushings转盘补芯（大方瓦）rotary drive bushing 转盘刹车rotary brake 丝扣油thread lubricant oil 刹把brake crank，brake bar，brake lever 脚踏开关pedal switch 挂档put into gear拉猫头cathead 内钳back-up tongs 外钳lead tongs 气动大钳pneumatic tongs 液压大钳hydraulic tongs 机械手mechanical arm 铁钻工machine hand 司钻房driller room有故障it has broken down, it has something wrong 已修好the breakdown has been fixed马上去go there at once 请下去please go down 请上来please come up躲开，危险get out，danger 请翻译来ask the interpretor to come here 冲洗flushing井口well-head（well head）井下落物fish 一根钻杆（单根）single（pipe）三根钻杆组合（立根）thribble 甩单根breaking down 接单根make a connection气动绞车pneumatic drawworks 吊篮basket 卡子clamp 绳套rope sling loosening紧固tightening 挪开move it off 换班change，shift 保养设备maintain equipment钻井日志boring journal，boring log 油管悬挂器tubing hanger第5节钻井工程井口作业实用词汇与短语喇叭口bell mouth，flare opening 贮能器accumulater 液压阀hydraulic valve液压管hydraulic hose 阻流管choke line 井控管汇well control manifold泄压阀pressure relief valve 调压针阀pressure regulating needle valve回压阀backpressure valve 井口螺丝the bolt of wellhead 井口绞车well head drawworks水刹车water brake，hydraulic brake 电缆（electric）cable 井口压力wellhead pressure隔水导管conductor riser 小心滑倒Guard against slipping 不要掉下去Take care not to fall down 我来清理let me clean up 带把扳手来bring a spanner，please 带把铁锤来bring a hammer，please. 带点密封剂bring a little sealant，please 带个密封圈bring a sealing washer 用起子撬prize with （using）screwdriver 用手推注push by hand 卸下来了it has been removed off 装配好了it has been assembled 很快就好了it will be finished right away抬一下let’s lift it 上紧螺丝tighten the screw loosen 松开螺丝loosen the screw把绳子给我give me the rope，please 把绳子拿走take the rope away。
钻井平台英语(石油专业英语)
Rig position 钻井平台岗位assistant driller assistant supervisor 副钻副监督casing crew 套管队cementer 固井人员cementing engineer chief supervisor 固井工程师总监chief electrician 电气师chief engineer 轮机长chief mechanic chief repairman 机械师检修长chief roustabout / boatswain 水手长cleaning man 清洁工company man completion supervisor 甲方人员完井监督cook 厨师cooking crew 炊事班crane operator 吊车司机day/night supervisor deck manderrick man directional engineer directional operator 白班/夜班监督甲板工架工定向井工程师定向井技师driller 司钻drilling crew 钻井班drilling engineer 钻井工程师drilling supervisor 钻井监督electrician floorman geology supervisor geoservices man 电工钻工地质监督气测人员head cookhydraulic pressure man 厨师长液压工lathe man 车工laundry man 洗衣工logger 测井人员logging engineer material engineer material man 测井工程师材料师材料员mechanic 机械工mess boy 厨工motor man 机工mud man mud supervisor person on duty 泥浆工泥浆监督值班人员radio operator repairman 电报员大班rig manager 平台经理roustabout 水手senior tool pusher service provider 高级队长服务人员tool pusher trainee 队长实习人员welder 电焊工Unit & Conversion 单位及换算1.length light-year (km) 长度光年kilometer (km) 千米meter (m) 米decimeter (dm) 分米centimeter (cm) millimeter (mm) 厘米毫米yard (yd) 码foot (ft) 英尺inch (in.) 英寸mile 英里nautical mile (n mile) 海里1 m = 3.281ft = 1.094 yd1 ft = 12 in. = 0.305 m1 in. = 25.4 mm1 mile = 1609.344 m1 n mile = 1852 mbit diameter 钻头直径bit footage 钻头进尺bit position 钻头位置casing size 套管尺寸hole size 井眼尺寸hook position 大钩位置kelly - down/in depth 方入深度kelly - up 方余mean sea level 平均海平面mean tide level 平均潮面nozzle size 水眼尺寸2.area 面积square meter (m2) foot (ft2) 平方米平方英尺1 m2= 10.764 ft23.volume 容积cubic meter(m3) foot (ft3) 立方米立方英尺liter (l) 升barrel (bbl) (美)桶gallon (gal) (美)加仑pint (pt) (美)品脱quart (qt) (美)夸脱1 m3= 6.290 bbl1 L = 0.264 gal1 bbl = 158.988 L = 42.02 gal1 gal = 4 qt = 8 pt1 qt = 0.946 LHow much mud is there in mud pit 3? 3号池有多少泥浆？There is 400 bbl of mud in pit 3. 400 桶。
石油工程专业英语单词总结
3-D seismic survey (D: dimension:) 三维地震勘探5-spot pattern n.五点井网Abandon v.（油井）报废，废弃Abandon well n.废井Acid wash n.酸洗Acidization n.酸化（作用）Acidize v.酸化Additive n.添加剂Agent n.试剂，媒介Alkane n.烷烃，链烷烃Analytic solution n.解析解Anisotropic a.各向异性的，非均质的Annular a.环形的Annular mist flow n.环雾流Annulus n.环形空间，环空Anticline n.背斜API standards n.美国石油协会标准Aromatic n.芳香族，a. 芳香的Artifical lift n.人工举升Artificial water drive n.人工注水驱Asphaltene n.沥青烯Associated a.伴生的Attribute n.属性，特征，标志Baffle n.隔板；v.阻碍，挫折Barefoot completion n.裸眼完井Barite n.重晶石Barrel n.桶Barrier n.隔层Bbl (blue barrel) Bean n.油嘴，节流器Belt cover n.皮带盖Bentonite n.膨润土，斑脱岩Bit n.钻头Black-oil simulator n.黑油模拟器Blender truck n.混砂车Blow out v.井喷Blowout n.井喷Blowout preventer (BOP) n.防喷器Borehole n.井眼Bottom hole n.井下Collapse v.坍塌，倒塌Collar n.钻铤Compaction n.压实作用Completion n.完井，完成，结束Compress v.压缩Compressor n.压缩机Concentration n.浓度；集中Condensate n.凝析油Conductor casing n.导管Conductor hole n.导管孔Conductor pipe n.导管Cone n.圆锥，（锥形）牙轮Configuration n.构造Connate a.原生的，共生的Connate water n.原生水，共生水Contaminant n.杂质，污染物Continuous lift n.连续气举Core n.岩心Core holder n.岩心夹持器Core slug n.岩心塞Coring bit n.取芯钻头Corrode v.腐蚀Corrosion n.腐蚀Corrosive a.腐蚀的；n.腐蚀剂Counterbalance n.平衡（块）；v.使平衡Diesel n.柴油机，内燃机Counterweight n.平衡块Crack v.裂开Crank n.曲柄，摇把Crown block n.钻台Crumble v.坍塌，破碎Crust n.地壳Curve n.曲线Cutting/chips n.钻屑Darcy’s law n.达西定律Defoamer n.除泡剂Degas v.脱气Dehydrate v.脱水Dehydration n.脱水，去水Delta n.三角洲Demulsified n.破乳剂Deposit v.沉积，存款（withdraw）Derrick n.井架，钻塔Derrick floor n.钻台Desalt v.除盐Desalter n.脱盐剂Desand v.除砂Desander n.除砂器Descale v.除垢Desilter n.除泥器Development well n.开发井Deviate v.偏移，偏差Deviated well n.斜井Diamond n.金刚石Diffusivity n.扩散率，扩散性，扩散系数Dimension n.量纲，因次，维，元Dimensional a.量纲的，维次的Directional well n.定向井Discharge line n.排出管线Discount factor n.折现系数Discount rate n.现贴率Displacement n.驱替，取代，排出量Displacement efficiency n.驱替效率Displacement fluid n.顶替液Displacement pressure n.排驱压力Dissolve v.溶解，解除；无效Dissolved gas n.溶解气Doghouse n.井场值班房Dolomite n.白云岩Downhole n.底部井眼，井下Downstroke n.下冲程Dozer n.推土机Drainage n.排驱，排水Drainage area n.供油面积，泄油面积Draw works n.绞车Drillfloor n.钻台Drilling line n.钻井钢丝绳Drilling mud n.钻井泥浆Drilling string n.钻柱Drill-stem test (DST ) n.中途试井Droplet n.微滴，小滴Dynagraph card n.示功图Effective permeability n.有效渗透率Elevate v.提升，升华Elevation n.海拔，上升，举起Emulsified acid n.乳化酸Emulsifier n.乳化剂Emulsion n.乳化；乳状液Emulsion breaker n.破乳剂Encroachment n.侵入，水侵Engine oil n.机油Engine system n.动力系统Enhance v.提高，改善Enhanced recovery n.强化采油，提高采收率Ester n.酯，酯类Ethane n.乙烷Exploitation n.开发Exploration n.勘探Exploration well n.探井Fall-off test n.（注水井）压降试井Fatty a.脂的，脂肪的Fault n.断层Fine n.细砂Fingering n.指进现象Fitting n.配件；油嘴；适合Five-spot n.五点井网Flood front n.注水前缘Flow nipple n.节流嘴，油嘴Flow pattern n.流型Flow rate n.产量Flowing well efficiency n.流动系数Flowmeter n.流量计Foam n.泡沫Fold v.褶皱，折叠Formation n.地层Formation gas oil ratio n.地层气油比Formation transmissibility n.地层传导率Frac pumper n.压裂泵车Frac sand n.压裂砂，支撑剂Fraction n.馏分；分数Fracture v. & n. 裂缝Freshwater n.淡水，清水，新鲜水Friction reducing additive n.降阻剂Fuel storage n.燃料罐FVF(formation volume factor) n.地层体积系数Gas cap n.气顶Gaseous a.气体的，气态的，空虚的Gas-in-place n.天然气地质储量Gasoline n.汽油Gathering system n.集输系统Gear reducer n.齿轮变速器Geometry n.几何形态，几何学Geophysical well logs 地球物理测井Gravel n.砾石，砾砂Gravel pack n.砾石充填Gravitational drainage n.重力排驱Grease n.润滑油Gross thickness n.总厚度Gush v.井喷Gusher n.井喷Hardness n.硬度，硬性Heterogeneity n.不均匀，复杂性Hoist v.提升，轮换，改变Hoist system n.提升系统Hook n.大钩Hose n.水龙带Hydraulic fracture n.人工裂缝，水力压裂裂缝Hydraulic fracture n.水力压裂裂缝Hydraulic fracturing n.水力压裂Hydrocarbon n.烃类，碳氢化合物Hydrogen sulfide n.硫化氢Hydrogen sulphide n.硫化氢Identified crude oil reserves n.探明地质储量Impermeable a.不渗透的（与permeable相对）Impurity n.杂质，夹杂质混合物In situ n.（拉丁语）就地，原地Infill drilling n.加密钻井Influx n.流入，注入，主入口Inject v.注入Injectivity n.注入能力，注入性Injectivity index n.注入指数Inlet n.进口，输入（量）In-situ combustion n.火烧油层Interference test n.干扰试井Intermediate casing n.中间套管Intermittent a.间歇的，中断的Intermittent lift n.间歇气举Internal rate of return n.内部收益率Interval n.间隔，层段；隔层Irreducible a.不可减少的，剩余的Irreducible water/oil saturation n.束缚水/残余油饱和度Jack up v.举高，顶起Junk n.废料，井下金属碎屑Kelly n.方钻杆Kelly bushing n.方钻杆补心Kerosene n.煤油Kick n.井涌；v.踢Layer zone n.产层Leak v.滤失Leakage / leak-off n.滤失Limestone n.石灰岩Liner hanger n.尾管悬挂器Liner n.筛管，尾管Liquefy v.液化；稀释LPG (liquefied petroleum gas) n.液化气Lubricant n.润滑油Magnesium n.镁Make a trip 起下钻Manifold a.多方面的；n.汇管Marine a.海相的，海上的Mast n.桅杆式井架Masterbushing n.转盘方瓦Matrix n.基质MEOR (microbial enhanced oil recovery) Methane n.甲烷Microbial a.微生物的Milli-Darcy n.毫达西（渗透率单位）Mine v.开采矿物Mineral n.矿物Miscibility n.混相能力Miscible a.混相的Miscible flooding n.混相驱Mist n.雾Mobility n.流度Mobility ratio n.流度比Monkey board n.二层平台Mud acid n.土酸Mud cake n.泥饼Mud engineer n.泥浆工程师Mud gas separator n.泥气分离器Mud house n.泥浆房Mud logger n.录井员Mud n.泥浆，淤泥Mud pit n.泥浆池Mud pump n.泥浆泵Mud scale n.泥浆比重计Multiple-well test n.干扰试井Natural flow n.自然流动，自喷Natural gas liquids n.凝析油Nodding donkey/horsehead n.驴头Non-associated natural gas n.非伴生天然气Normal fault 正断层ODP (offshore drilling process) n.海洋钻井程序Offshore n.海上，近海Oil film n.油膜Oil patch/field n.油田Oil string n.油层套管，生产套管Oil zone n.生产层Oil-bearing 油层；含油的Oil-in-place n.地下原油储量Onshore a.陆地的，陆上的Open-hole n.裸眼Open-hole completion n.裸眼完井Original oil in place n.原始地质储量Originate v.起源，发起（接from）Outcome n.产量Outcrop n.露头Outlet n.出口，输出（量）Overbalance n.过平衡，正压Overbalanced drilling n.过平衡钻井Overlay v.上覆Oversaturated oil 过饱和油Packer n.封隔器Packer-bridge n.桥堵Pad fluid n.前置液Paraffin n.链烷烃，石蜡族；煤油Particle n.微粒，粒子Pattern n.井网；模式Pattern type n.井网类型Pay zone n.生产层Payout time n.偿还期PDC bit (polycrystalline diamond compact bit ) Penetration n.穿透；吃入（钻头对岩层）Pentane n.戊烷Perforate v.射孔，穿孔Perforated a.射孔的，带孔的Perforated completion n.射孔完井Perforation n.射孔Perforation interval n.射孔井段Permeability n.渗透率Permeable a.可渗透的Petrochemical n.石油化学Phase n.相；阶段Pig n.清管器Pig receiver n.收球装置Pig sender n.发球装置Pile driver n.打桩机Pipe rack n.管架Pipeline n.管道，管道输送Pipeline system n.管网系统Pipework / pipeline n.管网，管道工程Piston n.活塞Pit n.坑，窖，泥浆池Pitman n.连杆Platform n.钻台Plug v.堵；n.旋塞，岩塞，段塞Plunger n.柱塞Pneumatic a.空气的，风力的；气体的Pneumatic/air drilling n.风钻，空气钻井Polish rod n.光杆Polymer n.聚合物Porosity n.孔隙度Porous a.多孔的，空隙的Porous media 多孔介质Portable rig n.轻便钻机Potentiometric model n.电位模型，等势模型ppm (parts per million ) n.百万分之几Preflush n.前置液Present worth index n.现值指数Present worth n.现值Present worth net profit n.现值净收益Pressure buildup n.压力恢复Pressure build-up test n.压力恢复试井Pressure drawdown n.压力降落Primary pore n.原生孔隙Primary recovery n.一次采油Prime mover n.电动机，马达Production battery 集油站Production casing n.生产套管Production decline 产量递减Production facility 生产设备Production gain 增产油量Production horizon 生产层位Production interval 生产层段Production liner n.生产尾管Production logging 生产测井Production operation 采油作业Production rate n.采油速度，产量Production seismology 开发地震Production watercut 产液含水率Production well n.生产井Production zone n.生产层Productive a.生产的，产油的Productivity n.生产能力，产能Productivity index n.采油指数Profitability index n.赢利指数Profit-to-investment-ratio n.利润投资比Propane n.丙烷Proppant n.支撑剂Pull rod/sucker rod /sucker pole n.抽吸拉杆Pulse test n.脉冲试井Quaternary a.第四的，第四次的Quaternary recovery n.四次采油Ram n.柱塞；防喷器芯子Recoverable reserves n.可采储量Recycle v.再循环Reel n.卷轴，滚筒；卷缆车Refine v.炼制，提纯Refinery n.炼油厂Refinery n.炼油厂Reinject v.回注Reperforation n.补孔，再射孔Reserve n.储量Reservoir n.油藏，水库Reservoir management n.油藏管理Reservoir performance n.油藏动态Residual a.残余的，剩余的Residual oil saturation n.剩（残）余油饱和度Resin n.树脂，松香；v.涂树脂Respirator n.防毒面具，口罩Return line n.上返管线Rig n.钻机Rock layer n.岩层Rocking ram n.摇臂Rod pump n.有杆泵Rotary a. 旋转的，循环的Rotary drilling n.旋转钻井Rotary table n.转盘Rotating system n.旋转系统Saddle bearing n.支架轴承Safety slip n.安全卡瓦Saline a.含盐的；n.盐水Saline lake n.盐湖Saline water n.盐水Salineness n.含盐度，含盐量Salinity n.盐度，盐性，矿化度Samson posts n.支架Sand carrier n.携砂液Sand control n.防砂Sand cutting n.砂蚀，砂屑Sand truck n.砂罐车Sandstone n.砂岩Sandup n.砂堵Saturate v.饱和Saturation n.饱和Scale n.刻度，温标；水垢Screen n.筛网Secondary recovery n.二次采油Sediment v.沉积，沉积岩Sedimentary a.沉积的Sedimentary basin n.沉积盆地Sedimentary rock n.沉积岩Separator n.分离器Shale shaker n.泥浆振动筛Shaped charges n.聚能射孔弹Shut-down n.关井，停机Shut-in n.关井Simulate v.模仿，模拟，使模型化Simulation n.模型，模拟，模型化Simulator n.模拟程序，模拟器Skin factor n.表皮系数Slant hole /inclined well n.斜井Slip n.滑；卡瓦Slippage effect n.滑脱效应Slug n.段塞Slug flow n.段塞流Slurry n.水泥浆Slurry fluid n.携砂液Soluble a.可溶的，能溶的；可解决的Solution n.溶解作用Sort v.分选，排序Sour gas n.含硫天然气Spud in v.开钻Standing valve n.固定阀STB(stock tank barrel) n.储罐桶数Steam drive n.蒸汽驱Stimulate v.（油井）增产，（水井）増注Stimulation n.增产措施；増注措施Storage n.储存，储备Strata n. (pl.) 地层Stratigraphic a.地层的，地层学的Stratum n.层，岩层；地层Stroke n.冲程Structure fault trap 构造断层圈闭Stuffing box n.盘根盒Substructure n.井架底座Sucker n.吸入泵，吸管，吸入活塞Sulfide n.硫化物Sulfur n.硫Supersaturated a.过饱和的Surface casing n.表层套管Surface tension n.表面张力Surfactant n.表面活性剂Suspending agent n.悬浮剂Sweep efficiency n.波及效率Sweep v.扫油，波及Swivel n.旋转接头，（钻井）水龙头Syncline n.向斜 anticline 背斜Tectonic a.构造的，构造学的Tectonic plate n.构造板块Tertiary recovery n.三次采油Throat n.喉道，咽喉Throttle v.节制，调节，n.节流，节流阀Throttle valve n.节流阀Throughput n.生产量，生产率Thrust fault 逆断层Tortuosity n.迂曲度，弯曲度Tortuous a.弯曲的Toxic a.有毒的Tractor-trailer n.牵引拖车Trap n.圈闭Traveling block n.游动滑车Traveling valve n.游动阀Tricone bit n.三牙轮钻头Trip out v.起出（钻具）Truck-mounted rig n.车载钻机Tubing n.油管Underbalance drilling n.欠平衡钻井Undersaturated a.不饱和的Undersaturated oil 不饱和油Unemulsified a.非乳化的Upstroke n.上冲程V-door ramp n.斜坡Viscosity increasing agent n.增粘剂Viscous a.粘性的，粘稠的Void n.空隙，孔隙；a.无效的，空白的Walking beam n.游梁Wash-out n.冲蚀；清洗Water cut 含水率Water encroachment n.水侵（量）Water flooding n.水驱Water influx n.水侵量Water tank n.水罐Water-free a.不含水的，无水的Water-in-oil n.油包水乳状液Water-oil contact n.油水界面Wax n.蜡；a.蜡状的Wear out v. 磨损，磨坏Well pattern n.井网Well rate n.油井产量Well testing n.试井Wellbore n.井眼，井筒Wellhead n.井口Well-sorted a.分选好的Wildcat n.干井，初探Wire-wrapped screen completion n.绕丝筛管完井Wire-wrapped screen n.绕丝筛管Withdrawal rate n.产量Workover n.修井Workover operation n.修井作业Yield n.产量Viscosity n.黏度。
钻井工程英语：The Rotary Drilling Rig
6. Well Monitoring system
Safety requires constant monitoring of the drilling process. If drilling problems are detected early remedial action can be taken quickly, thereby avoiding major problems. The driller must be aware of how drilling parameters are changing (e.g. WOB, RPM, pump rate, pump pressure, gas content of mud etc.). For this reason there are various gauges installed on the driller’s console where he can read them easily.
Prime movers
SCR system
4
1.Power plant and transmission system
Electric transmission
Mechanical transmission
5
2.Hoisting system -Draw works, derrick, crown block, traveling block and drilling line.
17
Duplex double-acting pump
Triplex single-acting pump
18
desilter desander
Mud flow
Shale shaker