【包装印刷造纸】造纸词汇

制浆工艺impregnator预浸器refiner盘磨机preheater预加热器pre-steaming bin预蒸仓heat recovery热回收thickner浓缩机Twin-Roll Press双辊挤浆机Thickening浓缩HC-bleaching高浓漂白Reject chest渣浆池Reject refiner渣浆池Screw drainer螺旋卸料器Plug screw feeder料塞螺旋喂料器Primary screen一段筛Stator plate定盘Standpipe立管Flat zone平盘区Blow line喷放管线Pressure cyclone压力旋风分离器Gravity重力Impurity杂质Extractive抽取物Manganese锰Equalizing bin匀料仓Rotomixer转子混合器Bleaching liquor漂液Disc screen盘筛Level indicator液位指示器Metering screw计量螺旋Gyratory screen旋筛Reclaim卸料Screw feeder螺旋喂料器Distallition蒸馏Shive纤维束Barometric leg水腿Filtrate滤液White water chest白水池Dewater脱水Pressurized preheating常压预加热Single-disc refiner单盘盘磨机Latency潜能Preheater加热器Double-disc refiner双盘盘磨机Load split荷载分配Coarse fiber粗纤维Reject浆渣Single-stage refining一段磨浆Pilot scale中试厂Energy consumption能耗Tear strength撕裂强度Retention time滞留时间Overpressure超压Lamella薄片Fiber wall纤维墙Compressed steam压缩蒸汽Soft fiber软纤维Moisture content水份Softness柔软度Toughness硬度Tensile index抗张指数Tear index撕裂指数Light scattering光散射系数Bulk松厚度Yield得率Standard newsprint 标准新闻纸Improved newsprint改良新闻纸Saturated steam饱和蒸汽Suspended solid悬浮物Effluent treatment污水处理Dew point露点Screen basket筛鼓Fastening bolt 坚固螺栓Stuffing box填料箱Inspection hatch检查孔Hub轮毂spherical thrust roller bearing球墨止推滚柱轴承fastening screw紧固螺丝friction force摩擦力valve tray 填料方式bubble cap汽泡盖sieve tray滤网盘downcomer下导管weir堰板volatile component挥发元素Gap clearance盘隙Refining intensity磨浆强度Centrifugal force离心力Drag force拖拉力Residence time停留时间Long fiber content长纤维含量Conical refiner椎形盘磨机Breaker bar破碎棒Hydrogen peroxide过氧化氢Sodium hydroxide氢氧化钠Sodium silicate硅酸钠Sodium sulfite亚硫酸钠Hydrosulfite次硫酸钠transducer传感器thermometer温度计neutral point中性点dynamic balance动态平衡Short circuit current短回路电流The related vocabulary for A package (A包相关词汇)Approach flow system流送系统disc filter多盘Thick stock screening浓浆筛选super clear filtrate超清滤液Fiber recovery纤维回收clear filtrate清滤液Cleaner除砂器cloudy filtrate浊滤液Flying wing Deculator cord packing盘根with cleaner 飞翼式除气器 double suction pump双吸泵Headbox 流浆箱make-up water补充水Wire pit 机外白水槽accept良浆Condenser冷凝器reject尾渣Vacuum pump真空泵interface衔接Centrifugal pump离心泵sight glass视镜Diagram pump隔膜泵votex nozzle涡流喷嘴Screw pump螺杆泵throttling valve节流阀Displacement pump置换泵recovered fiber回收纤维WW channel白水方管NBKP漂白针叶硫酸盐浆Dilution headbox screen稀释水筛BCTMP漂白化学热磨机械浆HB screen纸机筛poplar pulp杨木浆Broke thickener chest损纸浓缩浆池sweetener垫层浆Dry broke intermitted chest干损纸中间浆池DIP脱墨浆Silencer消音器broken损纸Seal pit水封池dilution water稀释水Manifolds上浆总管sealing water密封水Separator分离器defibrination纤维疏解Vibrations sensor振动传感器oscillating shower摆动喷淋FC motor变频电机flow sheet流程图Dosing chest配浆池emergency stop急停Mixing chest混合浆池manufacturing drawing制造图Machine chest抄前池foundation drawing基础图Stuffing box填料箱reference drawing参考图Header总管functional diagram功能图Distribution pipe布浆管interlocking diagram连锁图Deflector 导流板over flow溢流Suction side引程侧solid content固含量Head扬程buffer缓冲器Counter flange配对法兰furnish配比Anchor bolt地脚螺栓magnetic flow-meter电磁流量计Slid rail 滑轨periodical variation周期波动Tensioning equipment张紧装置random variation随机波动Wall ring大法兰（墙环）fiber orientation纤维定向Motor stand电机座scaling结垢Fastening element紧固件pressure pulsation压力脉冲Steam heater蒸汽加热器flow evenness均衡流量Plug flow滞流short circulation短循环Transition flow过渡流(混流) air pocket气袋slime腐浆turbulence flow紊流(湍流)Medium-consistency storage tower中浓储浆塔plunger pump潜水泵部分造纸术语：grade 纸种grammage 定量width on reel 卷取纸幅宽coating weight 涂布量moisture before coating 涂前水份moisture on reel 卷取水份steam pressure 蒸汽压力steam consumption 蒸汽灌消耗量wire speed 网速press speed 压榨速度reel speed 卷取速度furnish 浆料配比Temp.in HB 流浆箱浆料温度press data 压榨数据supplier 供应商installed date安装日期days running运行天数style型号basis weight克重tension张力felt width on stretcher张紧辊上毛毯宽度stretched/stretch to go张紧辊张紧位置uhle box 毛毯真空箱vaccum真空度air velocity空气流速vacuum system 真空系统edge shower边缘喷淋水lubrication shower低压润滑喷淋水HP shower高压喷淋水moisture profiles水份图像moisture point measurements水份测量点absorption capability透水度常用高得率浆中英文对照SGW (Stone Ground Wood) 磨石磨木浆PGW (Pressurized Ground Wood) 压力磨石磨木浆TGW (high Temperature Ground Wood) 高温磨石磨木浆RMP (Refiner Mechanical Pulp) 盘磨机械浆TMP (Thermo-Mechanical Pulp) 预热盘磨机械浆CMP (Chemi-Mechanical Pulp) 化学盘磨机械浆CTMP (Chemi-Thermo-Mechanical Pulp) 化学预热机械浆APMP (Alkaline Peroxide Mechanical Pulp) 碱性过氧化氢化学机械浆SCMP (Sulfonated Chemi-Mechanical Pulp) 磺化化学机械浆BMP (Bio-Mechanical Pulp) 生物机械浆SEP (Steam Explosion Pulping) 蒸汽爆破法制浆EMP (Extruder Mechanical Pulp) 挤压法机械浆SCP (Semi-Chemical Pulp) 半化学法浆NSSC (Neutral Sulphite Semi-Chemical pulp) 中性亚硫酸盐法半化学浆ASSC (Alkaline Sulphite Semi-Chemical pulp) 碱性亚硫酸盐法半化学浆各种缩写：AA = atomic absorption原子吸收ABS = acrylonitrile－buladrene styrene丙烯腈—丁；烯—苯乙烯ACAR = angular correlation of annihilation radiation消除辐射的角相关性AM = acrylamide丙烯酰胺AOX = adsorbable organic halides可吸附的有机卤化物AP = plkali pulp碱法纸浆APAM = anionic polyacrylamide阴离子型聚丙烯酰胺ASB = aerotion stabilization basin稳定曝气池AST = activated sludge treatment活性污泥处理BBCT = best convential pollutant cotrol technology最常用污染物控制技术BDMT = bone dry metric tons绝干公吨BME = bipolar membrane electro dialysis两极膜电透析BMP = best management practices最优管理实践BOD = biochemical oxygen demand生化耗氧量BP = boiling point沸点BPK = bleached papergrade kraft and soda(生产)白纸用硫酸盐和荷性纳法浆BPT = best practicable control technology最佳实用控制技术BTU = british thermal unit英热单位BW = basis weight定量CCAD = computer aided design计算机辅助设计CBLI = chemistry－based leak indicator化学(法)示漏器CC = consistency controller浓度调节器CFD = computational fluid dynamics计算流体动力学CI = colour index比色指数= cofidence interval置信区间CL = colored ledger彩色底板CLSM = confocal laser scanning microscopy共焦激光扫描显微镜CMC = carboxy methylated cellulose羧甲基纤维素COMS = compliance optimization modeling system寻优模型系统CP = chemical pulp化学浆= chemical pure化学纯CPPC = coordinated phosphate/pH chemistry controller配位磷酸盐/pH 调节器CR = consistency regulator浓度调节器CRP = chloride removal process氯化物排出法CSD = condensate steam distillation column冷凝汽馏塔CTMP = chemical treatment in terms of sulphonation硫化期间的化学处理= chemithermomechanical pulp化学热磨机械浆CTU = centigrade thermal unit公制热量单位CV = coefficient variation偏离系数= crystal violet结晶紫DD = dioxide二氧化物DAF = dissolved air floatation(溶)气浮DCS = dissolved and colloidal substances溶解与胶态物= distributed control system集散控制系统DELS = Doppler electrophoretic light scattering多普勒电泳光扫描DIP = deinked pulp脱墨纸浆DKP = deinked kraft pulp脱墨牛皮纸浆DLK = double－line clippings双线限位DMS = dynamic mechanical spectroscopy动力谱学DMSO = dimethyl sulfoxide二甲亚砜DMT = dimethyl terephthalate对邻苯二甲酸二甲酯DO = dissolved oxygen溶解氧DP = degree of polymerization聚合度DSC = differential scanning calorimetry微分扫描量热法DVC = digital valve controller数字伐控制器EEC = embedded costs插入成本ECF = elemental chlorine free无元素氯(漂白)EDTA = ethylene eiamine tetraacetic acid乙二胺四乙酸EPC = experimental prismatic calcite实验棱镜方解石ERV = estimated replacement value预计取代值ESP = electrostatic precipitator静电滤尘器= emergency shutdown procedure事故停机程序EVA = ethylene vinyl acetate乙烯乙酸乙烯酯ESPRA = empire state paper research associates国立造纸研究会EVOH = ethylene－vinyl alcohol乙烯－乙烯醇FFAS = formamidine sulfinic acid甲脒亚磺酸FBB = folding box board折叠箱纸板FBK = fully bleached kraft全漂牛皮纸FC = flow controller流量控制器FID = free induction decays自由感应衰减FP = freezing point冰点；凝固点GGDP = gross domestic product本国生产总值GEMS = general energy and materials balance system通用能量和物料平衡系统GLC = gas－liquid chromatography气液色谱GPC = gel permeation chromatographic analysis凝胶渗透色谱分析GPM = gallons per minute加仑/分钟HHC = high consistency高浓HCR = high consistency refiner高浓磨浆机HD = high density高密度HPR = high production rate高生产率HPSEC = high－performance size－exclusion chromatography高性能粒度筛析色谱法HRT = hydraulic retention time水力停留时间HTH = high test hypochlorite高级漂粉HV = high voltage高压HW = hardwood硬木IIMPM = interactive multiplanar model相互作用的多面模型IPST = institute of paper science and technology造纸科技研究院IWC = international water consultants国际水质顾问团JJIT = just－in－time正好；准时KKP = kraft pulp牛皮浆；硫酸盐浆LLC = level controller液面控制器LCC = lignin－carbohydrate complexes木素－碳水化合物复合体LCL = lower control limits控制下限LCR = level cotroller and recorder液面控制记录仪LDPE = low density poly ethylene低密度聚乙烯LDV = laser Doppler velocimetry激光多普勒测速法LIVG = low inlet velocity gasification process低入口速度气化工艺LPR = low production rate低生产率LRD = long rang dependence广范围相关LVDT = linear position transducer线性位移变送器LWC = lightweight coated低定量涂布的MMACT = maximum achievable control technology最大可达控制技术MAP = modified atmosphere packaging改良常压包装法MC = marginal cost边际成本= medium consistency中浓(度)MDI = methylendiphenyl diisocyanate亚甲苯二苯二异氰酸酯MeB = methylene blue亚甲基兰，四甲基兰MEK = methyl ethyl ketone甲(基)乙(基)酮MF = machine finished机械整饰的MG = machine glazed机械上光的= malachte green孔雀绿MISS = mixed liquor suspended solids (有机物与活性污泥 )混合液中悬浮固体MOW = mixed office waste混合办公废纸MRP = matal removal process金属(离子)脱除过程MSW = municipal solid waste城市固体废物MVP = moisture vapor permeability水蒸汽渗透性MWL = milled wood lignin磨木木素NNC = nitrocellulose 硝化纤维素NF = nanofiltration超滤 (毫微过滤)NMR = nuclear magnetic resonance核磁共振NSPS = new source performance standards新的资源性能标准NSSC = neutral sulfite semi－chemical pulp中性亚硫酸半化学浆OOCC = old corrugated container旧瓦楞纸箱OD = over dry绝干；烘干OEE = overall equipment efficiency总设备效率OIT = oxidative induction temperature氧化起始温度O＆M = operating and maintenance 使用与维护ONP = old newspaper旧新闻纸OPP = oriented polypropylene取向聚丙烯OPR = oil penetration rates渗油率OWL = oxidized white liquor氧化白液PPAL = positron annihilation life time正电子湮没寿命PC = pressure controller压力调节器PCA = principal components analysis主成分分析PCC = precipitated calcium carbonate沉淀碳酸钙PCR = pressure controller and recorder压力调节记录仪PDSC = pressure differential scanning colorimetry压差扫描量热术PEMS = predictive emissions modeling system预测排放模型系统PEO = poly ethylene oxide聚氧化乙烯PGS = papergrade sulfite造纸用硫磺PGW = pressurized groundwood压力磨木浆PM = paper machine 造纸机；抄纸机PM/ECCM = preventive maintenance and essential care and condition monitoring预防维修／基本维修及状态监测PP = polypropylene聚丙烯PSES = pretreatment standards for existing sources现存资源预测标准PSM = process safety management(生产)过程安全管理PTFE = polytetrafluoroethylene聚四氟乙烯PTR = photothermal radiometry光热辐射分析法PVC = polyvinylchloride聚氯乙烯PVDC = polyvinyl dichloride聚二氯乙烯PVSK = polyvinylsulfate聚乙烯硫酸酯RRDH = rapid displacement heating快速置换加热法RH = relative humidity相对湿度RMP = refiner mechanical pulp木片磨木浆；盘磨机械浆RN = regular number纸板标准号RT = radiographic testing射线照相试验，X射线检验SSBK = solid bleached kraft(同质)漂白牛皮纸SBR = sequencing batch reactors程序化间歇反应器SC = super calendered超级压光的SDI = silt density index淤泥浓度指数SE = supplemental energy补充能量；辅助能SEC = size exclusion chromatographic粒度筛析色谱法SEM = scanning electron microscope扫描电子显微镜SEM－EDS = scanning electron microscope－energy dispersive spectrometry扫描电子显微镜—能量分散能谱测定法SGW = stone ground wood磨石磨木浆SIF = stress intensity factor应力强度系数；应力强化因子SOPs = standard operating procedures标准作业程序SP = sulphite pulp亚硫酸盐纸浆SPC = satislical process control过程控制SRT = solids retention time粒子留着时间SUB = solid unbleached board(同质)本色浆纸板SW = softwood软木；针叶树SWL = sulphite waste liguor亚硫酸盐废液TTAC = totally applied chlorine总用氯量TC = temperature controller温度调节器TCDF = tetrachlorodibenzofuran四氯二苯并呋喃TCF = totally chlorine－free全无氯(漂白)TCR = temperature controller and recorder温度调节记录仪TGA = thermal gravimetric analysis热重分析TLA = thin layer activation薄层活性化TMP = thermo mechanical pulp热磨机械浆TP = thermo－plastic热塑性的TQ = threshold quantity临界量(值)TRS = total reduced sulfur总还原硫TS = tensile strength抗张强度TSS = total suspended solids总悬浮固体量UUBB = unbeached board本色(浆)纸板UBK = unbeached kraft本色牛皮纸UCL = upper control limits控制上限UT = ultrasonic testing超声试验UV = ultraviolet紫外光VVOC = volatile organic compound挥发性有机化合物WWAS = waste－activated sludge废活性污泥WFMT = wet fluorescent magnetic particle test湿荧光磁粉试验WL = white ledger白色帐簿纸WLC = white－lined chipboard白浆衬里的粗纸板WP = wood pulp木浆WVTR = water vapor transmission rate水蒸汽传递速度YYI = yellow index返黄值；返黄指数YP = yield point屈服(软化)点。