电控柜检验单
电气柜成品出厂检验记录
门锁与地之间
100mΩ
元件框架与地之间
100mΩ
6
电气间隙
爬电距离
电气间隙≥10mm爬电距离≥12.5mm隔离距离≥20mm
□ 合 格
□ 不合格
7
防护等级
使用2.5mm的探针，施加3N力，不能探入壳体内
8
一致性
关键件是否符合CCC认证细则要求，产品与图纸、描述报告是否一致；产品结构与型式试验样品一致
结论：只有全部项目检验合格，该产品的出厂检验才合格
□ 合 格
□ 不合格
质检员：
（签章）
年 月 日
□ 有
□无
闪络击穿现象
2、不由主电路直接供电的辅助电路对地：2320V 5S；
3、绝缘手柄对地、对主回路次
□ 合 格
□ 不合格
2、电动按照设计原理要求操作50次
5
保护电路连续性
检查保护电路的连续性应可靠，设备有明显的接地保护点及标志。
使用接地电阻测试仪测量保护导体端子和相应的裸导体部件之间的电阻，
成品出厂检验记录
标准:
编号:
产品名称:
产品编号:
规格型号:
合同号:
序号
检验项目
检验标准
结果
1
一般检查
1、电气元器件安装型号、规格与图纸一致
□ 合 格
□ 不合格
2、电气元件安装端正、牢固、美观
3、母线端部整齐、毛刺打磨干净，母线涂漆平整，美观
4、盘面无碰伤、划漆，电气元件内无杂物
5、二次接线无接头，无错误和划伤，线号正确、清晰
6、二次布线整齐，美观，远离受机械损伤处
7、所有螺母紧固
8、铭牌安装牢固，内容正确齐全
电器控制柜盘装配检验记录
电器控制柜盘装配检验记录
抽检及检定
抽检及检定：根据产品的安装和检验要求，按部件号和无害性试验进行确认和抽检，并确保有效的相关质量检查，以确保整体质量。
安装调试
1、安装供电柜：加入柜体，安装模块、绝缘模块、控制器，以及底座及附件；
2、安装变频器：安装变频器，并连接电缆；
3、安装控制器：安装控制器，并安装编程模块；
4、控制线路调试：检查所有控制线路，并进行调试；
5、调试变频器：根据设计要求，设定变频器的运行参数，以及各种保护功能；
6、调试PLC编程：根据设计要求，进行PLC编程，检查其控制逻辑是否正确，以及程序的可靠性；
7、调试安全系统：安装并调试各种安全设备，确保操作过程中的安全；
8、进行机械定位：机械定位，把每一个部件安装到正确的位置，确保其有良好的冷却效果；
可靠性检测
1、进行可靠性检测：检查设备的可靠性，包括各种时序、电路连接情况，以及控制系统稳定性；
2、测试防热介质：测试工作介质温度，检查其是否能够达到设计要求；
3、测试噪音：检测工作环境噪音，以确保声音的舒适性；。
配电柜出厂检验报告
电控柜验收报告
项目名称：编号：
柜体名称
柜体规格
柜体类型
柜体数量
项目
检验项目及技术要求
检验结果
备注
绝缘
测试
1、相间电阻、及相线与中线电阻应大于500MΩ。
合格/不合格
耐压
测试
1、主电路带电部件与地（框架）之间，2500V在5秒无击穿、无闪络现象。
合格/不合格
2、主电路母排各相之间，2500V5秒无击穿、无闪络。主回路导线之间，750V5秒无击穿、无闪络，二次回路500V5秒无击穿、无闪络。
合格/不合格
保护电 路的连 续 性
1、主接地线与门（箱体）之间的的连续性试验，接地电阻<Ω，试验电流为》10A
合格/不合格
2、主接地线与柜体裸露导电部件之间，接地电阻<Ω，试验电流为》10A。
合格/不合格
通电
测试
1、按装置的电气原理图要求进行模拟动作试验，试验结果应符合要求，5次以上均正常动作。
合格/不合格
质检综合结论：
检验部门：
质 检 人：
检验日期：
性能
参数
1、变频器、软启动器、热继电器、时间继电、仪表等参数必须按所需功能设定。
合格/不合格
品牌检验
1、元件器品牌型号应与图纸或者报价单一致。
合格/不合格
包
装
1、编号管、图纸、安装附件应齐全。
合格/不合格
2、柜面、显示部分或突出部分应有保护措施。
合格/不合格
3、包装应有方向说明及注意事项。
合格/不合格
2、安装置的电气原理图要求进行故障模拟试验，其故障信号和报警指示应正确。
合格/不合格
低压配电柜检验报告单
低压配电柜检验报告单
有一定的专业知识以及分析，图表等
一、检验报告概述
本文的主要目的是检验低压配电柜的安全性。
在本次检验中，首先将对外部整体外观尺寸和内部元件等状况进行检查，以确保设备外观完整无损，并确保设备内部元件正常工作。
其次，将开展检验，检查低压配电柜的电气安全性以及电器安装施工质量。
二、检验工作
2.1外部整体外观
（1）外观尺寸检查：首先，针对低压配电柜的外观尺寸进行检查，以确保外观尺寸与图纸规定尺寸一致，检查柜体及框架的外观形状是否完整，检查柜门及连接件的尺寸是否吻合，以及其表面处理是否达到要求。
（2）内部元件检查：检查低压配电柜内部的元件，确保每个元件的安装质量及工作状态达到要求，确保每个元件的接线无误，确保电表的标定是否正确，确保内部连接端子处的接触是否良好，确保关键元件的安装是否牢固，以及关键元件的易耗部件是否有效。
2.2低压配电柜电气安全性检验
（1）绝缘电阻检验：首先，通过绝缘电阻检验仪，检查低压配电柜的各端子和金属外壳的绝缘电阻，以确保设备的电气安全性，以及内部电路的完整性。
低压配电柜检验报告单
低压配电柜检验报告单一、基本信息：检验单位：检验日期：被检单位：检验周期：二、检验项目：1.设备安装情况：（1）检查配电柜的基础安装情况，包括支架、固定螺栓的锁紧情况以及相邻设备之间的间距是否符合要求；（2）检查配电柜的接地是否符合要求，并进行接地电阻测量；（3）检查配电柜内的设备的安装是否牢固，连接是否正常，线缆是否整齐；（4）检查配电柜的门锁是否正常，门是否能够完全关闭，并确认门的密封性；（5）检查配电柜的外观是否有划痕、破损等问题。
2.设备性能测试：（1）确认被检配电柜的额定操作电流和额定操作电压；（2）进行配电柜的绝缘电阻测试，确保绝缘电阻符合标准要求；（3）进行配电柜的接地电阻测试，确保接地电阻符合标准要求；（4）进行配电柜的漏电流检测，确保漏电流符合标准要求；（5）进行配电柜的开关操作测试，确认开关的正常使用；（6）进行配电柜的负荷开关切换能力测试，确保能正常切换负荷；（7）进行配电柜的温升试验，确认设备在正常工作负荷下的温升符合标准要求。
三、检验结果：1.设备安装情况：正常/异常（异常情况详述）。
2.设备性能测试：（1）绝缘电阻：符合/不符合（具体数值）。
（2）接地电阻：符合/不符合（具体数值）。
（3）漏电流：符合/不符合（具体数值）。
（4）开关操作：正常/异常。
（5）负荷开关切换能力：正常/异常（具体情况）。
（6）温升试验：符合/不符合（具体数值）。
四、检验结论：根据以上检验结果，本次低压配电柜的安装和性能检测结果为（合格/不合格），具体情况如下：（对不合格情况进行详细说明，并提出相应的解决方案和改进措施）五、下一步措施：根据本次检验结果，建议被检单位采取以下措施：（1）对于存在的安装问题，及时修复并重新安装，确保设备安装牢固；（2）对于存在的性能问题，根据不同情况采取相应的解决方案，确保设备能够正常运行；（3）定期对配电柜进行维护和检修，确保设备的安全可靠性。
六、检验人员签名：。
电控柜柜体点检记录表
19 滤波器
接线紧固，放松标识。
OK□ NG□ N/A□
20 开关电源
点位正确，接线紧固，无虚接、漏接。
OK□ NG□ N/A□
21 柜体表观
漆面无划伤、磕碰，标识粘贴无歪斜。
OK□ NG□ N/A□
22 接地排、零排 接线紧固，标识正确，螺栓规格使用正确。
OK□ NG□ N/A□
23 柜门
柜门高度差≤3mm，止门器无变形、卡滞。
线缆安装要求： 接线端子在插接中除部分器件注（见下注）均须将接线端子插到底或插实，绝缘部分或线皮禁止插入接线孔内及插入压接位 置。 注：端子排、微型断路器压接管型端子，注意接线端子导体部分插入接线孔，禁止将绝缘部分插入接线孔内及插入压接位置 。
检验结果：
检验员/日期：
检验结果：
检验员/日期：
OK□
NG□ N/A□
点位正确，接线紧固，无虚接、漏接，主接触器盖板安装到位 。
OK□
NG□ N/A□
接线紧固，无虚接、漏接，主断路器防护盖板安装到位，检验 后开关处于断开状态。
OK□
NG□ N/A□
责任人
6 整流桥
紧固到位பைடு நூலகம்接线正确
OK□ NG□ N/A□
中间继电器、 7 安全继电器、 点位正确，接线紧固，无虚接、漏接。
继电器排
8 PLC、模块
点位正确，接线紧固，无虚接、漏接，确认模块之间连接正 确，无错位，卡扣锁紧到位。
OK□ NG□ N/A□ OK□ NG□ N/A□
9 马达保护器 点位正确，接线紧固，无虚接、漏接。
OK□ NG□ N/A□
10 伺服驱动器
点位正确，接线紧固，无虚接、漏接，短接片安装正确，紧固 到位。
GGD配电柜出厂检验报告
GGD型交流低压配电控制柜出厂检验报告型号：___________________一、目的通过检查和试验，对GGD型交流低压配电柜在技术条件，范围的性能、安全性、适应性及制造、安装工艺进行验证，使产品达到出厂要求。
二、主要依据1、LEC439-1-1992低压成套开关设备第一部分2、GB7251-1-1997低压成套开关设备和控制条一部分三、试验项目1、柜体检验2、装配检验3、断路器检验4、隔离刀开关检验5、主四路无载通电操作试验6、绝缘电阻测试7、介电强度试验8、结论GGD型交流低压配电柜出厂检验报告第2页（英文版）Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the < code > adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; < rule > around the party discipline, disciplinary ruler requirements, listed as "negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the" bottom line ". Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. < code > and < Regulations > revised the necessity and revisedhistory of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines > and < Chinese Communist Party discipline and Punishment Regulations > column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the party's leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the < code > and < rule >, reflects the party's 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the party's eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of < the ICAC guidelines > in < in 1997 Leaders as members of the Communist Party of China clean politics certain criteria (Trial) > based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play animportant role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, "eight prohibition, 52 are not allowed to" hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to "clean" the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. < rule > is in 1997 < Chinese Communist Party disciplinary cases (Trial) > based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage theauthority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to < the criterion of a clean and honest administration > and < rule > the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations < > made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target,respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs DepartmentThe first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated thewisdom of the whole party, embodies the party. Second, < code > and < Regulations > revision of the basic principles of two party regulations revision work and implement the party's eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised < low political criterion > and < Regulations >, highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent < rule > and < rule >. Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that "no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules." the revision of the< code > and < rule > is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue "de", mainly refers to the party's ideals and beliefs, excellent traditional style. The revised the < code > closely linked to the "self-discipline", insisting on the positive initiative, for all members, highlight the "vital few", emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised < > Ji method separately, Ji, Ji Yan to Method, as a "negative list", emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in theparty at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the party's eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the < code > and < rule > modified and needs to grasp several key problems (a) < code > < code > adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the "self-discipline", removal and no direct relation to the provisions of . the second is adhere to a positive advocate, "eight prohibition" 52 are not allowed to "about the content of the" negative list moved into synchronizationamendment < cases >. Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised < code > is the ruling Party since the first insists on a positive advocate forAll Party members and the self-discipline norms, moral declaration issued to all members of the party and the National People's solemn commitment. > < criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the < code >, a total of eight, 281 words, including lead, specification and Party member cadre clean fingered self-discipline norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as "four must" "eight code". Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and work style, noble sentiments, such as "four must" the principle of requirements, strong tone of self-discipline, The higher request for 6 andsupervised tenet, the foothold in permanent Bao the party's advanced nature and purity, to reflect the revised standards requirements. Members of self-discipline norms around the party members how to correctly treat and deal with the "public and private", "cheap and rot" thrifty and extravagance "bitter music", put forward the "four norms". Party leader cadre clean fingered self-discipline norms for the leadership of the party members and cadres of the "vital few", around the "clean politics", from civil servant of the color, the exercise of power, moral integrity, a good family tradition and other aspects of the leadership of the party members and cadres of the "four norms" < > < norm norm. "The Party member's self-discipline norms" and "party members and leading cadre clean fingered self-discipline norms," a total of eight, collectively referred to as the "eight". "Four must" and "eight" of the content from the party constitution and Party's several generation of leaders, especially Xi Jinping, general secretary of the important discussion, refer to the "three discipline and eight points for attention" statements, and reference some embody the Chinese nation excellent traditional culture essence of epigrams. (2) the revised regulations, the main changes in the revised Regulations > to fully adapt to thestrictly requirements, reflects the according to the regulations governing the law of recognition of deepening, the realization of the discipline construction and Jin Ju. < rule > is party a ruler, members of the basic line and follow. And the majority of Party members and cadres of Party organizations at all levels should adhere to the bottom line of thinking, fear discipline, hold the bottom line, as a preventive measure, to keep the party's advanced nature and purity. 1, respect for the constitution, refinement and discipline. Revised < rule > from comprehensive comb physical constitution began, the party constitution and other regulations of the Party of Party organizations and Party discipline requirements refinement, clearly defined in violation of the party constitution will be in accordance with regulations to give the corresponding disciplinary action. The original 10 categories of misconduct, integration specification for political discipline, discipline, honesty and discipline masses Ji Law and discipline and discipline and other six categories, the content of < rule > real return to Party discipline, for the majority of Party members and listed a "negative list. 7 2, highlighting the political discipline and political rules. > < Regulations according to the stage of the discipline of outstandingperformance, emphasizing political discipline and political rules, organization and discipline, in opposition to the party's leadership and the party's basic theory, basic line, basic program and basic experience, the basic requirement of behavior made prescribed punishment, increase the cliques, against the organization such as violation of the provisions, to ensure that the central government decrees and the Party of centralized and unified. 3, adhere to strict discipline in the law and discipline In front, Ji separated. Revised < Regulations > adhere to the problem oriented, do Ji separated. Any national law existing content, will not repeat the provisions, the total removal of 79 and criminal law, repeat the content of the public security management punishment law, and other laws and regulations. In the general reiterated that party organizations and Party members must conscientiously accept the party's discipline, die van comply with national laws and regulations; at the same time, to investigate violations of Party members and even criminal behavior of Party discipline and responsibility, > < Regulations distinguish five different conditions, with special provisions were made provisions, so as to realize the connection of Party discipline and state law. 4, reflect Wind building and anti-corruptionstruggle of the latest achievements. < rule > the party's eighteen years implement the spirit of the central provisions of the eight, against the requirements of the "four winds" and transformation for disciplinary provisions, reflecting the style construction is always on the road, not a gust of wind. In the fight against corruption out of new problems, increase the trading rights, the use of authority relatives profit and other disciplinary terms. Prominent discipline of the masses, the new against the interests of the masses and ignore the demands of the masses and other disciplinary terms and make provisions of the disposition and the destruction of the party's close ties with the masses.Discipline to protect the party's purpose. 8 of these regulations, a total of three series, Chapter 15, 178, more than 24000 words, after the revision of the regulations a total of 3 series, Chapter 11, 133, 17000 words, divided into "general" and "special provisions" and "Supplementary Provisions" Part 3. Among them, add, delete, modify the provisions of the proportion of up to nearly 90%. 1, the general general is divided into five chapters. The first chapter to the regulations of the guiding ideology, principles and scope of application of the provisions, highlight the strengthening ofthe party constitution consciousness, maintenance the authority of Party Constitution, increase the party organizations and Party members must abide by the party constitution, Yan Centralized centralized, would examine at all levels of the amended provisions implementing and maintaining Party discipline, and consciously accept the party discipline, exemplary compliance with national laws and regulations. The second chapter of discipline concept, disciplinary action types and effects of the regulations, will be a serious warning from the original a year for a year and a half; increase the Party Congress representative, by leaving the party above (including leave probation) punishment, the party organization should be terminated its representative qualification provisions. The third chapter of the disciplinary rules of use prescribed in the discipline rectifying process, non convergence, not close hand classified as severely or heavier punishment. "Discipline straighten "At least eighteen years of five years, these five years is to pay close attention to the provisions of the central eight implementation and anti -" four winds ". The fourth chapter on suspicion of illegal party disciplinary distinguish five different conditions, with special provisions were madeprovisions, to achieve effective convergence of Party and country 9 method. < rule > the provisions of Article 27, Party organizations in the disciplinary review found that party members have committed embezzlement, bribery, dereliction of duty dereliction of duty and other criminal law act is suspected of committing a crime shall give cancel party posts, probation or expelled from the party. The second is < Regulations > Article 28 the provisions of Party organizations in the disciplinary review But found that party members are stipulated in the criminal law, although not involved in a crime shall be investigated for Party discipline and responsibility should be depending on the specific circumstances shall be given a warning until expelled punishment. This situation and a difference is that the former regulation behavior has been suspected of a crime, the feeling is quite strict, and the latter for the behavior not involving crime, only the objective performance of the provisions of the criminal code of behavior, but the plot is a crime to slightly. < Regulations > the 29 provisions, Party organizations in the discipline review found that party members and other illegal behavior, affect the party's image, the damage to the party, the state and the people's interests, we should depend on the situationSeriousness given disciplinary action. The loss of Party members, seriously damaging the party's image of behavior, should be given expelled from the party. At this article is party member is in violation of the criminal law outside the other illegal acts, such as violates the public security administration punishment law, customs law, financial laws and regulations behavior. The fourth is < cases > Article 32 stipulates, minor party members and the circumstances of the crime, the people's Procuratorate shall make a decision not to initiate a prosecution, or the people's court shall make a conviction and exempted from criminal punishment shall be given within the party is removed from his post, probation or expelled from the party. Party members and crime, sheets were fined in accordance with For acts; the principal Ordinance amended the provisions of the preceding paragraph. This is the new content, in order to achieve Ji method effective convergence. Five is < > the thirty third article 10 of the provisions, the Party member due to an intentional crime is sentenced to criminal law (including probation) sheets or additional deprivation of political rights; due to negligence crime and was sentenced to three years or more (excluding three years) a penalty, shall give expelled punishment. Due to negligence crime is convictedand sentenced to three years (including three years) in prison or be sentenced to public surveillance, detention, shall in general be expelled from the party. For the individual may not be expelled from the party, should control Approval. This is followed and retained the original > < Regulations the provisions of punishment party authorization rules and report to a level party organizations. For is "party members with criminal acts, and by the criminal punishment, generally should be expelled from the party". The fifth chapter of probationary Party member of the discipline and discipline after missing members of the treatment and punishment decisions, such as the implementation of the provisions, clear the related party discipline and punishment decision made after, for duties, wages and other relevant alteration formalities for the longest time. 2, sub sub section will the original regulations of10 categories of acts of violation of discipline integration revised into 6 categories, respectively, in violation of the punishments for acts of political discipline "in violation of discipline behavior of punishment" in violation of integrity of disciplinary action points "of violation punishments for acts of mass discipline" "the violation of work discipline, punishment" in violation of discipline of life behaviorpunishment "6 chapters. 3, annex" Supplementary Provisions "clear authority making supplementary provisions of, cases of interpretative organ, as well as regulations implementation time and retroactivity etc.. 11 (3) learning understanding > < regulations needs to grasp several key problems The first problem -- about the violation of political discipline behavior > < new ordinance chapter 6 the political discipline column for the six disciplines, that is the main opposition to Party leadership and the opposition of the basic theory, basic line, basic program and basic experience, basic requirements of misconduct made provisions of the disposition, especially the eighteen since the CPC Central Committee put forward the Yan Mingzheng treatment of discipline and political rules requirements and practical achievements transformation for Discipline article, increase the false debate central policies, cliques, against the organization review, make no discipline of the principle of harmony terms. These are the party's eighteen years in comprehensive strictly Process combined with the practice of rich content. (1) false debate the central policies and undermine the Party of centralized and unified the problem is made in accordance with the provisions of the party constitution. Constitution in general programme requirementsadhere to democratic centralism is one of the requirements of the construction of the party must adhere to the four cardinal. Application of this principle is not only the party the basic organization principle and is also the mass line in party life, it requires that we must fully develop inner-party democracy, respect for the dominant position of Party members, safeguarding the Party member democratic rights, give full play to the enthusiasm and creativity of the party organizations at all levels and Party members, at the same time, also must implement the right concentration, ensure the party's mission < the chaos in unity and concerted action to ensure that the party's decision to get quickly and effectively implementing. The Party Central Committee formulated the major principles and policies, through different channels and ways, fully listen to the party organizations and Party members of the opinions and suggestions, but 12 is some people face to face not to say back blather "" will not say, after the meeting said, "" Taiwan does not say, and nonsense ", in fact, not only disrupt the people thought, some causing serious consequences, the damage to the Party of the centralized and unified, hinder the central policy implementation, but also a serious violation of the democratic system of principles. There is no doubt that shall, inaccordance with the Regulations > 4 Specified in Article 6 to give the appropriate punishment. For did not cause serious consequences, to give criticism and education or the corresponding tissue processing. (2) about the destruction of the party's unity < New Regulations > the forty eighth to fifty second article, to damage Party's unity unified and violation of political discipline, punishment situation made explicit provisions. Article 52 of the new "in the party get round group, gangs seek private gain, cliques, cultivate private forces or through the exchange of interests, for their own to create momentum and other activities to gain political capital, given a serious warning or withdraw from their party posts disposition; if the circumstances are serious, to give Leave a party to observation or expelled from the party. (3) on against the organization review of the provisions of the constitution, party loyalty honesty is party members must comply with the obligations. Members must obey the organization decision, shall not violate the organization decided encounters by asking questions to find organization, rely on the organization, shall not deceive the organization, against the organization. For example, after the investigation does not take the initiative to explain the situation, but to engage inoffensive and defensive alliance, hiding the stolen money is against survey organization, is a violation of the behavior of political discipline. Article 24 of the original > < Regulations, although the provisions of the interference, hinder group review the behavior of the fabric can be severely or 13 Aggravated punishment, but did not put this kind of behavior alone as a discipline for qualitative amount of discipline. > < new regulations increase the Article 57, "anti organization review, one of the following acts, given a warning or serious warning; if the circumstances are relatively serious, giving removed from or placed on probation within the party post; if the circumstances are serious, give expelled from the party: (a) on supply or forged, destroyed, transfer, conceal evidence; (II) to prevent others expose, providing evidence Material; (III) harboring co personnel; (4) to the organization to provide false information, to hide the fact;(5) the him against the acts of the organization review. "< rule > add this clause to the Constitution requires more specific, the previous no punishment in accordance with the definite list and put forward clear punishment in accordance with. (4) about organizing or participating in superstitious activities as < Regulations > about engage in activities of。
电气控制柜出厂检验报告单
电气控制柜出厂检验报告单报告单编号：2024-001企业名称：XXX有限公司产品名称：电气控制柜出厂日期：2024年1月1日一、产品概述二、检验内容本次检验旨在验证电气控制柜的安全性、可靠性、功能性等方面是否符合相关标准要求，并检验产品的性能指标是否满足技术要求。
三、检验方法1.外观检验：对电气控制柜的外观进行检验，包括外壳是否完整且无明显损伤、开关按钮是否灵活、标识是否清晰等。
2.绝缘电阻测量：使用万用表对电气控制柜的绝缘电阻进行测量，确保其绝缘性能符合要求。
3.功能性测试：对电气控制柜的各个部件进行功能性测试，例如主开关、照明开关、电流表、电压表等。
4.短路保护测试：通过模拟短路故障，检验电气控制柜的短路保护功能是否正常。
5.接地保护测试：使用接地测试仪对电气控制柜的接地保护效果进行测试，确保其符合相关标准要求。
四、检验结果1.外观检验：电气控制柜的外观完整无损，开关按钮灵活，标识清晰可读。
2.绝缘电阻测量：测量结果显示，电气控制柜的绝缘电阻均达到标准要求，符合安全性要求。
3.功能性测试：各部件功能正常，主开关、照明开关、电流表、电压表等均能正常工作。
4.短路保护测试：在模拟短路故障下，电气控制柜能及时切断电路，有效保护设备。
5.接地保护测试：接地测试仪显示，电气控制柜的接地保护效果良好，符合相关标准要求。
五、结论经过本次出厂检验，电气控制柜的安全性、可靠性、功能性等方面均符合相关标准要求，性能指标满足技术要求。
符合出厂要求，可以进行发货销售。
六、建议1.在生产过程中，加强对电气控制柜外壳的保护，确保运输和使用过程中不会导致外观损坏。
2.继续保持对电气控制柜各部件的质量把控，确保产品功能正常可靠。
3.根据市场反馈，不断改进产品设计和性能，提高产品竞争力。
七、其他报告编制人：XXX。
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
产方法
检验记录
结论
1
柜门
面板平整，门开启角度大于90度，门缝均匀，开启时不能使电器受到冲击，不损坏油漆，上销后无晃动，有元件门要接地。
目测
符合要求
2
电镀件
无起皮脱落、发霉及生锈现象
3
喷漆层
无流痕、刷痕、透底、起沟、杂质、色泽均匀
4
紧固件
采用的紧固件符合要求应拧紧，并有防松装置
手动目测
符合要求
5
元件安装
型号规格符合图纸，并有许可证、3C证、合格证，安装符合说明书，飞弧距离达到要求
目测校准
符合要求
6
母线
无毛刺、锤痕、划痕、凹坑；接触面吻合平整排列整齐，漆色相序正确；弯曲处无裂痕
目测
量具测量
符合要求
7
二次线
接线符合图纸，布线方式符合工艺要求，同一工程导线走向基本一致，导线规格采用正确
3、接地端子排
4、断路器支架
5、刀开关支架
12
电气间隙爬电距离
电气间隙≥8mm
游标卡尺
符合要求
爬电距离≥
13
通电试验
机械操作试验
各元件动作顺序、功能符合设计，手动分合各5次，灵活可靠，无误动作。联锁正确、可靠。
通电后用手动操作
符合要求
电气操作试验
14
介电强度试验（工频1S）
在主电路导电部分之间和相对地之间应经受至少施加电压2500V/1S的耐压试验
目测
符合要求
8
指示灯
符合GB2681,GB2682(含按钮、导线颜色)
9
清洁
内部清洁，无油污、清晰、
10
铭牌
平整、数据正确、清晰
11
接地保护电路
柜架、元件接地部分应保证其电气连续性、接地装置无油污、锈迹。保护回路电阻≤100mΩ。主接地点至设备点
1、仪表门
目测
用接地电阻测试仪测量
≤100mΩ
2、门锁
IP30量具
符合要求
结论：本产品经检验符合标准，检验合格，准予出厂。
检验员： 质检部： 日期：
手柄与带电部分之间应经受至少1S时间施加3750V的电压。辅助电路2500V/1S。泄漏电流100mA。额定频率为50HZ正弦波
用工频耐压试验仪
符合要求
15
电路绝缘电阻
相对相
动力电路导线和保护接地电路间施加时，其绝缘电阻应≥20MΩ(变频器脱离绝缘测试电路）
使用
兆欧表
符合要求
相对地
16
防护等级
IP30