低压配电柜产品出厂检验报告
低压配电柜产品出厂检验报告
交流低压配电柜产品自检报告产品名称交流低压配电柜产品型号规格一级、二级柜检验员序号检验项目检验内容及方法标准要求实测值一次合格修后合格1 一般检查1）外观质量柜体内外喷漆质量柜体漆涂层不允许有皱纹、气泡、透底等缺陷。
色泽均匀，无明显刷痕、伤痕、机械杂质，表面漆色一致。
所有电镀层质量镀层牢固，无起皮、发霉、生锈等现象。
连接柜架外壳连接件的紧固螺钉应拧紧，有防松措施。
柜架紧固螺钉拧紧，有防松措施。
2）电器元件按设计及现行规范核对柜内所有元器件型号规格及参数，且元件为进厂合格品。
操作机构运行方向有明显标志。
(1)柜内安装的元件为进厂合格品。
(2)元件型号规格及参数符合设计要求和产品描述报告。
(3)元件的安装调整符合有关技术文件要求。
(4)操作机构运动方向应在操作处有明显标志，且运动方向符合有关技术要求规定。
3）母线与二次回路检查母线规格及加工质量。
检查二次回路导线规格及配线质量。
(1)母线及二次回路导线符合设计要求。
(2)一次元件接线正确，母线排列整齐美观，搭接面平整，不平度不大于0.5mm，且自然吻合，有防松防电化腐蚀措施。
(3)二次回路接线正确，配线整齐美观，标号清楚。
(4) 母线及二次回路导线均符合工艺求。
4）间隙和爬电距离检查各导电回路带电部件之间及其金属结构件之间，母线与母线之间的电气间隙和爬电距离。
(1)母线与母线之间，元件进出线端子之间的电气间隙不小于8mm。
(2)母线与母线之间，元件进出线端子之间的爬电距离不小于12.5mm。
5）绝缘电阻检查各导电回路带电部件之间及其金属结构件之间，母线与母线之间的绝缘电阻绝缘电阻相间.相对地均不小于5MΩ序号检验项目检验内容及方法标准要求实测值一次合格修后合格2 机械操作验证1）装置中所有手动操作部件等操作5次。
2）按照设计要求，进行通电试验5次。
(1) 手动操作机构灵活，无卡滞，操作力过大等现象。
(2) 通电试验，一、二次线路正确，符合设计要求。
(3) 主开关在85%和110%额定电压下吸合动作可靠，在65%~110%分闸和35%~70%失压脱扣动作可靠(4) 电子式脱扣器参照开关技术参数进行3 介电强度验证主电路及与主电路直接连接的辅助电路试验电压为：（V）2500V，1s，无闪烙、无击穿不与主电路直接连接的辅助电路试验电压为：（V）2000V，1s，无闪烙、无击穿4 保护电路连续性验证测量主接地点与保护电路任一点之间的电阻值。
配电箱出厂检验报告
配电箱出厂检验报告（二）引言概述：本次配电箱出厂检验报告旨在对配电箱进行全面的检验和评估，确保其符合相关国家标准和行业要求。
通过本次检验，能够确保配电箱的质量和可靠性，保障其在安全和可靠性方面的性能。
正文内容：1.外观检验1.1配电箱外壳1.1.1通过目视检查，外壳无明显变形、裂纹、划痕等缺陷。
1.1.2外壳表面光滑且无锈蚀或脱漆现象。
1.1.3配电箱的外部标识清晰可读，标注符合相应国家标准和规范要求。
1.2配电箱门1.2.1配电箱门开闭灵活，并配备可靠的门锁装置。
1.2.2配电箱门密封良好，确保内部元器件不受外界灰尘、湿气等影响。
2.内部结构检验2.1配电箱内部导线连接2.1.1检查配电箱内导线连接是否牢固，无松动和断裂现象。
2.1.2导线接头处均采用绝缘套管进行包覆，确保绝缘性能。
2.1.3配电箱内导线标准、规格和颜色符合相应的电气标准。
2.2配电箱电器设备2.2.1检查配电箱内的电器设备如断路器、熔断器等是否符合相关标准，且工作可靠。
2.2.2确保电器设备的额定电流与配电箱的负荷要求相匹配。
2.2.3测试电器设备动作可靠性和保护性能，确保在过载和短路情况下能及时断电保护。
3.绝缘性能检验3.1使用绝缘电阻表对配电箱的导线和绝缘件进行测量，确保其绝缘电阻值符合相关标准要求。
3.2检查配电箱的绝缘材料和绝缘涂层，确保其完好无损，绝缘性能良好。
4.过载和短路保护测试4.1使用专业测试设备对配电箱的过载保护和短路保护功能进行测试。
4.2确保过载保护功能的动作时间符合国家标准要求，能有效保护电器设备。
4.3确保短路保护功能的动作时间符合国家标准要求，能及时切断异常电流，避免事故发生。
5.漏电保护测试5.1使用专业测试仪器对配电箱的漏电保护器进行测试。
5.2确保漏电保护器的动作电流和动作时间符合相关标准要求。
5.3测试漏电保护器能否可靠地切断漏电电流，保护人身安全。
总结：本次配电箱出厂检验过程中，对配电箱外观、内部结构、绝缘性能、过载和短路保护以及漏电保护进行了全面检查和测试。
低压控制柜出厂检验报告
设备标志、安全警示标识等标识均配备
线色
线路颜色区分清晰
电气间隙和爬电距离
电气间隙＞1.5mm
爬电距离＞1.5mm
电击防护及保护电路的完整性
电击防护及保护电路均可靠完整
机械操作器操作正常
出厂合格证及其他配件
齐全
包装
包装完好，简易缠绕膜防尘防护
检验结论
日期：检验：批准：
低压控制柜产品出厂质量检验报告
客户名称：产品名称：年月日
检验项目
技术要求
实测结果
单项判定
外观及本体
外观及本体无破损、无变形裂纹
壳体尺寸
尺寸：
内装元器件
各电气元器件固定牢靠、无松动
内部电路和连接
电路连接线路清晰可靠、接线准确
电气设备
运行
传感器工作正常
PLC控制器、触摸屏开关机正常、操作无异常
其他零电气件运行无异常
交流低压开关柜GGD例行检验报告
交流低压开关柜GGD例行检验报告
No：
产品名称：交流低压开关柜
型号规格：GGD-1000
依据标准：GB/T 7251.12-2013
出厂编号：2020101021
地下室低压配电柜
生产日期：2020年10月10日
序
项目
技 术 要 求
实测
试验结果
1
一般检查
柜体各功能单元门的开启角应大于90°，转动灵活
符合
对主电路和不与主电路直接连接的辅助电路之间、辅助电路与框架之间应能受50Hz，1890V历时7s耐压试验。
符合
9
保护措施和保护电路的连续性
有主接地点和接地标记，零部件和电器元件的保护接地使用专用的螺钉，以保证保护电路的连续性。
符合
电阻值应在100mΩ以下。
主开关安装支架-主接地
≤50MΩ
分支开关安装支架-主接地
≤50MΩ
接线端子支架-主接地
≤50MΩ
门锁-主接地
≤50MΩ
10
操作试验
手动操作试验：装置中所有手动操作部分：如主开关的操作手柄等手动操作5次而无异常现象出现。有连锁功能要求的应连锁可靠。
符合
11
一致性检查
1关键元器件和材料、2.结构 3.铭牌应与型式试验报告描述一致
符合
12
检验结论：该产品经我公司检验合格，准予出厂
符合
5
内部电路和连接
装应符合认证产品的一致性要求、工艺要求和图纸规定的要求。
符合
6
外接端子
数量、类型和标识应符合成套设备输出接线的要求及型式试验报告的要求
符合
7
绝缘电阻
相与相之间,相与地之间的绝缘电阻值绝缘电阻不应小于1000Ω/V，规定≥10MΩ。
低压配电柜产品出厂检验报告
低压配电柜产品出厂检验报告一、检验概述本报告是对低压配电柜产品进行出厂检验的结论性报告，旨在验证产品的性能和质量是否符合相关标准和客户要求。
本次出厂检验采用了标准化的测试方法和设备，确保结果的准确性和可靠性。
二、检验项目1.外观检验：对产品的外观进行全面检查，包括外壳是否完整、标识是否清晰、面板是否平整等。
2.功能检验：对产品的各项功能进行测试，包括开关操作是否正常、电流是否在规定范围内、短路和过载保护是否可靠等。
3.绝缘电阻检验：对产品的绝缘电阻进行测量，确保产品的绝缘性能符合要求。
4.效应应力测试：对产品进行效应应力测试，模拟产品在正常使用过程中的负荷情况，确保产品的结构和材料能够承受正常工作状态下的应力。
5.耐压试验：对产品进行耐压试验，模拟产品在特殊环境下的工作情况，例如高温、低温和高湿度等，确保产品能够在各种环境下正常工作。
6.电气参数测量：对产品的电气参数进行测量，例如电压、电流、功率因数等，确保产品符合设计要求。
7.电弧灭弧性能测定：对产品的电弧灭弧性能进行测试，确保产品在发生电弧事故时能够迅速灭弧，以保护人员和设备的安全。
三、检验结果经过上述项目的检验，本次低压配电柜产品出厂检验的结果如下：1.外观检验：产品的外观完整，标识清晰，面板平整。
2.功能检验：产品的开关操作正常，电流在规定范围内，短路和过载保护可靠。
3.绝缘电阻检验：产品的绝缘电阻符合要求。
4.效应应力测试：产品在效应应力测试中表现良好，未出现结构破损或材料变形等情况。
5.耐压试验：产品在耐压试验中正常工作，无异常情况发生。
6.电气参数测量：产品的电气参数符合设计要求。
7.电弧灭弧性能测定：产品的电弧灭弧性能达到或超过标准规定，对电弧能够迅速灭弧。
综上所述，本次低压配电柜产品出厂检验的结果符合相关标准和客户要求，产品在各项指标上均符合设计要求，质量可靠、性能稳定。
四、结论1.本次低压配电柜产品出厂检验的结果显示，产品在外观、功能、绝缘性能、结构强度、耐压能力、电气参数和电弧灭弧性能等方面都符合要求。
低压开关柜出厂检验报告
规格型号：用户单位：HD.J.34
检查项目
技术标准要求
检验结果
编号：
结构检查
壳体表面喷涂层无气孔流痕透底等缺陷，镀层色泽均匀；门开闭灵活，焊接结构牢固；
开关器件和元件的组合
内装元件的安装和标识符合图纸及工艺文件要求
内部电路和连接
1.检查装置中母线相序排列、标识应符合工艺文件要求
1、主电路的所有带电部分（包括连接到主电路上的控制电路和辅助电路）连接在一起与外露可导电部分之间施压1890V，施压时间1S，应无击穿闪络现象；
2、主电路不同电位的每个带电部分和不同电位其他带电部分与连接在一起的外露导电部分之间施压1890V，施压时间1S，应无击穿闪络现象
3、带电部件与用金属箔裹缠的绝缘操作手柄之间(试验时，框架不应接地，也不应与其他电路连接)施压2835V，施压时间1S，应无击穿闪络现象
2.检查导线、母线截面积是否符合要求，连接接触良好
3.检查装置中连接导线是否采用铜芯多股绝缘导线，且接线正确无误
外接导线端子
端子的数量、类型、标志、允许外接铜导线的截面积应符合图纸和工艺文件要求。
机械操作试验
对机械操作的部件操作5次无异常现象出现，机构灵活动作可靠，应无卡阻、有效
介电强度试验
绝缘电阻验证：相间及相导体与裸露导电部件之间>1000Ω/V
前门锁与地之间
后上门锁与地之间
后下门锁与地之间
刀开关手柄与地之间
断路器框架与地之间
熔断器安装支架与地之间
柜体与地之间
电气间隙
爬电距离
不同极性的裸导线之间以及它们与外壳之间
≥10mm
≥12.5mm
壳防护等级
φ2.5试具不得通过，符合IP30要求
低压开关柜合格检验报告
低压开关柜合格检验报告
自查报告。
日期，2022年10月15日。
自查单位，某某公司。
自查人员，XXX。
自查内容：
1.外观检查，检查低压开关柜外壳表面是否有明显的损坏或划痕，确保外观完好。
2.内部连接检查，检查低压开关柜内部连接是否牢固，电缆是否有松动或损坏。
3.电气性能检查，使用电气测试仪器对低压开关柜的电气性能进行检测，确保各项参数符合要求。
4.安全装置检查，检查低压开关柜的安全装置是否完好，包括漏电保护装置、短路保护装置等。
自查结果：
经过自查，低压开关柜外观完好，内部连接牢固，电气性能符合要求，安全装置完好。
自查结果合格。
自查结论：
本次自查结果显示，低压开关柜符合合格标准，可以正常投入使用。
但在日常使用中，仍需定期进行检查和维护，确保设备的安全和可靠性。
自查人员签名，XXX 日期，2022年10月15日。
以上为低压开关柜合格检验自查报告。
GGD配电柜出厂检验报告
GGD型交流低压配电控制柜出厂检验报告型号：___________________一、目的通过检查和试验，对GGD型交流低压配电柜在技术条件，范围的性能、安全性、适应性及制造、安装工艺进行验证，使产品达到出厂要求。
二、主要依据1、LEC439-1-1992低压成套开关设备第一部分2、GB7251-1-1997低压成套开关设备和控制条一部分三、试验项目1、柜体检验2、装配检验3、断路器检验4、隔离刀开关检验5、主四路无载通电操作试验6、绝缘电阻测试7、介电强度试验8、结论GGD型交流低压配电柜出厂检验报告第2页（英文版）Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the < code > adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; < rule > around the party discipline, disciplinary ruler requirements, listed as "negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the" bottom line ". Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. < code > and < Regulations > revised the necessity and revisedhistory of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines > and < Chinese Communist Party discipline and Punishment Regulations > column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the party's leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the < code > and < rule >, reflects the party's 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the party's eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of < the ICAC guidelines > in < in 1997 Leaders as members of the Communist Party of China clean politics certain criteria (Trial) > based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play animportant role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, "eight prohibition, 52 are not allowed to" hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to "clean" the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. < rule > is in 1997 < Chinese Communist Party disciplinary cases (Trial) > based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage theauthority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to < the criterion of a clean and honest administration > and < rule > the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations < > made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target,respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs DepartmentThe first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated thewisdom of the whole party, embodies the party. Second, < code > and < Regulations > revision of the basic principles of two party regulations revision work and implement the party's eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised < low political criterion > and < Regulations >, highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent < rule > and < rule >. Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that "no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules." the revision of the< code > and < rule > is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue "de", mainly refers to the party's ideals and beliefs, excellent traditional style. The revised the < code > closely linked to the "self-discipline", insisting on the positive initiative, for all members, highlight the "vital few", emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised < > Ji method separately, Ji, Ji Yan to Method, as a "negative list", emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in theparty at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the party's eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the < code > and < rule > modified and needs to grasp several key problems (a) < code > < code > adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the "self-discipline", removal and no direct relation to the provisions of . the second is adhere to a positive advocate, "eight prohibition" 52 are not allowed to "about the content of the" negative list moved into synchronizationamendment < cases >. Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised < code > is the ruling Party since the first insists on a positive advocate forAll Party members and the self-discipline norms, moral declaration issued to all members of the party and the National People's solemn commitment. > < criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the < code >, a total of eight, 281 words, including lead, specification and Party member cadre clean fingered self-discipline norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as "four must" "eight code". Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and work style, noble sentiments, such as "four must" the principle of requirements, strong tone of self-discipline, The higher request for 6 andsupervised tenet, the foothold in permanent Bao the party's advanced nature and purity, to reflect the revised standards requirements. Members of self-discipline norms around the party members how to correctly treat and deal with the "public and private", "cheap and rot" thrifty and extravagance "bitter music", put forward the "four norms". Party leader cadre clean fingered self-discipline norms for the leadership of the party members and cadres of the "vital few", around the "clean politics", from civil servant of the color, the exercise of power, moral integrity, a good family tradition and other aspects of the leadership of the party members and cadres of the "four norms" < > < norm norm. "The Party member's self-discipline norms" and "party members and leading cadre clean fingered self-discipline norms," a total of eight, collectively referred to as the "eight". "Four must" and "eight" of the content from the party constitution and Party's several generation of leaders, especially Xi Jinping, general secretary of the important discussion, refer to the "three discipline and eight points for attention" statements, and reference some embody the Chinese nation excellent traditional culture essence of epigrams. (2) the revised regulations, the main changes in the revised Regulations > to fully adapt to thestrictly requirements, reflects the according to the regulations governing the law of recognition of deepening, the realization of the discipline construction and Jin Ju. < rule > is party a ruler, members of the basic line and follow. And the majority of Party members and cadres of Party organizations at all levels should adhere to the bottom line of thinking, fear discipline, hold the bottom line, as a preventive measure, to keep the party's advanced nature and purity. 1, respect for the constitution, refinement and discipline. Revised < rule > from comprehensive comb physical constitution began, the party constitution and other regulations of the Party of Party organizations and Party discipline requirements refinement, clearly defined in violation of the party constitution will be in accordance with regulations to give the corresponding disciplinary action. The original 10 categories of misconduct, integration specification for political discipline, discipline, honesty and discipline masses Ji Law and discipline and discipline and other six categories, the content of < rule > real return to Party discipline, for the majority of Party members and listed a "negative list. 7 2, highlighting the political discipline and political rules. > < Regulations according to the stage of the discipline of outstandingperformance, emphasizing political discipline and political rules, organization and discipline, in opposition to the party's leadership and the party's basic theory, basic line, basic program and basic experience, the basic requirement of behavior made prescribed punishment, increase the cliques, against the organization such as violation of the provisions, to ensure that the central government decrees and the Party of centralized and unified. 3, adhere to strict discipline in the law and discipline In front, Ji separated. Revised < Regulations > adhere to the problem oriented, do Ji separated. Any national law existing content, will not repeat the provisions, the total removal of 79 and criminal law, repeat the content of the public security management punishment law, and other laws and regulations. In the general reiterated that party organizations and Party members must conscientiously accept the party's discipline, die van comply with national laws and regulations; at the same time, to investigate violations of Party members and even criminal behavior of Party discipline and responsibility, > < Regulations distinguish five different conditions, with special provisions were made provisions, so as to realize the connection of Party discipline and state law. 4, reflect Wind building and anti-corruptionstruggle of the latest achievements. < rule > the party's eighteen years implement the spirit of the central provisions of the eight, against the requirements of the "four winds" and transformation for disciplinary provisions, reflecting the style construction is always on the road, not a gust of wind. In the fight against corruption out of new problems, increase the trading rights, the use of authority relatives profit and other disciplinary terms. Prominent discipline of the masses, the new against the interests of the masses and ignore the demands of the masses and other disciplinary terms and make provisions of the disposition and the destruction of the party's close ties with the masses.Discipline to protect the party's purpose. 8 of these regulations, a total of three series, Chapter 15, 178, more than 24000 words, after the revision of the regulations a total of 3 series, Chapter 11, 133, 17000 words, divided into "general" and "special provisions" and "Supplementary Provisions" Part 3. Among them, add, delete, modify the provisions of the proportion of up to nearly 90%. 1, the general general is divided into five chapters. The first chapter to the regulations of the guiding ideology, principles and scope of application of the provisions, highlight the strengthening ofthe party constitution consciousness, maintenance the authority of Party Constitution, increase the party organizations and Party members must abide by the party constitution, Yan Centralized centralized, would examine at all levels of the amended provisions implementing and maintaining Party discipline, and consciously accept the party discipline, exemplary compliance with national laws and regulations. The second chapter of discipline concept, disciplinary action types and effects of the regulations, will be a serious warning from the original a year for a year and a half; increase the Party Congress representative, by leaving the party above (including leave probation) punishment, the party organization should be terminated its representative qualification provisions. The third chapter of the disciplinary rules of use prescribed in the discipline rectifying process, non convergence, not close hand classified as severely or heavier punishment. "Discipline straighten "At least eighteen years of five years, these five years is to pay close attention to the provisions of the central eight implementation and anti -" four winds ". The fourth chapter on suspicion of illegal party disciplinary distinguish five different conditions, with special provisions were madeprovisions, to achieve effective convergence of Party and country 9 method. < rule > the provisions of Article 27, Party organizations in the disciplinary review found that party members have committed embezzlement, bribery, dereliction of duty dereliction of duty and other criminal law act is suspected of committing a crime shall give cancel party posts, probation or expelled from the party. The second is < Regulations > Article 28 the provisions of Party organizations in the disciplinary review But found that party members are stipulated in the criminal law, although not involved in a crime shall be investigated for Party discipline and responsibility should be depending on the specific circumstances shall be given a warning until expelled punishment. This situation and a difference is that the former regulation behavior has been suspected of a crime, the feeling is quite strict, and the latter for the behavior not involving crime, only the objective performance of the provisions of the criminal code of behavior, but the plot is a crime to slightly. < Regulations > the 29 provisions, Party organizations in the discipline review found that party members and other illegal behavior, affect the party's image, the damage to the party, the state and the people's interests, we should depend on the situationSeriousness given disciplinary action. The loss of Party members, seriously damaging the party's image of behavior, should be given expelled from the party. At this article is party member is in violation of the criminal law outside the other illegal acts, such as violates the public security administration punishment law, customs law, financial laws and regulations behavior. The fourth is < cases > Article 32 stipulates, minor party members and the circumstances of the crime, the people's Procuratorate shall make a decision not to initiate a prosecution, or the people's court shall make a conviction and exempted from criminal punishment shall be given within the party is removed from his post, probation or expelled from the party. Party members and crime, sheets were fined in accordance with For acts; the principal Ordinance amended the provisions of the preceding paragraph. This is the new content, in order to achieve Ji method effective convergence. Five is < > the thirty third article 10 of the provisions, the Party member due to an intentional crime is sentenced to criminal law (including probation) sheets or additional deprivation of political rights; due to negligence crime and was sentenced to three years or more (excluding three years) a penalty, shall give expelled punishment. Due to negligence crime is convictedand sentenced to three years (including three years) in prison or be sentenced to public surveillance, detention, shall in general be expelled from the party. For the individual may not be expelled from the party, should control Approval. This is followed and retained the original > < Regulations the provisions of punishment party authorization rules and report to a level party organizations. For is "party members with criminal acts, and by the criminal punishment, generally should be expelled from the party". The fifth chapter of probationary Party member of the discipline and discipline after missing members of the treatment and punishment decisions, such as the implementation of the provisions, clear the related party discipline and punishment decision made after, for duties, wages and other relevant alteration formalities for the longest time. 2, sub sub section will the original regulations of10 categories of acts of violation of discipline integration revised into 6 categories, respectively, in violation of the punishments for acts of political discipline "in violation of discipline behavior of punishment" in violation of integrity of disciplinary action points "of violation punishments for acts of mass discipline" "the violation of work discipline, punishment" in violation of discipline of life behaviorpunishment "6 chapters. 3, annex" Supplementary Provisions "clear authority making supplementary provisions of, cases of interpretative organ, as well as regulations implementation time and retroactivity etc.. 11 (3) learning understanding > < regulations needs to grasp several key problems The first problem -- about the violation of political discipline behavior > < new ordinance chapter 6 the political discipline column for the six disciplines, that is the main opposition to Party leadership and the opposition of the basic theory, basic line, basic program and basic experience, basic requirements of misconduct made provisions of the disposition, especially the eighteen since the CPC Central Committee put forward the Yan Mingzheng treatment of discipline and political rules requirements and practical achievements transformation for Discipline article, increase the false debate central policies, cliques, against the organization review, make no discipline of the principle of harmony terms. These are the party's eighteen years in comprehensive strictly Process combined with the practice of rich content. (1) false debate the central policies and undermine the Party of centralized and unified the problem is made in accordance with the provisions of the party constitution. Constitution in general programme requirementsadhere to democratic centralism is one of the requirements of the construction of the party must adhere to the four cardinal. Application of this principle is not only the party the basic organization principle and is also the mass line in party life, it requires that we must fully develop inner-party democracy, respect for the dominant position of Party members, safeguarding the Party member democratic rights, give full play to the enthusiasm and creativity of the party organizations at all levels and Party members, at the same time, also must implement the right concentration, ensure the party's mission < the chaos in unity and concerted action to ensure that the party's decision to get quickly and effectively implementing. The Party Central Committee formulated the major principles and policies, through different channels and ways, fully listen to the party organizations and Party members of the opinions and suggestions, but 12 is some people face to face not to say back blather "" will not say, after the meeting said, "" Taiwan does not say, and nonsense ", in fact, not only disrupt the people thought, some causing serious consequences, the damage to the Party of the centralized and unified, hinder the central policy implementation, but also a serious violation of the democratic system of principles. There is no doubt that shall, inaccordance with the Regulations > 4 Specified in Article 6 to give the appropriate punishment. For did not cause serious consequences, to give criticism and education or the corresponding tissue processing. (2) about the destruction of the party's unity < New Regulations > the forty eighth to fifty second article, to damage Party's unity unified and violation of political discipline, punishment situation made explicit provisions. Article 52 of the new "in the party get round group, gangs seek private gain, cliques, cultivate private forces or through the exchange of interests, for their own to create momentum and other activities to gain political capital, given a serious warning or withdraw from their party posts disposition; if the circumstances are serious, to give Leave a party to observation or expelled from the party. (3) on against the organization review of the provisions of the constitution, party loyalty honesty is party members must comply with the obligations. Members must obey the organization decision, shall not violate the organization decided encounters by asking questions to find organization, rely on the organization, shall not deceive the organization, against the organization. For example, after the investigation does not take the initiative to explain the situation, but to engage inoffensive and defensive alliance, hiding the stolen money is against survey organization, is a violation of the behavior of political discipline. Article 24 of the original > < Regulations, although the provisions of the interference, hinder group review the behavior of the fabric can be severely or 13 Aggravated punishment, but did not put this kind of behavior alone as a discipline for qualitative amount of discipline. > < new regulations increase the Article 57, "anti organization review, one of the following acts, given a warning or serious warning; if the circumstances are relatively serious, giving removed from or placed on probation within the party post; if the circumstances are serious, give expelled from the party: (a) on supply or forged, destroyed, transfer, conceal evidence; (II) to prevent others expose, providing evidence Material; (III) harboring co personnel; (4) to the organization to provide false information, to hide the fact;(5) the him against the acts of the organization review. "< rule > add this clause to the Constitution requires more specific, the previous no punishment in accordance with the definite list and put forward clear punishment in accordance with. (4) about organizing or participating in superstitious activities as < Regulations > about engage in activities of。
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
检查各导电回路带电部件之间及其金属结构件之间，母线与母线之间的绝缘电阻
绝缘电阻相间.相对地均不小于5MΩ
低压配电设备出厂检验记录
序号
检验项目
检验内容及方法
标准要求
实测值
一次
合格
修后
合格
2
机械操作验证
1）装置中所有手动操作部件等操作5次。
2）按照原理图要求，进行通电试验5次。
(1)手动操作机构灵活，无卡滞，操作力过大等现象。
XXX交流低压配电柜
产品出厂检验报告
产品编号
产品名称
产品型号规格
额定电流
检验员
XXXX电器有限公司
20年月日
低压配电设备出厂检验记录
产品型号：电流（A）：出厂编号：文件号：XXXXXX
序号
检验
项目
检验内容及方法
标准要求
实测值
一次
合格
修后
合格
1
一般检查
1）外观质量
柜体内外喷漆质量
柜体正面是无反射的桔形漆，正面和侧面涂层不允许有皱纹、气泡、透底等缺陷。色泽均匀，无明显刷痕、伤痕、机械杂质，表面漆色一致。
所有电镀层质量
镀层牢固，无起皮、发霉、生锈等现象。
连接柜架外壳连接件的紧固螺钉应拧紧，有防松措施。
柜架紧固螺钉拧紧，有防松措施。
2）电器元件
按设计图核对柜内所有元器件型号规格及参数，且元件为进厂合格品。
操作机构运行方向有明显标志。
(1)柜内安装的元件为进厂合格品。
(2)元件型号规格及参数符合图纸和产品描述报告。
(3)元件的安装调整符合有关技术文件要求。
(4)操作机构运动方向应在操作处有明显标志，且运动方向符合有关技术要求规定。
3）母线与二次回路
检查母线规格及加工质量。
检查二次回路导线规格及配线质量。
(1)母线及二次回路导线符合设计图纸要求。
(2)一次元件接线正确，母线排列整齐美观，搭接面平整，不平度不大于0.5mm，且自然吻合，有防松防电化腐蚀措施。
(2)通电试验，一、二次线路正确，符合原理图要求。
(3)主开关在85%和110%额定电压下吸合动作可靠，在65%~110%分闸和35%~70%失压脱扣动作可靠
(4)电子式脱扣器参照开关技术参数进行
3
介电强度验证
主电路及与主电路直接连接的辅助电路试验电压为：（V）
2500V，1s，无闪烙、无击穿
不与主电路直接连接的辅助电路试验电压为：（V）
2000V，1s，无闪烙、无击穿
4
保护电路连续性验证
测量主接地点与保护电路任一点之mΩ。
检查接地符号是否明显牢固。
(1)柜架操作机构以及内部主电路所装元件需接地的部位均保证良好的接地连续性。
(2)骨架有明显的接地标记。
(3)有接地装置专用的螺栓和垫圈。
5
铭牌检查
产品名称、型号、生产厂名称等与3C证书一致。
6
结论：
检验员（签字）：年月日
注：一次合格、修后合格记为“√”，一次不合格、修后不合格记为“×”。有“*”号为直接判产品不合格。
检验标准：GB7251.1-2005
(3)二次回路接线正确，配线整齐美观，标号清楚。
(4) 母线及二次回路导线均符合工艺求。
4）间隙和爬电距离
检查各导电回路带电部件之间及其金属结构件之间，母线与母线之间的电气间隙和爬电距离。
(1)母线与母线之间，元件进出线端子之间的电气间隙不小于8mm。
(2)母线与母线之间，元件进出线端子之间的爬电距离不小于12.5mm。