动力电池材料安全数据表
LG 电池安全性数据表说明书
MATERIAL SAFETY DATA SHEETINR18650 Lithium-Ion BatteryLG CHEMICAL LIMITED1.Chemical Product and Company IdentificationProduct IdentificationINR18650 MJ1 (12.5Wh) Lithium-Ion BatteryManufacturerLG Chem LimitedTwin TowerYouido-Dong, Youngdeungpo-KuSeoul, KoreaEmergency Telephone Number82-2-3773-7417position InformationHazardous Ingredients % CAS Number Aluminum Foil 2-10 7429-90-5Nickel compound (proprietary) 0-80Manganese compound (proprietary) 0-15Cobalt compound (proprietary) 0-15Styrene-Butadiene-Rubber <1Polyvinylidene Fluoride (PVDF) <5 24937-79-9Copper Foil 2-10 7440-50-8Carbon (proprietary) 10-30 7440-44-0Electrolyte (proprietary) 10-20Steel, Nickel and inert materials Remainder N/A3. Hazards IdentificationPrimary routes of entrySkin contact :NOSkin absorption : NO Eye contact : NO Inhalation : NO Ingestion : NOSymptoms of exposureSkin contactNo effect under routine handling and use.Skin absorptionNo effect under routine handling and use.Eye contactNo effect under routine handling and use.InhalationNo effect under routine handling and use.Reported as carcinogen Not applicable4.First Aid MeasuresInhalationNot a health hazard.Eye contactNot a health hazard.Skin contactNot a health hazard.IngestionIf swallowed, obtain medical attention immediately.IF EXPOSURE TO INTERNAL MATERIALS WITHIN CELL DUE TO DAMAGED OUTER CASING, THE FOLLOWING ACTIONS ARE RECOMMENDED ;InhalationLeave area immediately and seek medical attention.Eye contactRinse eyes with water for 15 minutes and seek medical attention.Skin contactWash area thoroughly with soap and water and seek medical attention.IngestionDrink milk/water and induce vomiting; seek medical attention.5.Fire Fighting MeasuresGeneral HazardCell is not flammable but internal organic material will burn if the cell is incinerated. Combustion products include, but are not limited to hydrogen fluoride, carbon monoxide and carbon dioxide.Extinguishing MediaUse extinguishing media suitable for the materials that are burning.Special Firefighting InstructionsIf possible, remove cell(s) from fire fighting area. If heated above 125°C, cell(s) may explode/vent.Firefighting EquipmentUse NIOSH/MSHA approved full-face self-contained breathing apparatus (SCBA) with full protective gear.6.Accidental Release MeasuresOn LandPlace material into suitable containers and call local fire/police department.In WaterIf possible, remove from water and call local fire/police department.7.Handling and StorageHandlingNo special protective clothing required for handling individual cells.StorageStore in a cool, dry place.8.Exposure Controls / Personal ProtectionEngineering controlsKeep away from heat and fire. Keep in a cool and dry place.Personal ProtectionRespiratorNot required during normal operations. SCBA required in the event of a fire.Eye/face protectionNot required beyond safety practices of employer.GlovesNot required for handling of cells.Foot protectionSteel toed shoes recommended for large container handling.9.Physical and Chemical Properties10.Stability and ReactivityReactivityNoneIncompatibilitiesThere are nothings during a normal operation. Avoid exposure to heat, open flame, and corrosives.Hazardous Decomposition ProductsThere are nothings during normal operating conditions. If cells are opened, hydrogen fluoride and carbon monoxide may be released.Conditions to AvoidAvoid exposure from heat and fire. Do not puncture, crush, and incinerate. 11.Toxicological InformationThis product does not contain elicit toxicological properties during routine handling and using.If cells are opened through misuse or damage, do discard immediately. Internal components of cell are irritants and sensitizers.12.Ecological InformationSome materials within the cell are bioaccumulative. Under normal conditions, these materials are sealed into cell, and then there is no risk to persons or the surrounding environment.13.Disposal ConsiderationsCalifornia regulated debrisRCRA Waste Code : NonregulatedDispose of according to all federal, state, and local regulations.14.Transport InformationLithium Ion batteries are considered to be "Rechargeable batteries" and meet the requirements of transportation by the U.S. Department of Transportation(DOT), the International Civil Aviation Administration(ICAO), the International Maritime Dangerous Goods (IMDG) Code.Even classified as lithium ion batteries (UN3480), 2016 IATA Dangerous Goods Regulations 57th edition Packing Instruction 965 Section IB or II is applied.The general and additional requirements apply to all lithium ion cells and batteries prepared for transport according to this packing instruction:1) Section IB applies to lithium ion cells with a Watt-hour rating not exceeding 20Wh and lithium ion batteries with a Watt-hour rating not exceeding 100 Wh packed in quantities that exceed the allowance permitted in Section II, Table 965-II; and2) Section II applies to lithium ion cells with a Watt-hour rating not exceeding 20Wh and lithium ion batteries with a Watt-hour rating not exceeding 100 Wh packed in quantities not exceeding the allowance permitted in Section II, Table 965-II.Cells and/or batteries specified in columns 2, 3 and 4 of Table 965-II must not be combined in the same package.Each cell or battery is of the type proven to meet the requirements of each test in the UN Manual of Tests and Criteria Part 3 subsection 38.3.The product has been evaluated according to the UN Manual of Tests and Criteria.15.Regulatory InformationThis product is not hazardous under the criteria of the Federal Occupational Safety and HealthAdministration(OSHA) Hazard Communication Standard.(29 CFR 1910.1200)IATA Dangerous Goods Regulations 57th Edition Effective 1 January 2016.Hazardous Non-hazardous。
EVE Energy Co., Ltd 锂氧化钙电池产品安全与可靠性数据表说明书
Lithium-Thionyl Chloride (Li-SOCl 2) Battery 1/6 Document Number: RD-ER-201401-001Issued date: 3 January 2014PRODUCT SAFETY DATA SHEET1. Product and Company IdentificationProduct Category: Lithium-Thionyl Chloride (Li-SOCl 2) BatteryNominal Voltage: 3.6 V Product NameType Lithium (gr .)ER14250 0.31 ER14335 0.43 ER14505 0.70 ER17505 0.93 ER14250M 0.19 ER14335M 0.34 ER14505M 0.52 ER17505M 0.73 ER18505M0.91Supplier’s Name: EVE Energy Co., Ltd Supplier’s Address: EVE Industrial Park, Xikeng Industrial Zone, Huihuan Town, Huizhou,Guangdong, China.Post Code : 516006Emergency Telephone: (+86) -752-2606966 Fax: (+86) -752-2606033Note: The battery is neither substance nor mixture but product and having no risk to life and healthunder normal use or transportation because ingredients of battery is not leaked out by virtue of hermetical sealing with metal case.This sheet notifies possible risk of our battery under abnormal use but mainly aim to provideinformation about ingredients, notification of handling and transportation regulations as a useful reference.2. Hazards identificationThe important hazards andadverse effects of the chemical productNo information available Chemical product – specific hazardsNo information availableOutline of an anticipated emergencyChemical contents are seal in metal can. Therefore, risk of exposure never occursunless battery is mechanically or electrically abused.Risk of explosion by fire is anticipated if batteries are dispose of in fire or heated above 100 degree Celsius. Stacking or jumbling of batteries may cause external short circuits, heat generation, in some case, allowing fire or explosion.Note: our battery is not classified in accordance with the GHS classification.TypeLithium (gr .)ER22G68（BEL ） 0.10 ER32L65（1/10D ） 0.26 ER32L100（1/6D ） 0.44 ER1860 0.07 ER2450T0.13 EF651615（LTC-3PN ） 0.10 EF651620（LTC-5PN ） 0.14 EF651625（LTC-7PN ） 0.19 EF703228（LTC-16PN ）0.41SDS-0072 OM-CP-BAT107position/Information on IngredientMaterial CAS# % wt.Lithium metal 7439-93-2 0.13~3.7Thionyl Chloride electrolyte (mixture with organicsolvent)——18~38 Carbon 1333-86-4 1.8~4.2 4.First-aid measuresInhalation If ingredient leaked out from inside of a battery and if inhaled it, move to a place where fresh air is provided. Refer for medical attention.Skin contact If ingredient leaked out from inside of a battery and stuck on skin, wash the contact areas off immediately with plenty of water and soap. If appropriate procedures are not taken, this may cause sores on the skin. Refer for medical attention.Eyes contact If ingredient leaked out from inside of a battery and came into eyes, flush the eyes with plenty of water for at least 15 minutes immediately without rubbing. Take a medical treatment. If appropriate procedures are not taken, this may cause an eye irritation.Swallowing In case of swallowing of battery, immediately refer for medical attention.5.Fire-fighting MeasuresFire extinguishing agent:Dry chemical, alcohol-resistant foam, powder, atomized water, carbon dioxide and dry sand are effective.Extinguishing method:Escape batteries to safe place prevent from ignition by spreading fire.Because of packing material of battery is paper, use water extinguisher, CO2 extinguisher or powder extinguisher as normal extinguisher.Since vapor, generated from burning batteries may make eyes, nose and throat irritate, be sure to extinguish the fire on the windward side. Wear the respiratory protection equipment in some cases.6.Accidental Release MeasuresChemical contents are sealed in metal can. But if the battery is mechanically or electrically abused, contents may leak out. In such case, take action as shown below.Personal precautions: Temporary inhalation of odor and attaching of electrolyte to skin does notcause serious health hazard. Be sure the ventilation and washing out ofelectrolyte quickly.Environmental precautions:Clean up it quickly. Specific environmental precaution is notnecessary.Method and materials for containment and methods and materials for cleaning up:Contain and collect spillage and place in container for disposal according to local regulations.7.Handling and StorageHanding Do not charge, short-circuit, disassemble, deform, heat above 100℃or incinerate.Do not pile up or mingle battery with each other.Do not place battery on metal case, metal plate or antistatic material.In case of multi cell application, replace all batteries to new at once when replacing used batteries.Storage Be sure to store batteries in well-ventilated, dry and cool conditions.Keep away from water, rain, snow, frost or dew condensation.Do not store batteries near source of heat or nozzle of hot air.Do not store batteries in direct sunshine.Take care not to get wet packing by dew condensation when packing is removed from cold to warm and humid condition.Enough number of fire fighting apparatuses should be installed in warehouse8.Exposure Controls and Personal ProtectionThere is no need of personal protective equipment on regular handling and storage. In the event, however, a large amount of electrolyte should be released by mechanical or electrical abuse, use the protection as shown below.Respiratory protection: Mask (with a filter preferably)Hand protection : Synthetic rubber glovesEye protection : Goggles or glasses9.Physical and Chemical PropertiesState：SolidShape: Cylindrical、Prismatic10.Stability and ReactivityStability: Stable on regular handlingConditions to Avoid: External short circuit of battery, deformation by crush, exposure at hightemperature of more than 100 degree C (may cause heat generation andignition), direct sunlight, high humidity.Materials to avoid: Substances that cause short circuit.11.Toxicological InformationInhalation, skin contact and eye contact are possible when the battery is opened. Exposure to internal contents, the corrosive fumes will be very irritating to skin, eyes and mucous membranes.Overexposure can cause symptoms of non-fibrotic lung injury and membrane irritation.12.Ecological InformationPersistence and degradability No information availableMobility in soil No information available13.Disposal ConsiderationsDispose of batteries in accordance with applicable federal, state and local regulations.For safety precaution, battery should be insulated in proper manner; covering both terminals by tape, wrapping of battery in insulative bag or packing battery in original package is recommended in order to prevent ignition due to short-circuit.14.Transport InformationFor the international transport of lithium batteries, they must comply with these regulations: the International Maritime Dangerous Goods (IMDG) Code by International Maritime Organization (IMO), Dangerous Goods Regulations (DGR) by International Air Transport Association (IATA) and Technical Instructions for the Safe Transport of Dangerous Goods by Air (TI) by International Civil Aviation Organization (ICAO). These regulations are based on the UN Recommendations on the Transport of Dangerous Goods, Manual of Tests and Criteria.Lithium batteries which meet the requirements of UN38.3 (UN Manual of Tests and Criteria, Part Ⅲ, subsection 38.3) could be transported by air and by sea as ordinary goods, otherwise should be transported according to Class 9, Packing Group Ⅱhazardous goods.As the published of the UN Recommendations on the Transport of Dangerous Goods, all these regulations have added some new contents to regulate the transport of lithium metal batteries. And they should be complied since 1January 2009. Following the latest changes on Lithium Cells / Batteries shipment as per the 55th edition of IATA Dangerous Goods Regulations, the Lithium Battery Best Practice 014 will replace Best Practice 013 and with effect from 1 January 2014.1. For lithium metal batteries, UN ID number is 3090. For lithium ion batteries contained inequipment or lithium ion batteries packed with equipment, UN ID number is 3091.2. The consignment should be fully described by proper shipping name and packed, marked and inproper condition for carriage by air. The consignment is not classified as dangerous under the current edition of the IATA 55th Effective, Dangerous goods regulation and all applicable carrier and government regulations.3. For transported air, Lithium-metal Cells/Batteries shipped as “Not Restricted” Cargo: Must complywith Section Ⅱof PI968-P1970 accordingly; For cells, the lithium content should not be more than 1g; for batteries, the lithium content should not be more than 2g. Lithium content must be marked on the outside of the battery case (marked by manufacturer).4. Each consignment must be accompanied with a document such as an air waybill with anindication. For those Lithium metal cells/batteries contained in equipment, the equipment must be equipped with an effective means of preventing accidental activation.5.The net quantity of lithium –metal battery（cells），shall not exceed 2.5kg if transport as PI 968,andneed to paste the Li-metal battery marking and Class 9 hazardous goods marking; The net quantity of lithium-ion battery (cells) shall not exceed 5kg if transport as PI 969 or PI 970; andneed to paste the Li-metal battery marking.6.Each package must be capable of withstanding a 1.2m drop test in orientation without damage ofcells or batteries contained therein.7. Lithium batteries which meet the requirements of which could be transported by air, and thebatteries manufactured by EVE Energy Co., Ltd meet these requirements. (Lithium batteries identified by the manufacturer as being defective for safety reasons, or that have been damaged, that have the potential of producing a dangerous evolution of heat, fire or short circuit are forbidden transport.)8.Cells and batteries must be protected so as to prevent short circuits. This includes protectionagainst contact with conductive materials within the same packing that could lead to short circuit.9.Lithium –metal battery is applicable to the International Maritime Dangerous Goods Code(IMDG-Code) Special provision 188 because it corresponds to either case that the cell – lithium content is less than 1g or the battery – lithium content is less than 2g, so it is permitted to transport as Exempted Dangerous Goods when it complies with all requirements of the transport conditions.UN No. Proper Shipping Name/Description3090 Lithium metal batteries3091 Lithium metal batteries contained in equipment3091 Lithium metal batteries packed with equipmentRelated regulations: Following regulations shall be cited and considered.Transportations Related organization / Issue documentsAir transport (by airplane) ICAO (International Civil Aviation Organization) / TI (Technical Instruction) IATA (International Air Transport Association) / DGR (Dangerous GoodsRegulations)﹡1Maritime transport(by ship) IMO (International Maritime Organization) / IMDG Code (International Maritime Dangerous Goods Code) ﹡2Land transport (Intra-European) RID (International Carriage of Dangerous Goods by Rail) , ADR (International Carriage of Dangerous Goods by Road)USA / UN USDOT (US Department of Transportation) / DOT 49 CFR (US law)UN: Recommendations on the transport of dangerous goods: Manual of Tests and Criteria 5th revised edition Amendment 1 [ST/SG/AC.10/11/Rev.5/Amend.1]: Part III, Subsection 38.315.Regulatory InformationEnvironment-related law of batteries: EU nations have applicable law in accordance with Directive 2006/66/EC and other some countries, China, Korea, Brazil, some provinces of USA and Canada or so have similar law.16.Other informationReferenceIATA Dangerous Goods Regulations, latest editionNotes on this sheet*1 Dangerous Goods Regulation – 55th Edition Effective 1 January 2014: International Air Transport Association (IATA)*2 IMDG Code -2010 Edition: International Maritime Organization (IMO)This sheet refers to normal use of the product in question. EVE Corp. makes no warranty expressed or implied。
锂电池MSDS
熔点
-61℃
外观及性状：无色液体，具有难闻的鱼腥味。
稳定性/禁忌物：
中文别名 英文别名 溶解度 沸点
甲酰二甲胺
DMF；Formyldimethylamine
溶 相对密度 0.94
152.8℃ 闪点
58℃
pH
弱碱
四氯化物、卤化物、铁、强氧化剂、烷基铝。 对人体危险性/症状：
火／爆炸：易燃，容器在火中易爆。 侵入途径：蒸气吸入，皮肤和眼睛接触，皮肤吸收。 健康危害：短期暴露：在 20ppm 以下暴露 32 周，引起恶心、呕吐、腹部绞痛、肝大；高 浓度暴露引起高血压、食欲下降、便秘、腹泻、兴奋，并伤肝、肾；接触则强烈刺激眼睛和 粘膜；长期反复暴露，刺激皮肤，引发皮疹。
泄露处理：
从事故发生地撤离所有人员。使用特殊防护设备。如果泄漏发生在用户设备内部，使用 惰性气体保护。
废弃处置：
无法再利用的废弃物应用适当的、被认可的处理设施及方法进行处理，其容器及未使用 过的物质按国家或当地的要求进行处理。
运输： 没有明确规定。
材料安全性数据表（MSDS）
编号：01-054
中文名称
∞ 56.24℃
相对密度 闪点 pH
0.79(d4/20 -20)℃
中性
稳定性/禁忌物：氧化物、酸。 对人体危险性/症状：
侵入途径：吸入、食入、皮肤及眼睛接触。 健康危害：刺激眼、鼻、咽喉，出现头痛、头晕和皮炎。
急救措施：
火／爆炸：用二氧化碳、干粉、泡沫或四氯化碳灭火器，喷水冷却着火容器，以免爆炸。 眼接触：用清水冲洗。 皮肤接触：用肥皂、水冲洗；沾染后，立刻更换衣服。 吸入：将患者移至新鲜空气处，施行人工呼吸。 食入：误服后，给饮大量水催吐(昏迷者例外)，就医。 防护措施（建议）：
新能源电池BOM表新材料、电芯及部分辅材
电导率
状态（气态/液态）
状态（液态）
关键属性三
比表面积 比表面积
比表面积 绝缘等级(高/低) 固含量
纯度(99.999%/99.9%) 纯度（无水/分析纯/化学纯/色谱纯/ 纯度（85%）
关键属性四
杂质含量 振实密度 振实密度 标识(数字/无)
类别（绝缘袋/绝缘片/止动架） 主成分（PVDF/SBR） 主成分(NMP) 主成分 主成分(CMC) 主成分(氧气/氮气/氩气/氢气/氢气氮气混合气体/氩气/甲烷 混合气体/干燥空气) 主成分（甲醇/乙醇) 主成分（磷酸）
关键属性二 纯度 纯度 纯度 纯度 纯度 纯度 纯度 纯度 电导率 粒径 尺寸（厚度*宽度） 尺寸（厚度*宽度） 尺寸（厚度*宽度） 粒径（D10、D50、D90） 子部件(铝壳/盖板/钢珠) 尺寸（厚度*宽度）
大类 原材料
中类
小类
草酸亚铁
磷酸二氢铵
冰糖
新材料物料
碳酸锂 偶联剂
二氧化钛
磷酸二氢锂
磷酸铁
导电剂
负极材料
箔材
极耳
隔膜
正极材料
电芯材料
壳体组件 胶带
绝缘防护辅
பைடு நூலகம்
件
粘结剂
溶剂
电解液
分散剂
辅助材料 气体 （部分） 化学溶剂
酸碱
关键属性一 主成分（草酸亚铁） 主成分（磷酸二氢铵） 主成分（冰糖） 主成分（碳酸锂） 主成分（醋酸镁/异丙醇钛） 主成分（二氧化钛） 主成分（磷酸二氢锂） 主成分（磷酸铁） 主成分（碳黑/KS_6/碳纳米管/石墨烯） 主成分(石墨/硅碳) 主成分(铝箔/铜箔/涂炭铝箔) 主成分(铜带/铝带) 主成分（PP/PE/PP-PE-PP/涂层隔膜） 主成分(LFP/NCM111/NCM523/NCM622) 尺寸（厚度*宽度*高度） 颜色（茶色/绿色透明）
维克顿能源 LiFePO4 锂磷电池安全数据表说明书
Victron Energy Batterie SICHERHEITSDATENBLATTLithium SuperPack 12,8V/20Ah, 60Ah, 100Ah, 200Ah, 25,6V/50AhABSCHNITT 2 - ZUSAMMENSETZUNG/INFORMATIONEN ZU DEN INHALTSSTOFFENInhaltsstoff G ewicht % CAS-Nr. EC-Nr. Phosphat 26 % -- PVDF 1,5 % 24937-79-9 -Graphit 13 % 7782-42-5 231-955-3 CMC 0,2 % 07.11.9000 -Al 6% 7429-90-5 231-072-3 Cu10 % 7440-50-8 231-159-6 PP-Separator 2,1 % -- Stahl 20 % - - Elektrolyt16 % - - Schrumpffolie PVC 0,03 % - - PP Dichtungsring0,05 %--GEBRÄUCHLICHE BEZEICHNUNG: (auf dem Etikett verwendet) Lithium-Ionen-BatterieABSCHNITT 6 - MASSNAHMEN BEI UNBEABSICHTIGTER FREISETZUNGWasser durchnässen oder mit reichlich Wasser besprühen. Nachdem sie abgekühlt ist, in einen genehmigten Behälter geben und in Einklang mit den örtlichen Bestimmungen entsorgen.Persönliche Sicherheitsmaßnahmen: Säureresistente Schürzen, Stiefel und Schutzkleidung. Durch die ANSI genehmigte Schutzbrillen mit Seiten-/Gesichtsschutz empfohlen.ABSCHNITT 11 - TOXIKOLOGISCHE ANGABENWiederaufladbare Lithium-Batterien enthalten keine giftigen Materialien.ABSCHNITT 12 - TOXIKOLOGISCHE ANGABENBei normaler Nutzung bis zum Ende der Lebenszeit kann die Batterie recycelt werden und verursacht keinerlei Umweltverschmutzung. ABSCHNITT 13 - ENTSORGUNG1. In Einklang mit den geltenden Bestimmungen entsorgen. Diese können je nach Land unterschiedlich sein.2. Die Anschlüsse von Lithium-Ionen-Batterien sollten vor der Entsorgung isoliert werden und am besten sollten die Batterien einzeln inPlastiktüten verpackt werden.3. Batterien dürfen nur von autorisierten Entsorgungsstellen im Feuer entsorgt werden.ABSCHNITT 14 - TRANSPORT1. UN-NO.3480ARD /RIDKlasse 9 Verpackungsgruppe II ADR/RID-EtikettenKorrekte Versandbezeichnung Lithium-Ionen-Batterien, UN3480IMOKlasse 9 Verpackungsgruppe II IMO-EtikettenKorrekte Versandbezeichnung Lithium-Ionen-Batterien, UN3480IATA-DGRKlasse 9 Verpackungsgruppe II ICAO-EtikettenKorrekte Versandbezeichnung Lithium-Ionen-Batterien, UN34802. Victron Energy B.V. erklärt hiermit, dass das …UN Manual of Tests and Criteria“, Teil III, Untersektion 38.3 eingehalten wurde.3. In der Luftfracht werden kleine Lithium-Ionen-Batterien (Zellen<20 WH oder Packs>100 WH) als “Expected Lithium-ion Batteries” angesehen, wenn sie den Anforderungen der Ed. 63 der IATA Bestimmungen (UN3480) und ICAO Verpackungsanleitung 965 Abschnitt II entsprechen. Diese legen weniger als 10 kg Gesamtgewicht pro Paket fest. So gekennzeichnetes Versandgut kann als normale Fracht unter dem aktuellen IATA versandt werden.4. In anderen Fällen (insbesondere bei großen Zellen >20 WH oder Packs > 100 WH), gelten diese als Klasse 9 (Siehe Verpackungshinweis 965 Abschnitt I für Luftfracht).5. In der Seefracht gelten Lithium-Ionen-Batterien als "Lithium-ion-Batteries-Not Restricted", sofern sie den Anforderungen des IMDGfür IMO Gefahrgut-Regulierung (UN3480) entsprechen.6. Der Transport von wiederaufladbaren Lithium-Ionen-Batterien wird durch mehrere Stellen reguliert, beachten Sie: IATA, IMO, ADR/RID. ABSCHNITT 15 - BESTIMMUNGEN1. TemperaturbereichFortlaufend SofortLagerung Entladung Aufladen +25°C ±5°C30/80°C0/75°C-45/+85°C-45/+85°C-0/+75°C2. Spezifische Energie: (Hinweis: Wh = normale Spannung x Nenn-Ah) kg = Durchnittliches Gewicht der Batterie)3. Spezifische Pulsleistung: 600 w-1200 w/kg schwankt je nach Größe4. Mechanische Widerstandsfähigkeit: Wie in der IEC-Norm festgelegt.ABSCHNITT 16 - SONSTIGE INFORMATIONEN1. Diese Angaben wurden aus Quellen zusammengetragen, die als zuverlässig erachtet werden und dies geschah nach bestem Wissen und Gewissen und so genau und zuverlässig wie es zu dem Zeitpunkt der Erstellung möglich war. Jedoch wird keine Erklärung, Gewährleistung (weder ausdrücklich noch impliziert) noch eine Garantie bezüglich der Genauigkeit, Zuverlässigkeit oder Vollständigkeit der hier gemachten Angaben abgegeben.2. Diese Angaben beziehen sich auf die spezifisch aufgeführten Materialien und gelten möglicherweise nicht für solche Materialien, die in Kombination mit anderen Materialien oder in irgendeinem Verfahren verwendet werden. Es obliegt der Verantwortung des Nutzers selbst, sich ausreichend bezüglich der Eignung und Vollständigkeit dieser Angaben für seine jeweilige Nutzung abzusichern.3.Victron Energy B.V. übernimmt keinerlei Haftung für Verluste oder Schäden, die entweder direkt der indirekt, nebensächlich oder als Konsequenz aus der Nutzung dieser Angaben entstehen. Victron Energy B.V. bietet keine Gewährleistung gegenüber Patentverletzungen. Weitere Informationen sind telefonisch unter Angabe des beabsichtigten Zweckes möglich.。
动力电池材料安全数据表
材料安全数据表（上）
在所有情况下，都要立刻就医 .
接触眼睛: 用大量清水清洗至少15 分钟( 打开眼睛).
接触皮肤: 脱下被污染的衣物并用大量清水及肥皂清洗感染处至少15 分钟。
不要搽药膏
吞食: 用水冲淡它并立刻就医 .
确保感染者没有使用催吐剂
确保粘液没有阻隔呼吸道
不要给无意识的人吃其他东西
吸入: 到空气清新的地方并使污染区通风 .
如果必要的话，输氧或进行人工呼吸
5 –防止燃烧的办法
燃烧或冒烟危险：
除LFP 类电池外，LCP 、LMP 电池若被不当使用的情况下或受环境影响，在150 ℃的情况下会泄燃电解物质。
在火烧中可能会形成氟化氢(HF) 与磷氧化物，电解液中的LiPF 6 与水发生的化学反应
灭火媒介:用水喷淋或将冒烟的或起火燃烧的电池浸泡在水中。
可使用的:………… D 型灭火器, Co2, 干燥化学物或泡沫灭火器
特殊危险:由于外部影响或不当使用导致的电池过热，电解液泄漏，或电池破裂可能会导致泄漏电池内部接触眼睛:电池内部的电解液对眼睛会产生刺激。
接触皮肤:电池内部的电解液可能会导致皮肤感染。
吞食:吞食电解液可能会导致喉咙或呼吸道感染。
吸入:电池泄漏或破裂时，其内部成分可能会导致呼吸道粘液，隔膜或水肿。
特殊保护工具:使用呼吸设备来避免吸入刺激性气体。
穿防护衣或用其他装置来避免身体接触到电解液。
电池内部成分只有在滥用的情况下才有可能被泄漏。
浸泡在水中或用大量的水冲洗，放置在合适的容器
中( 如果必要的话在其经过冷却之后) ，根据当地规定处理。
潘森高能电池产品安全数据表说明书
This product is used in a hermetically sealed state. So, it is not an object of the SDS system. This document is provided to customers as reference information for the safe handling of the product. The information and recommendations set forth are made in good faith and are believed to be accurate at the date of preparation. Panasonic Corporation makes no warranty expressed or implied.PRODUCT SAFETY DATA SHEET1 Chemical product and company identificationName of Product : Lithium Iron Disulfide battery FR6 (FR14505), FR03 (FR10G445)Name of Company : Panasonic Energy Co., Ltd.Address : 1-1Matsushita-cho, Moriguchi-city, Osaka, 570-8511, JapanEmergency Contact : +81-80-9932-3190 (JST Working hours)+81-6-6991-1141 (Holiday)2Hazards identificationGHS Classification : No applicableToxicity : Vapor generated from burning batteries, may irritate eyes, skin and throat.Hazard : Electrolyte and lithium metal are inflammable.Risk of explosion by fire if batteries are disposed in fire or heated above 100degrees C.Stacking or jumbling batteries may cause external short circuits, heatgeneration, fire or explosion.3Composition/information of ingredientsComponent Material CAS RN Content •i%•jPositive electrode Iron disulfide 1317-37-9 24 - 35 Carbon black 133-86-4 0 - 4 Graphite 7782-42-5 0 - 4Negative electrode* Lithium or Lithium alloy 7439-93-2 6.7 •iFR6) 6.6 •iFR03•jElectrolyte 1,2-dimethoxyethane 110-71-4 2 - 4 1,3-dioxolane 646-06-0 5 - 9 Lithium iodide - 0.3 - 3(Remarks) * Each size contains less than 1 gram of lithium per cell.4First aid measures (in case of electrolyte leakage from the battery)Eye contact : Flush the eyes with plenty of clean water for at least 15 minutesimmediately, without rubbing. Get immediate medical treatment.If appropriate procedures are not taken, this may cause eye injury.Skin contact : Wash the affected area under tepid running water using a mildsoap. If appropriates procedures are not taken, this may cause soreson the skin. Get medical attention if irritation develops or persists.Inhalation: Remove to fresh air immediately. Get medical treatmentimmediately.5 Firefighting measuresFire extinguishing agent : Alcohol-resistant foam and dry sand are effective.Extinguishing method : Be sure on the windward to extinguish the fire, since vapor maymake eyes, nose and throat irritate, Wear the respiratory protectionequipment in some cases.6Accidental release measures (in case of electrolyte leakage from the battery)Take up with absorbent cloth, treat cloth as inflammable.Move the battery away from the fire.7 Handling and storageHandling : žWhen packing the batteries, do not allow battery terminals tocontact each other, or contact with other metals. Be sure to packbatteries by providing partitions in the packaging box, or in aseparate plastic bag so that the single batteries are not mixedtogether.žUse strong material for packaging boxes so that they will not bedamaged by vibration, impact, dropping and stacking duringtheir transportation.žDo not short-circuit, recharge, deform, throw into fire ordisassemble.žDo not mix different type of batteries.žDo not solder directly onto batteries.žInsert the battery correctly in electrical equipment.Storage : •E Do not let water penetrate into packaging boxes during theirstorage and transportation.•E Do not store the battery in places of the high temperature orunder direct sunlight.žPlease also avoid the places of high humidity. Be sure not toexpose the battery to condensation, rain or frozen condition8.Exposure controls and personal protectionAcceptable concentration : Not specified about Lithium Battery.Facilities : Nothing in particularProtective Equipment (in case of electrolyte leakage from the battery)Respiratory Protection : For most condition no respiratory protection.Hand Protection : Safety gloves.Eye Protection : Safety goggle9.Physical and chemical propertiesAppearance : Cylindrical shapeNominal Voltage : 1.5 V10. Stability and reactivitySince batteries utilize a chemical reaction they are actually considered a chemical product.As such, battery performance will deteriorate over time even if stored for a long period of time without being used. In addition, the various usage conditions such as discharge, ambient temperature, etc. are not maintained within the specified ranges the life expectancy of the battery may be shortened or the device in which the battery is used may be damaged by electrolyte leakage.11.Toxicological informationSwallowing can lead to chemical bums, perforation of soft tissue, and death. Severe bums can occur within 2 hours of ingestion. Seek medical attention immediately.12.Ecological informationIn case of the worn out battery was disposed in land, the battery case may be corroded, and leak electrolyte. However, there is no environmental impact information.Mercury (Hg), Cadmium (Cd) and Lead (Pb) are not used in cell.13.Disposal considerationsWhen the battery is worn out, dispose of it under the ordinance of each local government.14.Transport informationHandlingDuring the transportation of a large amount of batteries by ship, trailer or railway, do not leave them in the places of high temperatures and do not allow them to be exposed to condensation.During the transportation do not allow packages to be dropped or damaged.Proper shipping name : Lithium metal batteriesUN Number, UN Class : UN3090, Class9 (for the Air transport by PI968 Section IA or IB): Exemption (for the Marine transport SP188 and the Air transportby Section II of PI 969 or 970)Even though the cells are classified as lithium metal batteries(UN3090 or UN3091), they are not subject to some requirements ofDangerous Goods Regulations because they meet the following:1. for cells, the lithium content is not more than 1 g ;2. each cell is of the type proven to meet the requirements of each test inthe UN Manual of T ests and Criteria, PartúL, sub-section 38.3.3. each cell is manufactured in ISO9001 certified factory.4. the test summary is available from;https:///ww/downloads/battery-test-summary Please refer to the following reference information about concrete ways of transportation. Actual content of packaging label and shipping documents varies by shipping companies. Make sure to confirm in advance with your shipping company.Information of referenceReference Packing Instruction(PI)/Special provision(SP)NoteAir transport IATA DGR PI 968 SectionúJ A Cells, Cargo Aircraft only; Net quantity perpackage Max. 35kgPI 968 SectionúJ B Cells, Cargo Aircraft only; net quantity perpackage Max. 2.5kgPI 969 SectionúK Cells packed with equipmentPI 970 SectionúK Cells contained in equipment Marine transport IMDG Code SP 18815.Regulatory information•E IATA Dangerous Goods Regulations Edition 64 (IATA DGR)•E IMO International Maritime Dangerous Goods Code 2020 and 2022 Edition (IMDG Code)•E UN Recommendations on the Transportation of Dangerous Goods, Model Regulations•E UN Recommendations on the Transportation of Dangerous Goods, Manual of Tests and Criteria •E EU Battery Directive•i2006/66/EC, 2013/56/EU)•E Regulation (EC) No. 1907/2006 on the Registration, Evaluation, Authorization and Restriction of Chemicals (REACH)•E State of California Regulations - Best management practices for Perchlorate Materials•E Act on Preventing Environmental Pollution of Mercury (Japan)16.Other informationThis PSDS is provided to customers as reference information in order to handle batteries safely.It is necessary for the customer to take appropriate measures depending on the actual situation such as the individual handling, based on this information.Prepared by: Engineering DepartmentEnergy Device Business DivisionPanasonic Energy Co., Ltd.。
聚合物锂离子电池 SL400926-T 商品安全说明表说明书
Report No.:PNS2011166711011材料安全数据表Material Safety Data Sheet货物名称:聚合物锂离子电池Name of Goods:Polymer Li-ion Battery委托单位:东莞山锂电池科技有限公司Commissioner:Dongguan Sunly Battery Technology Co.,Ltd广东联鼎检测科技有限公司GUANGDONG UTL CO.,LTD.材料安全数据表Material Safety Data SheetApproved by:Reviewed by：Tested by:批准：审核：主检：眼睛：万一接触，立即用大量的清水冲洗至少15分钟，翻起上下眼睑，直到化学的残留物消失为止，迅速就医. EyeFlush eyes with plenty of water for at least15minutes,occasionally lifting the upper and lower eyelids.Get medical aid.皮肤：万一接触，用大量水冲洗至少15分钟，同时除去污染的衣物和鞋子，迅速就医。
SkinRemove contaminated clothes and rinse skin with plenty of water or shower for15minutes.Get medical aid.吸入：立即从暴露处移至空气清新处，如果呼吸困难给予输氧，立即就医。
InhalationRemove from exposure and move to fresh air e oxygen if available.食入：引用两杯牛奶或水。
如果当事人仍然清晰可以采取催吐的方法，并且立即就医。
IngestionGive at least2glasses of milk or water.Induce vomiting unless patient is unconscious.Call a physician.燃点：不适用Flash Point:N/A.自燃温度：不适用Auto-Ignition Temperature:N/A.灭火介质：大量水(降温)，二氧化碳Extinguishing Media:Water,CO2.特殊灭火程序：自给式呼吸器Special Fire-Fighting Procedures:Self-contained breathing apparatus.异常火灾或爆炸：当电芯暴露于过热的环境中时，安全阀可能会打开。
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
材料安全数据表（上）
在所有情况下，都要立刻就医 .
接触眼睛: 用大量清水清洗至少15 分钟( 打开眼睛).
接触皮肤: 脱下被污染的衣物并用大量清水及肥皂清洗感染处至少15 分钟。
不要搽药膏
吞食: 用水冲淡它并立刻就医 .
确保感染者没有使用催吐剂
确保粘液没有阻隔呼吸道
不要给无意识的人吃其他东西
吸入: 到空气清新的地方并使污染区通风 .
如果必要的话，输氧或进行人工呼吸
5 –防止燃烧的办法
燃烧或冒烟危险：
除LFP 类电池外，LCP 、LMP 电池若被不当使用的情况下或受环境影响，在150 ℃的情况下会泄燃电解物质。
在火烧中可能会形成氟化氢(HF) 与磷氧化物，电解液中的LiPF 6 与水发生的化学反应
灭火媒介:用水喷淋或将冒烟的或起火燃烧的电池浸泡在水中。
可使用的:………… D 型灭火器, Co2, 干燥化学物或泡沫灭火器
特殊危险:由于外部影响或不当使用导致的电池过热，电解液泄漏，或电池破裂可能会导致泄漏电池内部接触眼睛:电池内部的电解液对眼睛会产生刺激。
接触皮肤:电池内部的电解液可能会导致皮肤感染。
吞食:吞食电解液可能会导致喉咙或呼吸道感染。
吸入:电池泄漏或破裂时，其内部成分可能会导致呼吸道粘液，隔膜或水肿。
特殊保护工具:使用呼吸设备来避免吸入刺激性气体。
穿防护衣或用其他装置来避免身体接触到电解液。
电池内部成分只有在滥用的情况下才有可能被泄漏。
浸泡在水中或用大量的水冲洗，放置在合适的容器中 ( 如果必要的话在其经过冷却之后 ) ，根据当地规定处理。
7 - 操作与贮藏
电池不可以被打开 , 损坏和烧弃，因为其可能会泄漏或毁坏并且将里面含有的化学成分释放到外界。
操作 :不要压挤，刺破及将电池 (+)(-) 电极用 可传导的材料连接（例如金属）。
不要直接加热或焊接。
不要扔进火中 . 不要随意连接不同型号和品牌的电池。
不要将新旧型号的电池 混用。
将电池放在不传导的容器中。
（例如塑料）
贮藏 :需贮存在凉爽通风的地方 ( 最好是低于 30 ℃ ) ，远离潮湿 ，热源，火源，食物及饮料。
电池放置需与墙壁保持适当距离。
温度高于 100 ℃ 可能会导致电池泄漏或破裂。
由于 短路可能会引起壳体破裂燃烧，泄漏与破损，所以应将电池保持在初始包装内直至使用，并且不要混杂。
其他 :依照厂商关于最大电流，工作温度范围的建议使用挤压或使电池变形可能会导致电池壳体破裂拆解，并且感染眼睛，皮肤与喉咙。
呼吸保护 :在正常情况下不需使用，在电池破损的情况下，可用面罩呼吸工具来保护。
手防护 :在正常情况下不需使用，如拿处理已泄漏的电池，可以带橡胶手套作为防护。
眼睛保护 :在正常情况下不需使用，如拿处理已泄漏的电池，可戴侧面有防护的安全护目镜或眼镜。
皮肤保护 :在正常情况下不需使用，如拿处理已泄漏的电池，可穿橡胶围裙以做防护。
9.1 外观 :( 物理形状与颜色如所提供的 ) 白色条纹状外壳 , 密封并且装有金属电极 / 连接器。
9.2 温度范围 :
9.3
特殊功率 :(Note: Wh = 额定电压 x 额定 Ah kg = 平均电池重量 ) 9.4 特殊缓冲功率 :600w-1200w/kg 根据电池型号而定 9.5 电阻 :如相关的 IEC 标准所规定 9.6 其他 : 避免的情况 :温度高于 80 ℃ 或烧弃 使变形，毁伤 , 挤压，刺破，分解，短路，持续暴露在潮湿的环境中
避开的材料 :N/A
危险分解物 :腐蚀性 / 刺激性的氟化氢 (HF) 会在 LiPF 6 与水的反应中产生。
易燃水汽，氟化氢 (HF) 与磷氧化物将会在火烧中产生。
11 - 有毒物信息
雷天锂离子充电电池不含有有毒物 12 - 生态环境信息
在正确使用至电池寿命终止时，可回收再造，雷天锂离子充电电池不会带来环境污染。
根据可适用的规则处理, 因国家而异 .
锂离子电池的电极必须保持绝缘并且最好在使用前用独立塑料包装袋包装。
13.1 焚烧:使用者不可焚烧电池，只能由权威的机构合理处理。
13.2 回收:交给权威的回收机构处理 .
14 - 运输信息
14.2 联合国: UN ° 3090
类别9 包装
空运ICAO 903 海运IMDG 903
14.2 国际惯例:
空运IATA 是
海运IMDG 是
陆地运输ADR ( 陆地运输) 是RID ( 铁路运输) 是
14.3 其他:
在美国: 联邦法律法规代码(49 CFR Ch. 1 §
173-185)
STSG/AC.10/1 Rev. 13 ” 由多方制定(IATA, IMO, ADR, US-DOT) 。
根据锂离子电池的重量，成分，设计，通过联合国“ 危险品运输- 测试标准手册- 第三次修改版本-2002- Ref. Ref. STSG/AC.10/11 Rev. 3 修订版1 << 锂电池>> ” 的安全测试的能力，锂离子电池与其电池组依照UN No 3090 第9 类之规定来判定其可或不可运输 .单体的锂电池与电池组若分别含有少于 1.5 克与8 克通过UN- 制定的安全测试的锂金属成分，则不在运输限制范围之内。
(1.0 Ah 额定容量= 0.3 克锂成分)
16 –其他/ 免责
此内容根据可靠依据编制，但是 . 对此内容的准确性，可靠性，完整性不做保证或担保,
此信息是针对此材料在此叙述之特定使用的，在其与其他材料混合使用或在其他过程中使用时并不有效。
在用户做特殊使用时他有责任考虑此信息的的合适性和完整性。