ZF齿轮箱手册(IRM350)
ZF行星减速机样本
HLP 68 as per ISO VG 68 HLP 46 as per ISO VG 46 HLP 32 as per ISO VG 32 最大允许120℃取决于应用，安装位置，润滑和冷却
5 000 h
对于V1和V3安装位置，循环油系统是必须的
(ca. kg)
30
62
70
110
325
130
400
900 1112 3 549 4 450 -
5 000 -
4.0 4 000
* * *
* -
3 500 -
* 4 000
* * *
* -
3 500 -
* **
* * *
水平 (B5) 垂直 (V1/V3)
1.0/1.4 1.5
2.8
循环润滑
--------------------------只有循环润滑 ------------------------
另外，四个同时啮合的行星斜齿 轮也保证了在高速运转时噪音较 低。
不固定的太阳轮平衡了同心度 ，改变了中心距离。所以行星齿 轮机构即使不用严格按照精密的 公差设计，也有较好的表现。
电机-齿轮箱通常利用齿轮箱壳 体上的安装底座来安装到机器上 。（只有2K120，2K250和 2K300）
另外每个齿轮箱用中心定位螺栓 来安装到法兰上。
-
4.00 560
1 600
*4.91 687
-
5.50 -
2 200
(rpm)
(mm/s) (rpm)
≠ 1 8 000 12) 10 000
2.0*)
6 300 8 000
2.0*) 6 000
(N)
(J in kgcm2) 输出 输入
齿轮箱说明书
齿轮箱使用说明书Edition：2012版本升级记录从Edtion：2011升级到Edtion：2012版本的主要内容：1.在6.4章节中增加了严禁对齿轮箱进行敲击装配的提醒；2.在8.2章节中增加了对风机传动链长时间锁死对齿轮箱会造成严重损害的重要提示；3.在9.1章节中进一步明确了电机泵的启动关闭控制流程，删去了单速电机泵的控制流程；4.在9.2章节中进一步明确了风扇的启动和关闭控制流程，删去了单速风扇或水冷的的控制流程；5.在10章中重新整合本章的内容，并增加了10.9级螺栓预紧力矩检查标准。
目录1 前言 (5)2 开箱 (6)3技术参数 (7)3.1 铭牌 (7)3.2 应用领域 (7)4 安全事项 (8)4.1正常使用 (8)4.2客户义务 (8)4.3环境保护 (9)4.4特殊危险 (10)5 运输和储藏 (11)5.1运输 (11)5.2 储藏 (12)6齿轮箱的安装 (14)6.1 拆箱 (14)6.2 排油、去除防腐剂 (14)6.3高速轴连轴器的安装 (14)6.4 加油 (16)6.5 连接电路 (16)6.6 机舱试车前的检查 (16)6.7 机舱试车 (17)6.8 齿轮箱随机舱的运输 (17)7齿轮箱拆卸 (18)7.1拆除高速轴连轴器 (18)7.2防腐防锈处理 (18)8启动与停机 (19)8.1启动 (19)8.2齿轮箱的停机 (20)9监控要求 (22)9.1 电机泵的控制 (23)9.2 风扇或水冷的控制 (24)9.3运行温度 (24)9.4 油位检查 (25)9.5 取油样 (26)9.6油压 (26)9.7 齿轮箱内部检查 (27)10维护和修复 (28)10.1中分面及齿圈螺栓的检查 (28)10.2必须维护的项目 (29)10.3齿轮箱常见故障 (30)11润滑系统 (32)11.1润滑油 (32)11.2 换油 (33)11.3更换滤芯 (33)11.4安装滤芯 (34)12 重要事项 (35)12.1 空气滤清器 (35)12.2 滤芯 (35)12.3 润滑油 (35)1 前言用户在安装使用前请详细阅读本说明书。
ZF齿轮箱手册(IRM350)
I R M350P L6.36.3 I R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R TS C A T A L O G U E I N D I C E P A G E I N D E X G R U P P O C A R C A S S A E C O P E R C H I A L B E R O I N G R E S S O C O N T R A L B E R O A L B E R O U S C I T A G R U P P O P O M P A D I S T R I B U T O R E K I T V A L V O L A T R O L L I N G G R U P P O S C A M B I A T O R E P T O G R U P P O P T O C O N F R I Z I O N E G R U P P O P R E S A D I R E T T A K I T A D A T T A T O R I + S E N S O R I T E M P ./P R E S S . K I T S R I C A M B I M A I N H O U S I N G -A S S E M B L Y I N P U T S H A F T C O U N T E R S H A F T O U T P U T S H A F T P U M P A S S E M B L Y C O N T R O L V A L V E T R O L L I N G V A L V E K I T E X C H A N G E R A S S Y P T O C L U T C H A B L E P T O A S S Y L I V E P T O A S S Y A D A P T O R S K I T + T E M P . A N D P R E S S . S E N S O R S S H A R E K I T S 41014182022242830363840C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O C A R C A S S A C O P E R C H I/M A I N H O U S I N G A S S E M B L YL I S TC o d i c e Pa r t n u mb e rQ u a n t i t àQ u a n t i t y D e s c r i z i o n e D e s c r i p t i o n 132152010011TU B O A S P I R A Z I O N E S U C T I O N T U B E 206360152895V I T E T E M 8x 16S C R E W T E M 8x 16306368040012G O L F A R E M 16E Y E M 16432153010191C A R T E R B A F F L E 506360152576V I T E T E M 8x 25S C R E W T E M 8x 256063030050450R O S E T T A E L A S T I C A E L A S T I C W A S H E R 706360151421V I T E T E M 5x 10S C R E W T E M 5x 10806303020101R O S E T T A E L A S T I C A E L A S T I C W A S H E R 932153010021R O N D E L L A W A S H E R 1032153010011T A P P O D .18x 13P L U G D .18x 131106343495335A N E L L O D I T E N U T A O R O R I N G 1206363010434T A P P O 1/4 G A S P L U G 1/4 G A S 1332153010271T A P P O S P E C I A L E 3/8 G A S S P E C I A L P L U G 3/8 G A S 1432153010201D O C C I A S U A S S I S H O W E R P I P E 1506343042603A N E L L O D I T E N U T A O R O R I N G 1606313291351S P I N A P I N 1732152010021A S S I E M E T U B O P E R L I V E L L O O L I O O I L L E V E L T U B E 1806343061941A N E L L O D I T E N U T A O R O R I N G 1932152010031A S T A L I V E L L O O L I O C O M P L E T A O I L D I P S T I C K 2006326010071I N G R A S S A T O R E G R E A S E F I L L E R 2106363010199T A P P O 1/8 G A S P L U G 1/8 G A S 2232153010041T U B O C O L L E G A M E N T O C O N N E C T I N G P I P E 2332153010071T U B O C O L L E G A M E N T O C O N N E C T I N G P I P E 2406305312112A N E L L O S E E G E R S E E G E R R I N G 2532153010051S U P P O R T O P O M P A P U M P S U P P O R T 2606343065311A N E L L O D I T E N U T A O R O R I N G 2706343034541A N E L L O D I T E N U T A O R O R I N G 2832153010151C O P E R C H I O C H I U S U R A S E A L C O V E R 2906343042661A N E L L O D I T E N U T A O R O R I N G I R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U E G R U P P O C A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y C o d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.56.3 P o s .Z FT A B L EI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U EG R U P P OC A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y Co d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.6 L I S TP o s .Z F C o d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y D e s c r i z i o n e D e s c r i p t i o nI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U E G R U P P O C A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y 31063601522738VI T E T E M 10x 35S C R E W T E M 10x 353306343037702A N E L L O D I T E N U T A O R O R I N G 3432153010211C A R C A S S A A N T E R I O R E F R O N T H O U S I N G 3530823090141C O P E R C H I O C O V E R 3806343042362A N E L L O D I T E N U T A O R O R I N G 3906360104082V I T E T E M 10x 90S C R E W T E M 10x 904032153080111P I A S T R A D I S T R I B U Z I O N E O L I O D I S T R I B U T I O N O I L F L A N G E 4132153010371F L A N G I A P O R T A C U S C I N E T T I B E A R I N G S S U P P O R T 4206343011002A N E L L O D I T E N U T A R I N G 4306343036681A N E L L O D I T E N U T A O R O R I N G 4406360103057V I T E T E M 10x 40S C R E W T E M 10x 404532153010381S P E S S O R E 0,15S H I M 32153010391S P E S S O R E 0,20S H I M 32153010401S P E S S O R E 0,25S H I M 32153010411S P E S S O R E 0,30S H I M 32153010421S P E S S O R E 0,50S H I M 4706363050762T A P P O C M 22x 1,5P L U G C M 22x 1,54806348010742G U A R N I Z I O N E G A S K E T 4932153010311C A R C A S S A P O S T E R I O R E R E A R H O U S I N G 5006313155232S P I N A P I N 5106343096111A N E L L O D I T E N U T A R I N G 5232093010091T A R G H E T T A C O N T R O L L O O L I O O I L L E V E L P L A T E 5332153010461C O P E R C H I O I S P E Z I O N E C H E C K C O V E R 5406363050021/P L 1 3/P L 2T A P P O C M 30x 1,5P L U G C M 30x 1,5550634801098 1/P L 1 3/P L 2G U A R N I Z I O N E G A S K E T 5606360152704V I T E T E M 10x 16S C R E W T E M 10x 165732173010011T A R G H E T T A D A T I L A B E L 5806313110796R I V E T T O R I V E T 5932153010431T A R G H E T T A D I R E Z I O N A L E D I R E C T I O N A L P L A T E Co d i c e s o l oc a ta l o g o r i c a mb i / S p a r e p a r t sc a t a l o g u e o n l y c ode : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.76.3T A B L EI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U EG R U P P OC A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y Co d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.8 L I S TP o s .Z F C o d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y D e s c r i z i o n e D e s c r i p t i o nI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U E G R U P P O C A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y 62063030050314R O S E T T A E L A S T I C A E L A S T I C W A S H E R 6332153080011S T A F F A T E L E C O M A N D O C O N T R O L V A L V E B R A C K E T 6432153030042S P E S S O R E D .110x 128,4x 0,15S H I M 32153030052S P E S S O R E D .110x 128,4x 0,20S H I M 32153030062S P E S S O R E D .110x 128,4x 0,25S H I M 32153030072S P E S S O R E D .110x 128,4x 0,30S H I M 32153030082S P E S S O R E D .110x 128.4x 0,50S H I M 6506343041542A N E L L O D I T E N U T A O R O R I N G 6606360153882V I T E M 8x 12S C R E W M 8x 12Co d i c e s o l oc a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c ode : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.96.3T A B L EI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U EA LB E R OI N G R E S S O / I N P U T S H A F T C o d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.10 L I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E AL B E R O I N G R E S S O / I N P U T S H A F T 132153020061AL B E R O E N T R A T A IN P U T S H A F T 232153020311C A M P A N A F R I Z I O N E D R U M C L U T C H 1 + 232152020051A S S I E M E A L B E R O + C A M P A N A D R U M A N D S H A F T A S S Y 306343037101AN E L L O D I T E N U T A O R OR I N G 406343036681A N E L L O D I T E N U T A O R O R I N G 532153020022DI S C O F R I Z I O N E C L U T C H D I S K 632133020249D I S C O F R I Z I O N E S I N U S S I N U S C L U T C H D I S K 732153020038DI S C O F R I Z I O N E CL U T C H D I S K 806354702061RU L L I N I RO L L E R 906305131051A N E L L O S E E G E R S E E G E R R I N G 1032133020251A N E L L O A R R E S T O D I S C H I F R I Z I O N E C L U T C H D I S K R E T A I N I N G R I N G 1132153024022DI S T A N Z I A L E D .58x 63x 26,2SP A C E R D .58x 63x 26,21206353002002GA B B I A R U L L I N I RO L L E R C A G E 1332153024032RA L L A T H R U S T W A S H E R 1406353020162G AB B I A A S S I E M E R U L L I N I R O L L E RC A G E A S S Y 1532153020231RA L L A T H R U S T W A S H E R 1606353740111C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E RB E A R I N G 1732153030031BU S S O L A BU S I N G 1806305312741A N E L L O S E E G E R S E E G E R R I N G 1906344025382SE G M E N T O S T E E L R I N G 2032153020261G R A N O S P E C I A L E M 10x 10S P E C I A L P L U G M 10x 102106316101211GR A N O M 10x 10PL U G M 10x 102232133020211S P I N A P E R P I S T O N E P I S T O N P I N 2332153020011P I S T O N E P E R F R I Z I O N E C L U T C H P I S T O N 2432153020051M O L L A P E R P I S T O N E F R I Z I O N E C L U T C H P I S T O N S P R I N G 2532153020341AN E L L O A R R E S T O M O L L A S P R I N G R E T A I N I N G R I N G 2606305055291AN E L L O E L A S T I C O EL A S T I C R I N G 2706352901141RA L L A WA S H E R 2806305040033A N E L L O S E E G E R S E E G E R R I N G6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LA LB E R O I N G R E S S O/I N P U T S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E AL B E R O I N G R E S S O / I N P U T S H A F T 2932153020183VI T E S P E C I A L E M 12SP E C I A L S C R E W M 123006353720091C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 3132153020391I N G R A N A G G I O Z = 40 R = 1.025PI N I O N Z = 40 R = 1.0253232153020401I N G R A N A G G I O Z = 35 R = 1.286P I N I O N Z = 35 R = 1.2863332153020411I N G R A N A G G I O Z = 31 R = 1.581P I N I O N Z = 31 R = 1.5813432153020381I N G R A N A G G I O Z = 26 R = 2.077P I N I O N Z = 26 R = 2.0773532152020321I N G R A N A G G I O Z = 22 R = 2.636P I N I O N Z = 22 R = 2.6363632152020311I N G R A N A G G I O Z = 22 R = 2.864P I N I O N Z = 22 R = 2.8646.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LC O N T R A L B E R O/C O U N T E R S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E CO N T R A L B E R O / C O U N T E R S H A F T 132153030011CO N T R A L B E R O CO U N T E R S H A F T 232153030101C A M P A N A F R I Z I O N E C L U T C H D R U M 1 + 232152030021A S S I E M E A L B E R O + C A M P A N A D R U M A N D S H A F T A S S Y 306343037101AN E L L O D I T E N U T A O R OR I N G 406343036681A N E L L O D I T E N U T A O R O R I N G 532153020022DI S C O F R I Z I O N E C L U T C H D I S K 632133020249D I S C O F R I Z I O N E S I N U S S I N U S C L U T C H D I S K 732153020038DI S C O F R I Z I O N E CL U T C H D I S K 806354702061RU L L I N I RO L L E R S 906305131051A N E L L O S E E G E R S E E G E R R I N G 1032133020251A N E L L O A R R E S T O D I S C H I F R I Z I O N E C L U T C H D I S K R E T A I N I N G S P R I N G 1132153024022DI S T A N Z I A L E D .58x 63x 26,2SP A C E R D .58x 63x 26,21206353002002GA B B I A R U L L I N I RO L L E R C A G E 1332153024032RA L L A T H R U S T W A S H E R 1406353020162G AB B I A A S S I E M E R U L L I N I R O L L E RC A G E A S S Y 1532153020231RA L L A T H R U S T W A S H E R 1606353740111C U S C I N E T T I R U L L I C O N I C I T A P E R E D R O L L E RB E A R I N G 1732153030031BU S S O L A BU S I N G 1806305312741A N E L L O S E E G E R S E E G E R R I N G 1906344025382SE G M E N T O S T E E L R I N G 2032153020261G R A N O S P E C I A L E M 10x 10S P E C I A L P L U G M 10x 102106316101211GR A N O M 10x 10PL U G M 10x 102232133020211S P I N A P E R P I S T O N E P I S T O N P I N 2332153020011P I S T O N E P E R F R I Z I O N E C L U T C H P I S T O N 2432153020051M O L L A P E R P I S T O N E F R I Z I O N E C L U T C H P I S T O N S P R I N G 2532153020341AN E L L O A R R E S T O M O L L A S P R I N G R E T A I N I N G R I N G 2606305055291AN E L L O E L A S T I C O EL A S T I C R I N G 2706352901141RA L L A WA S H E R 2806305040033A N E L L O S E E G E R S E E G E R R I N G6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LC O N T R A L B E R O/C O U N T E R S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E CO N T R A L B E R O / C O U N T E R S H A F T 2932153020183VI T E S P E C I A L E M 12SP E C I A L S C R E W M 123006353740111C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 3132153020391I N G R A N A G G I O Z = 40 R = 1.025PI N I O N Z = 40 R = 1.0253232153020401I N G R A N A G G I O Z = 35 R = 1.286P I N I O N Z = 35 R = 1.2863332153020411I N G R A N A G G I O Z = 31 R = 1.581P I N I O N Z = 31 R = 1.5813432153020381I N G R A N A G G I O Z = 26 R = 2.077P I N I O N Z = 26 R = 2.0773532152020321I N G R A N A G G I O Z = 22 R = 2.636P I N I O N Z = 22 R = 2.6363632152020311I N G R A N A G G I O Z = 22 R = 2.864P I N I O N Z = 22 R = 2.8646.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LA LB E R O U SC I T A/O U T P U T S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E AL B E R O U S C I T A / O U T P U T S H A F T 132153040431AL B E R O U S C I T A OU T P U T S H A F T 206353750301C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 306353760331C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 432153040081FL A N G I A U S C I T A OU T P U T F L A N G E 532153040441D I S C O A R R E S T O F L A N G I A U S C I T A O U T P U T F L A N G E R E T A I N R I N G 632153040451PI A S T R I N A D I S I C U R E Z Z A SA F E T Y P L A T E 706360200653VI T E M 20x 1,5x 60S C R E W M 20x 1,5x 60832153040101I N G R A N A G G I O Z = 41 R = 1.025P I N I O N Z = 41 R = 1.025932153040201I N G R A N A G G I O Z = 45 R = 1.286P I N I O N Z = 45 R = 1.2861032153040121I N G R A N A G G I O Z = 49 R = 1.581P I N I O N Z = 49 R = 1.5811132153040111I N G R A N A G G I O Z = 54 R = 2.077P I N I O N Z = 54 R = 2.0771232153040141I N G R A N A G G I O Z = 58 R = 2.636P I N I O N Z = 58 R = 2.6361332153040131I N G R A N A G G I O Z = 63 R = 2.864P I N I O N Z = 63 R = 2.8648 + 132152040061A S S I E M E A L B E R O + I N G R A N A G G I O Z = 41S H A F T A N D G E A R Z = 41 A S S Y 9 + 132153040471A S S I E M E A L B E R O + I N G R A N A G G I O Z = 45S H A F T A N D G E A R Z = 45 A S S Y 10 + 132153040481A S S I E M E A L B E R O + I N G R A N A G G I O Z = 49S H A F T A N D G E A R Z = 49 A S S Y 11 + 132153040491A S S I E M E A L B E R O + I N G R A N A G G I O Z = 54S H A F T A N D G E A R Z = 54 A S S Y 12 + 132153040501A S S I E M E A L B E R O + I N G R A N A G G I O Z = 58S H A F T A N D G E A R Z = 58 A S S Y 13 + 132153040511A S S I E M E A L B E R O + I N G R A N A G G I O Z = 63S H A F T A N D G E A R Z = 63 A S S Y6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O P O M P A/P U M P A S S E M B L YL I S T6.3 Po s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U EGR U P P O P O M P A / P U M P A S S E M B L Y 132151060011PO M P A PU M P 232153060071G U A R N I Z I O N E G A S K E T 332153060081G I U N T O T R A S C I N A M E N T O P O M P A P U M P D R I V E R C O U P L I N G 432153060061CO R P O P O M P A PU M P H O U S I N G 506363010131T A P P O M 24x 1,5P L U G M 24x 1,5606359009732BO C C O L A BU S H I N G 732133060111P E R N O PI N 832133060121L I N G U E T T A K E Y 932133060181R O T O R E R O T O R 1006343042291O R D I T E N U T A O -R I N G 1132153060051C O P E R C H I O C O V E R 1206303005046R O S E T T A E L A S T I C A E L A S T I C W A S H E R 1306360105406VI T E T E M 10x 90S C R E W T E M 10x 901406363010061T A P P O M 18x 1,5PL U G M 18x 1,51506363010192T A P P O 1/8 G A S P L U G 1/8 G A S 1632153060101FI L T R O SC R E E N 1732133060061G U A R N I Z I O N E G A S K E T 1832133060051PE R N O PI N 1906303005032R O S E T T A E L A S T I C A E L A S T I C W A S H E R 2006360105402VI T E T E M 8x 75S C R E W T E M 8x 75C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LD I S T R I B U T O R E/C O N T R O L V A L V EL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o n 132153080441CO R P O D I S T R I B U T O R E O L I O OI LD I S T R I B U T O R H O U S I N G 232153080571MO L L A SP R I N G 306354600371S F E R A R B B A L L 432153080571M O L L A S P R I N G 532152080041P I S T O N E P I S T O N 840053060271S P E S S O R E D .10,1x 16x 1,0S H I M D .10,1x 16x 1,0840053060321S P E S S O R E D .10,1x 16x0,50S H I M D .10,1x 16x 0,50840053060331S P E S S O R E D .10,1x 16x 0,40S H I M D .10,1x 16x 0,40840053060341S P E S S O R E D .10,1x 16x 0,30S H I M D .10,1x 16x 0,30840053060351S P E S S O R E D .10,1x 16x 0,20S H I M D .10,1x 16x 0,20932153080541MO L L A SP R I N G 1032093080172G U A R N I Z I O N E G A S K E T 1106360152105V I T E T E M 6x 30S C R E W T E M 6x 301206303005025R O S E T T A E L A S T I C A E L A S T I C W A S H E R 13 32151990511K I T C O P E R C H I O P E R D I S T R I B U T O R E C O N T R O L V A L V E C O V E R 1406305131501AN E L L O S E E G E R SE E G E R R I N G 1532153080591V A L V O L A P E R D I S T R I B U T O R E VA L V E 1606352900262RA L L A T H R U S T W A S H E R 1706353020511G AB B I A A S S I E M E R U L L I N I R O L L E RC A G E A S S Y 1832153080341P E R N O P E RD I S T R I B U T O RE C O N T R O L V A L V E P I N 1906313290691SP I N A PI N 2032153080171L E V A L E V E R 2106305321391A N E L L O S I C U R E Z Z A S N A P R I N G 2206343039551A N E L L O D I T E N U T A O R O -R I N G 2332153080631TA P P O P L U G 2406348010741A N E L L O D I T E N U T A O R O -R I N G 2532153080621MO L L A S P R I N G 2632153080611V A L V O L I N A D I R E G O L A Z I O N E 270636302039TA P P O 1/8"G A S PL U G 1/8"G A S IR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E DI S T R I B U T O R E / C O N T R O L V A L V E 6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LD I S T R I B U T O R E/C O N T R O L V A L V EL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o n 2806348011521AN E L L O D I T E N U T A O R O-R I N G2932013080011MO L L A S P R I N G 3006354600361S F E R A R B B A L L 3132093080071N I P P L O M 20X 1,5N I P P L E M 20X 1,53232133080191FI L T R O SC R E E N 3306363010195T A P P O 1/8"G A S P L U G 1/8"G A S 3406313291352SP I N A PI N 3506360101722V I T E T E M 10x55S C R E W T E M 10x 553606303005045R O S E T T A E L A S T I C A E L A S T I C W A S H E R 3706360101793VI T E T E M 10x 70S C R E W T E M 10x 703832153080601P I A S T R A G R A D U A L E 4006363020211TA P P O M 18x 1,5P L U G M 18x 1,54106348010571A N E L L O D I T E N U T A O R O-R I N G 4432093080373S P E S S O R E D .17,2x 23,8x 0,50S H I M D .17,2x 23,8x 0,504432093080381S P E S S O R E D .17,2x 23,8x 0,15S H I M D .17,2x 23,8x 0,154432093080391S P E S S O R E D .17,2x 23,8x 0,25S H I M D .17,2x 23,8x 0,254432093080402S P E S S O R E D .17,2x 23,8x 1,00S H I M D .17,2x 23,8x 1,004432093080411S P E S S O R E D .17,2x 23,8x 0,10S H I M D .17,2x 23,8x 0,104532153080651GU A R N I Z I O N E GA S K E T 4632151080041D I S T R IB U T O R E O L I OC O M P L E T O O I LD I S T R I B U T O R A S SE M B L Y IR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E DI S T R I B U T O R E / C O N T R O L V A L V E 6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LK I T V A L V O L A T R O L L I N G/T R O L L I N G V A L V E K I TL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o n 16361015841VI T E T C E I M 6x 50SC R E W M 6x 50206361017312V I T E T C E I M 6x 25S C R E W M 6x 25306361018592V I T E T C E I M 6x 60S C R E W M 6x 60432093080172G U A R N I Z I O N E GA S K E T 532153080551C O P E R C H I O C O V E R 632093080321MO L L A S P R I N G 706354600361S F E R A R B B A L L 80631611011G R A N O M 6x 8P L U G M 6x 8932153080581CAM M ACA M 1006313290441S P I N A P I N 1132153080401P E R N O P I N 1206343495331A N E L L O D I T E N U T A O -R I N G 1306370110341D A D O A U T OB L OC C A N T E S E L F -L O C K I N G N U T 1432153080071LE V A LE V E R 1540053060271S P E S S O R E D .10,1x 16x 1,0S H I M D .10,1x 16x 1,01540053060321S P E S S O R E D .10,1x 16x 0,50S H I M D .10,1x 16x 0,501540053060331S P E S S O R E D .10,1x 16x 0,40S H I M D .10,1x 16x 0,401540053060341S P E S S O R E D .10,1x 16x 0,30S H I M D .10,1x 16x 0,301540053060351S P E S S O R E D .10,1x 16x 0,20S H I M D .10,1x 16x 0,201632093080371S P E S S O R E D .17,2x 23,8x 0,50S H I M D .17,2x 23,8x 0,501632093080381S P E S S O R E D .17,2x 23,8x 0,15S H I M D .17,2x 23,8x 0,151632093080391S P E S S O R E D .17,2x 23,8x 0,25S H I M D .17,2x 23,8x 0,251706590645041MI C R O I N T E R R U T T O R E M I C R O S W I T C H E R 1806343038121A N E L L O D I T E N U T A O-R I N G 1932153080081SU P P O R T O S U P P O R T 2032153080641F I L T R O V E R S I O N E T R O L L I N G V A L V E T R O L L I N G V A L V E S C R E E N 2132133080121N I P P L O V E R S I O N E T R O L L I N G V A L V E T R O L L I N G V A L V E N I P P L E IR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E KI T V A L V O L A T R O L L I N G / T R O L L I N G V A L V E K I T 6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O S C A M B I A T O R E/E X C H A N G E R A S S YL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E GR U P P O S C A M B I A T O R E / E X C H A N G E R A S S Y6.3 132153070401TU B O O L I O D A S C A M B I A T O R E A I N V E R T I T O R E OI L T U B E F R O M C O O L E R T O G E A R B O X 206378700202NI P P L O NI P P L E 306348012283G U A R N I Z I O N E S E A L 406378702041GO M I T O E L B O W 506348012423G U A R N I Z I O N E S E A L W A S H E R 606378702013NI P P L O NI P P L E 732153070411T U B O O L I O D I S T R I B U T O R E /S C A M B I A T O R E C O N T R O L V A L V E O I L T U B E T O C O O L E R 806370110342DA D O A U T OB L OC C A N T E M 10SE LF -L O C K I NG N U T 906360152262VI T E T E M 10x 25S C R E W T E M 10x 251032153070316I N S E R T O E L A S T I C O E L A S T I C I N S E R T 1132153070312MO R S E T T O TE R M I N A L 1206360161782V I T E T E M 12x 25S C R E W T E M 12x 251306303020422R O S E T T A E L A S T I C A E L A S T I C W A S H E R 1432153070461S U P P O R T O S C A M B I A T O R E E X C H A N G E R S U P P O R T 1532133070062S C A M B I A T O R E D I C A L O R E HE A T E X C H A N G E R 1606360105682VI T E M 10x 100S C R E W M 10x 1001706348012912G U A R N I Z I O N E S E A L W A S H E R 1832093070252P O R T A G O M M A C O N N E C T O R 1932153070061T U B O P O M P A /D I S T R I B U T O R E O I L T U B E P U M P -D I S T R I B U T O RC A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O P T O C O N F R I Z I O N E/C L U T C H A B L E P T O A S S YL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E6.3 GR U P P O P T O C O N F R I Z I O N E / C L U T C H A B L E P T O A S S Y 1635302051 1GA B B I A A S S .R U L L I N I TR U S T N E E D L E B E A R I N G 206352900262RA L L A A S TR U S T W A S H E R 332153150051P E R N O D I S T R I B .P T O P T O D I S T R I B U T O R P I N 406313290691SP I N A EL A S T I C P I N 506305020151A N E L L O S I C U R E Z Z A S N A P R I N G 606354163301C U S C .R U L L I C I L .N J 208E C P -C 3B A L L S B E A R I N G 732153150111RA L L A T R U S T W A S H E R 8 0635302034 2G AB B I A A S S . R U L L I N I A X K 4060 T R U S T N E E D L E B E A R I N G 932153150091I N G R A N A G G I OC O N M O Z Z O GE A R 10 06352900352RA L L A A S 4060T R U S T W A S H E R 1106352900631R A L L A L S 4060T R U S T W A S H E R 1232153150071C A M P A N A F R I Z .P T O P T O C L U T C HB E L L 1306305020511AN E L L O S I C U R E Z Z A SN A P R I N G 1432093030131D I S C O C O N D O T T O P O S T .T O O T H E D R I N G 15 3210303015 3D I S C O F R I Z I O N E C L U T C H D I S K 16 3210303014 2D I S C O F R I Z I O N E C L U T C H D I S K 1732153150081P I S T O N E F R I Z .P T O PI S T O N 180634304233 1AN E L L O T E N U T A OR 19 0635460006 1SF E R A R B -B A L L 2032133020261G R A N O P L U G 2132153150101B U S S O L A D .45X 58X 78 B U SHI N G 22 0634402167 3SE G M E N T O S E G M E N T 23063630101911TA P P O PL U G 2406353580401C U S C .R A D .O R I E N T .R U L S W I N G I N G B A L L B E A R I N G 2506361011636VI T E SC R E W 26 0634319112 1A N E L L O T E N U T A S E A L R I N G 2732153150271B U S S O L AD .45X 65X 21 B U S H I N G 2806343063001AN E L L O T E N U T A OR 2906361014753VI T E S C R E W。
夏米尔350基本操作
夏米尔350基本操作一、开关机开机步骤1）先开主电源开关2）再按绿色电源按纽机器自动自动启动后在出始画面点击s e r v i c e s（服务）后弹出c u r r e n t u t i l i z a t i o n l e v e l话框后再点击M a c h i n e s e t t e r（机床设臵）后输入密码“C T”后点击“V”关机步骤1）按红色电源按纽2）关掉主电源开关二、校正、分正1、表针探头是否松动；2．表针正常摆动是在正负0.2m m，是否回到原值位臵；3．正常表针探头在检测时，应与垂直面摆成15~30度左右；4．校基准边标准应控制在0.005m m内；5．平行面标准应控制在0.015m m内；6、确定工件中心，应采用四面分中法，其中心心标准应控制在0.005m m内；7．工件和图纸都定有起点标识方向；8．工件上机前，油石打磨工件六个面，清除工件上毛刺，保证工件光滑平整，后根据图纸尺寸检查工件的长、宽、高及加工需使用到的相关数据，以便操作时有印象数据参与及加工设臵数据参考；9．用1000#细油石抽样打磨工作磁台，用干净纱布擦干净后，以手擦拭感觉无毛刺后，将工件平推入工作台，并目测调整工件大致水平，移动X、Y轴检查工件工作行程；10．检查电极分中凸台四周平整无毛刺，关测量记录凸台长宽尺寸，以便有数据数据确认分中正确与否，电极装夹前确认机台E R O W A底座是否有吹干净，E R O W A夹具4个定位脚是否不吹干净，拉钉是否有适当锁紧，确认无误后辨认好电极装夹方向，电极装夹上机台R R O W A底座；11．校正工件时请先校正工作X、Y平面，并控制平面度允许允许误差在0.015m m(工件长200，宽150),紧接着校正工件基准边误差控制在0.015m m内，最后检查工件直角边直角度误差控制在0.015内，校正电极时应先校正电极基准边，再校正X、Y平面，若X、Y平面校正时有作调整时，必须再倒检查校正基准边，反复检查直到三个自由度误差全部控制在0.005m m内，若检查误差超差又无法调整时请反馈给领班裁决处理，误差较大时由领班退回C N C查证处理；12．在电极，工件定位误差都控制在要求内后方能开始执行分中取数操作。
ZF变速箱内部培训课件
与车辆控制系统的集 成
详细说明zf变速箱如何与车辆控 制系统配合实现换挡和其他操作 。
与排放系统的集成
阐述zf变速箱如何与排放系统协 调工作，确保车辆达到排放标准 。
THANKS
谢谢您的观看
04
zf变速箱维护保养
定期检查与保养
01
02
03
定期检查油位
油位过高或过低都可能影 响变速箱的正常工作，需 定期检查并调整油位。
定期更换润滑油
变速箱润滑油在使用过程 中会逐渐劣化，影响变速 箱的润滑效果，建议定期 更换。
检查密封件
密封件的老化和损坏可能 导致变速箱漏油，需定期 检查并及时更换。
常见故障判断与处理
zf变速箱基本结构
手动变速箱
手动变速箱主要由齿轮、轴、箱体、垫圈、密封圈等组成，通过手动换挡手柄实 现档位的变换。
自动变速箱
自动变速箱主要由变矩器、行星齿轮、液压控制系统等组成，通过电磁阀和液压 控制系统实现自动换挡。
02
zf变速箱工作原理
换挡原理
自动换挡
ZF变速箱具有自动换挡功能 ，通过电磁阀和液压控制系统
技术发展方向
多元化传动技术
随着新能源汽车的兴起，zf变速箱将 进一步发展多元化传动技术，包括机 械传动、电力传动、液压传动等，以 满足不同类型车辆和不同使用场景的 需求。
自动换挡技术
zf变速箱将继续研发自动换挡技术， 提高车辆的燃油经济性和动力性，同 时降低驾驶者的操作强度。
智能化控制技术
利用大数据、云计算、人工智能等前 沿技术，实现zf变速箱的智能化控制 ，提高车辆的驾驶性能和安全性。
行业应用发展趋势
ZF自动变速箱2代操作使用手册.
4.2变速箱油油量. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
3.9状态监控/警示信号灯. . . . . . . . . . . . . . . . . . . . . . . . . . 21
3.10 HST 46辅助控制单元. . . . . . . . . . . . 22
4.保养. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
产品设计发生变化,本说明书亦应调整
ZF版权所有
本操作说明书受版权保护。未经版权所有者正式批准,严禁以任何形式进
行复制和传播(也包括改编、意译或节选,特别是重印、照相制版印刷、电子翻印、转储于数据处理设备或数据网络上,一经查实必将追究其法律责任。
中文版印于中国2004-8 ZJL
版本: 06.99
装有EST 46 C / EST 47 C电子控制单元的HP 502 C, HP 592 C,
3.操纵. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . .13 3.1驾驶. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 3.1.1档位选择器. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 3.1.2启动发动机. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 3.1.3排档选择. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 3.1.4起步. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 3.2排档范围. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 3.3强制低档. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 3.4缓速器操作. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 3.5停车,泊车. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 3.6牵引启动. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 3.7拖曳. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 3.8油温监控. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
齿轮箱说明书
齿轮箱使用说明书Edition：2012版本升级记录从Edtion：2011升级到Edtion：2012版本的主要内容：1.在6.4章节中增加了严禁对齿轮箱进行敲击装配的提醒；2.在8.2章节中增加了对风机传动链长时间锁死对齿轮箱会造成严重损害的重要提示；3.在9.1章节中进一步明确了电机泵的启动关闭控制流程，删去了单速电机泵的控制流程；4.在9.2章节中进一步明确了风扇的启动和关闭控制流程，删去了单速风扇或水冷的的控制流程；5.在10章中重新整合本章的内容，并增加了10.9级螺栓预紧力矩检查标准。
目录1 前言 (5)2 开箱 (6)3技术参数 (7)3.1 铭牌 (7)3.2 应用领域 (7)4 安全事项 (8)4.1正常使用 (8)4.2客户义务 (8)4.3环境保护 (9)4.4特殊危险 (10)5 运输和储藏 (11)5.1运输 (11)5.2 储藏 (12)6齿轮箱的安装 (14)6.1 拆箱 (14)6.2 排油、去除防腐剂 (14)6.3高速轴连轴器的安装 (14)6.4 加油 (16)6.5 连接电路 (16)6.6 机舱试车前的检查 (16)6.7 机舱试车 (17)6.8 齿轮箱随机舱的运输 (17)7齿轮箱拆卸 (18)7.1拆除高速轴连轴器 (18)7.2防腐防锈处理 (18)8启动与停机 (19)8.1启动 (19)8.2齿轮箱的停机 (20)9监控要求 (22)9.1 电机泵的控制 (23)9.2 风扇或水冷的控制 (24)9.3运行温度 (24)9.4 油位检查 (25)9.5 取油样 (26)9.6油压 (26)9.7 齿轮箱内部检查 (27)10维护和修复 (28)10.1中分面及齿圈螺栓的检查 (28)10.2必须维护的项目 (29)10.3齿轮箱常见故障 (30)11润滑系统 (32)11.1润滑油 (32)11.2 换油 (33)11.3更换滤芯 (33)11.4安装滤芯 (34)12 重要事项 (35)12.1 空气滤清器 (35)12.2 滤芯 (35)12.3 润滑油 (35)1 前言用户在安装使用前请详细阅读本说明书。
采埃孚变速箱齿轮模数表
采埃孚变速箱齿轮模数表采埃孚变速箱齿轮模数表：深度解析1. 引言在汽车行业中，采埃孚（ZF）被视为变速器技术的领导者之一。
作为世界领先的传动系统和底盘技术供应商，ZF公司提供了广泛的变速器产品，其中齿轮模数表是其变速箱设计过程中不可或缺的一部分。
2. 什么是齿轮模数表？齿轮模数表是一种用于描述齿轮尺寸、齿数和模数之间关系的工具。
模数（Module）指的是每个齿轮上每毫米的齿数，它是用于计算齿轮尺寸的重要参数。
齿轮模数表则是一份由采埃孚公司根据其变速器设计经验编制的参考表，记录了各种不同模数下可用的齿数范围。
3. 齿轮模数表的作用齿轮模数表在变速器设计中具有重要的作用。
它为设计师提供了一种快速选择合适的模数和齿数的方法，以满足特定的变速器性能要求。
仅仅通过查看齿轮模数表，设计师就能够找到可行的齿轮组合，并获取初步的设计概念。
齿轮模数表还帮助设计师在设计过程中进行优化。
通过选择合适的模数和齿数，设计师可以在保证变速器性能的同时提高传动效率、降低噪音和振动。
齿轮模数表提供了一种参考，以确保设计的齿轮在尺寸完备和传动效率之间取得最佳平衡。
齿轮模数表还为不同变速器类型和应用场景提供了标准化的参考指南。
无论是手动变速器还是自动变速器，无论是乘用车还是商用车，采埃孚的齿轮模数表都为设计师提供了详细的建议和指导。
这使得不同变速器之间可以实现部分互换性，并促进了整个行业的发展和进步。
4. 我对齿轮模数表的个人观点和理解作为一名汽车工程师，我深知齿轮模数表在变速器设计过程中的重要性。
它为设计师提供了一个快速而可靠的参考，帮助我们在短时间内获得合理的齿轮组合方案。
我个人认为，齿轮模数表是变速器设计过程中的一项核心工具，其准确性和实用性都至关重要。
然而，齿轮模数表并非万能。
设计师在使用时也需要结合实际需求进行灵活应用。
不同的变速器应用有不同的特点和要求，因此在使用齿轮模数表时，设计师还需要结合经验和专业知识，进行必要的调整和优化。
齿轮箱操作控制说明书
INSTRUCTIONS FOR OPERATION, CONTROL,MAINTENANCE ANDMOUNTINGGEARBOX LUBRICATIONKTM 1600CONTENT0. INTRODUCTION 31. EQUIPMENT DESCRIPTION 3 1.1 Technical parameters 3 1.2 Packaging, transportation, conservation 3 1.3 Mounting 41.4 Documentation 42. DESCRIPTION OF FUNCTION 43. ELECTRIC CONTROL 4 3.1 Electric appliances 43.2 Interlocking, signaling, control 54. PUTTING INTO OPERATION 5 4.1 Oil filling of gearbox 5 4.2 Flushing and testing 5 4.3 Working pressure set up 6 4.4 Flow rate signaling 6 4.5 Pressure control 6 4.6 Oil filtration 6 4.7 Temperature control 64.8 Level control 65. EQUIPMENT OPERATION 66. EQUIPMENT MAINTENANCE 77. SPARE PARTS AND GASKETS 8 7.1 Instructions for spare parts and gaskets ordering 80. INTRODUCTIONWe provide you this accompanying documentation to supplied equipment. You will find technical parameters and instructions for correct putting the equipment into operation, for control and maintenance.1. EQUIPMENT DESCRIPTIONThe equipment consists of the following parts : - aggregate- pipe distributionLubrication aggregate is a source of lubrication oil. It consists of the frame on which lubrication unit is placed (pump and electric motor), filter, cooler, contact thermometer, safety valve and flow rate switch.Pipe distribution is made with the pipes connected with flat flanges and closing valves. Pipe distribution is connected to the gearbox with hoses or rubber compensators for vibration compensation. On the gearbox body there is a level gauge with level switch and ball valve for discharge.Lubrication function is shown on the functional diagram dr.no. 4-OCH-31 011.1.1 Technical parametersLubrication aggregate∙Tank capacity -∙Delivered quantity 43 dm3min-1∙Safety pressure 10 bar∙Max. input 1,5 kW∙Electric motor revolutions 1400 min-1∙Working liquid Mineral oil ISO VG 100 ( according to DIN 51 519 ) ∙Working temperature 20 - 55 °C.∙Filtration rate 25 μm∙Heating In gearbox – 2 x 750 W∙Cooling Water cooler, P CH=18 kWat ∆t=25°C∙Electric motors voltage ~400 V, 50 Hz∙Elements voltage 24 V DC1.2 Packaging, transportation, conservationAll the parts of lubrication system are conserved with the lubrication oil and the parts of pipe distribution and the outlets from the aggregate and separate elements are plugged for transportation. Lubrication aggregate is possible to replace only for the lower part of the frame.1.3 MountingEquipment mounting is performed by the specialists for lubrication equipment or by the staff properly trained. Mounting shall be done in accordance with attached technical documentation.All parts of the pipe distribution shall be properly cleaned prior to mounting.The lubrication aggregate is mounted to the machine prior to the assembly of pipe distribution and is fixed with anchor bolts to the footing. After proper cleaning of the inlets the lubric. aggregate is connected with the gearbox by means of pipe distribution. Connection spots are shown on the lubrication aggregate layout drawing dr.no. 3-OCH-31 128and piping distribution is connected according to the functional diagram dr.no. 4-OCH-31 011.Mounting shall be documented with the assembly book mentioning the firm that performed mounting.1.4 DocumentationThe lubrication aggregate is usually supplied with :∙The instructions for operation, control, maintenance and mounting∙functional diagram∙specification of elements∙layout drawing of lubrication aggregate∙motor list2. DESCRIPTION OF FUNCTIONLubrication liquid is sucked with gear hydrogenerator (pos. 103) from the gearbox housing. Liquid flows further under pressure about 1÷3 bar through double filter (pos. 107) and the cooler (pos. 119) back to the gearbox housing on three lubricated spots. Filter clogging signal is electric.Pressure part of lubrication circuit is secured with pressure about 10 bar by means of pressure valve mounted on gear hydrogenerator (pos. 103).Working pressure is possible to control visually by means of manometer (pos. 109).Flow rate of lubrication oil is controlled with flow rate switch (pos. 114).Liquid temperature in gearbox is remote controlled with temperature sensor (pos. 117).Minimal oil level in the gearbox is signaled with level switch (pos. 122) mounted on gearbox.Remote control of pickup values is terminated on control panel.3. ELECTRIC CONTROL3.1 Electric appliancesPos. 102 - electric motor FCPA 90 L-4, 1,5 kW, 1400 min-1, 400 VPos. 106 - terminal switch DIN EN 50 041 – A1 250 VPos. 107 - filter clogging indicator AE.70.P.-.B, 3 VA, 24 VPos. 114 - flow rate sensor SI5000, 0,4 A, 24 VPos. 117 - temperature sensor T1005, 4÷20 mA, 230 VPos. 119 - water valve AB 21-23 / G3/4-G24 Z4, 12W, 24 VDCPos. 122 - level switch SNK 176 V-C-O-12-R, 0,5A, 24 VPos. 124 - heating element type 14070, 750 W, 230 V3.2 Interlocking, signaling, control-oil level drop in the gearbox below MIN –level switch SL1=0(pos.122) –electric motor run interlock M1 (pos.102) – FAILURE-closed ball valve SQ1=0(pos.106) –electric motor run interlock M1(pos.102) –FAILURE-insufficient lubrication – flow rate switch SQ2=0(pos.114) for a period more than 2 min. – electric motor run interlock M1 (pos.102) – FAILURE-filter clogging SF1=1 (pos.107) – signaling-low oil temperature (<15︒C) – temperature sensor BT1 (pos.117) – electric motor run interlock M1 (pos.102) – FAILURE-high oil temperature (>55︒C) – temperature sensor BT1 (pos.117) – water valve Y1=1 switched (pos.119)-high oil temperature (=60︒C) –temperature sensor BT1(pos.117) - visualization - warning-very high oil temperature (>70︒C) –temperature sensor BT1(pos.117) - electric motor run interlock M1 (pos.102) – FAILURE-oil heating – is automatically on at electric motor start M1 (pos.102) in case that oil temperature in the gearbox BT1 < 25 °C. It is off at BT1 = 35 °C4. PUTTING INTO OPERATIONPutting into operation is performed at the customer after it is connected to the machine lubrication and electric circuit. After transportation it is necessary to check the assembly of the aggregate parts, especially seating of electric motors and pumps.Putting into operation shall be done only by the equipment fabricator or by the persons trained by the fabricator who will be approved by the fabricator in written.During putting into operation the whole course of putting into operation shall be documented in the book. Putting into operation shall be done in accordance with the following points:4.1 Oil filling of gearboxGearbox filling shall be done with filtration filling unit with possibility of filtration min. 25 μm. Prescribed liquid is mentioned in technical parameters p.1.1. Level shall be checked on the level indicator (pos. 122)4.2 Flushing and testingPrior to putting into operation it shall be checked, whether the direction of electric motor turning corresponds to the data on the pump plate, on right-handed pump the direction of turning is in clockwise direction, with a view from electric motor to the pump. Pressure valve is released. Having performed the check, start the pump and let it run without pressure. During commissioning check and refill working fluid.After flushing it is necessary to take off oil sample from the gearbox to estimate liquid purity. If oil meets purity class 9 according to NAS 1638, it is possible to start with the lubrication equipment testing.Flushing shall be done also after long shut-downs and bigger repairs that involve pipe distribution.4.3 Working pressure set upMax. working pressure in lubrication circuit shall be set up by means of safety valve to 10 bar. Pressure is adjusted with the screw turning ( supply – pressure raise).Maximal working pressure can be adjusted at closed closing valve (pos. 120) at the outlet from the lubrication aggregate.4.4 Flow rate signalingFlow rate switch (pos. 114) signals liquid flow rate at the outlet from the aggregate.4.5 Pressure controlPressure can be controlled by means of built-in pressure gauge (pos. 109).4.6 Oil filtrationOil filtration is assured with double outlet filter (pos. 117). Filter is equipped with electric sensor of clogging and by-pass valve in case of clogging. Filtration degree is mentioned in technical parameters.Filtration insert substitution shall be done in case of :- impurity indicator signal (for more than 2 minutes)- after the first 500 hours after putting equipment into operation or once a year (according to the laboratory oil analysis – performs specialized firm ) -oil substitution4.7 Temperature controlOil temperature is measured with temperature sensor (pos. 117). Oil temperature can be checked with thermometer (pos. 118) – only when the pump runs.4.8 Level controlOil level height is controlled with level switch (pos. 122) that sends electrical signal if oil level in the gearbox is minimal and interlocks the drive, when oil level drops below emergency level.5. EQUIPMENT OPERATIONThe equipment operators shall be familiar with:a) the work of lubrication circuit in accordance with the functional diagramb) have basic knowledge about maintenance of lubrication equipmentc) safety rules and principles of safe work during manipulation with mineral oilsd) the function of lubrication elements and the way of their controlThe operators duties are :-performance of preventive examinations of equipment-control of hydraulic elements at adjustment-determination of requirements for equipment maintenance-maintain the book documenting running of the lubrication equipment and performed repairs6. EQUIPMENT MAINTENANCEMaintenance is an important condition for operation of the lubrication equipment. Any interferences for the maintenance of equipment are performed when it is out of operation (without pressure) and by the workers specially assigned for this work who are responsible for this work and properly trained for this activity.A part of the equipment maintenance Is the implementation of so called inspection system, duly documented with the book and checked, in which the following data are especially mentioned :-examination of equipment, in particular connections of pipe distribution-record of finding the first drop or oil leakage and the way of removal-assignment of repair date and responsible worker-confirmation about performance of the repair and its control-parallel oil check performed by specialized firm at least once a month and oil refill, as requiredImplementation of the inspection system is a necessary presumption foreventual claim procedure.Prior to eventual repair all lubrication equipment shall be cleaned in order to prevent from dirty entry into oil during repair. All the repairs are performed when agreed with the equipment operators.Especially for the first 3 months after passing-over the equipment to the User it is necessary to follow-up leaks of the pipe distribution and the connections shall be regularly retightened.At each long equipment shut-down it is useful :-to check the level height, or refill oil (only assigned quality with auxiliary hydrogenerator through the filter 25 m)At each repeated start :-to check oil level-to check filter cloggingFurthermore, during operation it is necessary to follow-up :-operation oil temperature-equipment noise7. SPARE PARTS AND GASKETSFor the equipment it is possible to order from the firm OCHI –INŽENÝRING, s.r.o. any spare parts or gaskets in accordance with the specification of elements dr.no. 4-OCH-31 129.7.1 Instructions for spare parts and gaskets orderingWhen ordering the spare parts you must mention :-production number of aggregate and number of the order as per the plate-date of production-name and marking of the element or the gasket in accordance with the specification of elements-number of pieces。
ZF变速箱内部培训课件
可靠性
ZF变速箱经过严格的质量控制和耐 久性测试，具有较高的可靠性和稳 定性，能够保证长期的性能表现。
灵活性
ZF变速箱具有广泛的适配范围，可 适用于多种车型和发动机，同时提 供多种速比选择，满足不同行驶工 况的需求。
应用领域
商用车领域
农业机械领域
ZF变速箱在商用车领域应用广泛，适 用于货车、客车等各类车型，满足物 流运输、公共交通等需求。
常见故障及排除方法
变速箱油温过高
可能是由于散热器堵塞、油位过高或过低等原因引起。应 检查散热器、油位及密封件是否正常、齿轮磨损或润滑不良等原因引起。 应检查轴承、齿轮及润滑系统是否正常，如有需要应更换 相关部件。
变速箱漏油
可能是由于密封件老化或损坏、油位过高或螺丝松动等原 因引起。应检查密封件、油位及螺丝是否正常，如有需要 应更换相关部件或重新紧固螺丝。
保持清洁
定期清洗变速箱，清除油泥和 杂质，保持变速箱内部清洁。
安全须知
操作时应注意力集中
操作变速箱时，应保持注意力集中， 避免分散注意力导致误操作。
禁止无资质人员操作
非专业人员不得随意拆卸、修理或改 装变速箱；如需维修，应由专业人员 进行处理。
遵守安全操作规程
在操作过程中，应遵守安全操作规程 ，确保人员和设备安全。
3
全球化趋势
ZF变速箱将积极拓展海外市场，提升在全球市场 的竞争力。
竞争格局
市场竞争
ZF变速箱面临着来自国内外竞争对手的激烈竞争，需要不断提升 自身的技术水平和产品质量。
合作与并购
为了提升市场地位和竞争力，ZF变速箱将寻求与其他企业和研究机 构的合作与并购机会。
品牌建设
加强品牌建设和市场营销，提升ZF变速箱在全球市场的知名度和影 响力。
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
I R M350P L6.36.3 I R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R TS C A T A L O G U E I N D I C E P A G E I N D E X G R U P P O C A R C A S S A E C O P E R C H I A L B E R O I N G R E S S O C O N T R A L B E R O A L B E R O U S C I T A G R U P P O P O M P A D I S T R I B U T O R E K I T V A L V O L A T R O L L I N G G R U P P O S C A M B I A T O R E P T O G R U P P O P T O C O N F R I Z I O N E G R U P P O P R E S A D I R E T T A K I T A D A T T A T O R I + S E N S O R I T E M P ./P R E S S . K I T S R I C A M B I M A I N H O U S I N G -A S S E M B L Y I N P U T S H A F T C O U N T E R S H A F T O U T P U T S H A F T P U M P A S S E M B L Y C O N T R O L V A L V E T R O L L I N G V A L V E K I T E X C H A N G E R A S S Y P T O C L U T C H A B L E P T O A S S Y L I V E P T O A S S Y A D A P T O R S K I T + T E M P . A N D P R E S S . S E N S O R S S H A R E K I T S 41014182022242830363840C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O C A R C A S S A C O P E R C H I/M A I N H O U S I N G A S S E M B L YL I S TC o d i c e Pa r t n u mb e rQ u a n t i t àQ u a n t i t y D e s c r i z i o n e D e s c r i p t i o n 132152010011TU B O A S P I R A Z I O N E S U C T I O N T U B E 206360152895V I T E T E M 8x 16S C R E W T E M 8x 16306368040012G O L F A R E M 16E Y E M 16432153010191C A R T E R B A F F L E 506360152576V I T E T E M 8x 25S C R E W T E M 8x 256063030050450R O S E T T A E L A S T I C A E L A S T I C W A S H E R 706360151421V I T E T E M 5x 10S C R E W T E M 5x 10806303020101R O S E T T A E L A S T I C A E L A S T I C W A S H E R 932153010021R O N D E L L A W A S H E R 1032153010011T A P P O D .18x 13P L U G D .18x 131106343495335A N E L L O D I T E N U T A O R O R I N G 1206363010434T A P P O 1/4 G A S P L U G 1/4 G A S 1332153010271T A P P O S P E C I A L E 3/8 G A S S P E C I A L P L U G 3/8 G A S 1432153010201D O C C I A S U A S S I S H O W E R P I P E 1506343042603A N E L L O D I T E N U T A O R O R I N G 1606313291351S P I N A P I N 1732152010021A S S I E M E T U B O P E R L I V E L L O O L I O O I L L E V E L T U B E 1806343061941A N E L L O D I T E N U T A O R O R I N G 1932152010031A S T A L I V E L L O O L I O C O M P L E T A O I L D I P S T I C K 2006326010071I N G R A S S A T O R E G R E A S E F I L L E R 2106363010199T A P P O 1/8 G A S P L U G 1/8 G A S 2232153010041T U B O C O L L E G A M E N T O C O N N E C T I N G P I P E 2332153010071T U B O C O L L E G A M E N T O C O N N E C T I N G P I P E 2406305312112A N E L L O S E E G E R S E E G E R R I N G 2532153010051S U P P O R T O P O M P A P U M P S U P P O R T 2606343065311A N E L L O D I T E N U T A O R O R I N G 2706343034541A N E L L O D I T E N U T A O R O R I N G 2832153010151C O P E R C H I O C H I U S U R A S E A L C O V E R 2906343042661A N E L L O D I T E N U T A O R O R I N G I R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U E G R U P P O C A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y C o d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.56.3 P o s .Z FT A B L EI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U EG R U P P OC A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y Co d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.6 L I S TP o s .Z F C o d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y D e s c r i z i o n e D e s c r i p t i o nI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U E G R U P P O C A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y 31063601522738VI T E T E M 10x 35S C R E W T E M 10x 353306343037702A N E L L O D I T E N U T A O R O R I N G 3432153010211C A R C A S S A A N T E R I O R E F R O N T H O U S I N G 3530823090141C O P E R C H I O C O V E R 3806343042362A N E L L O D I T E N U T A O R O R I N G 3906360104082V I T E T E M 10x 90S C R E W T E M 10x 904032153080111P I A S T R A D I S T R I B U Z I O N E O L I O D I S T R I B U T I O N O I L F L A N G E 4132153010371F L A N G I A P O R T A C U S C I N E T T I B E A R I N G S S U P P O R T 4206343011002A N E L L O D I T E N U T A R I N G 4306343036681A N E L L O D I T E N U T A O R O R I N G 4406360103057V I T E T E M 10x 40S C R E W T E M 10x 404532153010381S P E S S O R E 0,15S H I M 32153010391S P E S S O R E 0,20S H I M 32153010401S P E S S O R E 0,25S H I M 32153010411S P E S S O R E 0,30S H I M 32153010421S P E S S O R E 0,50S H I M 4706363050762T A P P O C M 22x 1,5P L U G C M 22x 1,54806348010742G U A R N I Z I O N E G A S K E T 4932153010311C A R C A S S A P O S T E R I O R E R E A R H O U S I N G 5006313155232S P I N A P I N 5106343096111A N E L L O D I T E N U T A R I N G 5232093010091T A R G H E T T A C O N T R O L L O O L I O O I L L E V E L P L A T E 5332153010461C O P E R C H I O I S P E Z I O N E C H E C K C O V E R 5406363050021/P L 1 3/P L 2T A P P O C M 30x 1,5P L U G C M 30x 1,5550634801098 1/P L 1 3/P L 2G U A R N I Z I O N E G A S K E T 5606360152704V I T E T E M 10x 16S C R E W T E M 10x 165732173010011T A R G H E T T A D A T I L A B E L 5806313110796R I V E T T O R I V E T 5932153010431T A R G H E T T A D I R E Z I O N A L E D I R E C T I O N A L P L A T E Co d i c e s o l oc a ta l o g o r i c a mb i / S p a r e p a r t sc a t a l o g u e o n l y c ode : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.76.3T A B L EI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U EG R U P P OC A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y Co d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.8 L I S TP o s .Z F C o d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y D e s c r i z i o n e D e s c r i p t i o nI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U E G R U P P O C A R C A S S A C O P E R C H I / M A I N H O U S I N G A S S E M B L Y 62063030050314R O S E T T A E L A S T I C A E L A S T I C W A S H E R 6332153080011S T A F F A T E L E C O M A N D O C O N T R O L V A L V E B R A C K E T 6432153030042S P E S S O R E D .110x 128,4x 0,15S H I M 32153030052S P E S S O R E D .110x 128,4x 0,20S H I M 32153030062S P E S S O R E D .110x 128,4x 0,25S H I M 32153030072S P E S S O R E D .110x 128,4x 0,30S H I M 32153030082S P E S S O R E D .110x 128.4x 0,50S H I M 6506343041542A N E L L O D I T E N U T A O R O R I N G 6606360153882V I T E M 8x 12S C R E W M 8x 12Co d i c e s o l oc a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c ode : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.96.3T A B L EI R M 350 P L C A T A L O G O P A R T I D I R I C A M B I O / S P A R E P A R T S C A T A L O G U EA LB E R OI N G R E S S O / I N P U T S H A F T C o d i c e s o l o c a t a l o g o r i c a m b i / S p a r e p a r t s c a t a l o g u e o n l y c o d e : 32.70.350.2002C o d i c e /C o d e : 32.70.350.5261 - E d i z i o n e /E d i t i o n : 09/2000 - P a g i n a /P a g e 6.3.10 L I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E AL B E R O I N G R E S S O / I N P U T S H A F T 132153020061AL B E R O E N T R A T A IN P U T S H A F T 232153020311C A M P A N A F R I Z I O N E D R U M C L U T C H 1 + 232152020051A S S I E M E A L B E R O + C A M P A N A D R U M A N D S H A F T A S S Y 306343037101AN E L L O D I T E N U T A O R OR I N G 406343036681A N E L L O D I T E N U T A O R O R I N G 532153020022DI S C O F R I Z I O N E C L U T C H D I S K 632133020249D I S C O F R I Z I O N E S I N U S S I N U S C L U T C H D I S K 732153020038DI S C O F R I Z I O N E CL U T C H D I S K 806354702061RU L L I N I RO L L E R 906305131051A N E L L O S E E G E R S E E G E R R I N G 1032133020251A N E L L O A R R E S T O D I S C H I F R I Z I O N E C L U T C H D I S K R E T A I N I N G R I N G 1132153024022DI S T A N Z I A L E D .58x 63x 26,2SP A C E R D .58x 63x 26,21206353002002GA B B I A R U L L I N I RO L L E R C A G E 1332153024032RA L L A T H R U S T W A S H E R 1406353020162G AB B I A A S S I E M E R U L L I N I R O L L E RC A G E A S S Y 1532153020231RA L L A T H R U S T W A S H E R 1606353740111C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E RB E A R I N G 1732153030031BU S S O L A BU S I N G 1806305312741A N E L L O S E E G E R S E E G E R R I N G 1906344025382SE G M E N T O S T E E L R I N G 2032153020261G R A N O S P E C I A L E M 10x 10S P E C I A L P L U G M 10x 102106316101211GR A N O M 10x 10PL U G M 10x 102232133020211S P I N A P E R P I S T O N E P I S T O N P I N 2332153020011P I S T O N E P E R F R I Z I O N E C L U T C H P I S T O N 2432153020051M O L L A P E R P I S T O N E F R I Z I O N E C L U T C H P I S T O N S P R I N G 2532153020341AN E L L O A R R E S T O M O L L A S P R I N G R E T A I N I N G R I N G 2606305055291AN E L L O E L A S T I C O EL A S T I C R I N G 2706352901141RA L L A WA S H E R 2806305040033A N E L L O S E E G E R S E E G E R R I N G6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LA LB E R O I N G R E S S O/I N P U T S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E AL B E R O I N G R E S S O / I N P U T S H A F T 2932153020183VI T E S P E C I A L E M 12SP E C I A L S C R E W M 123006353720091C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 3132153020391I N G R A N A G G I O Z = 40 R = 1.025PI N I O N Z = 40 R = 1.0253232153020401I N G R A N A G G I O Z = 35 R = 1.286P I N I O N Z = 35 R = 1.2863332153020411I N G R A N A G G I O Z = 31 R = 1.581P I N I O N Z = 31 R = 1.5813432153020381I N G R A N A G G I O Z = 26 R = 2.077P I N I O N Z = 26 R = 2.0773532152020321I N G R A N A G G I O Z = 22 R = 2.636P I N I O N Z = 22 R = 2.6363632152020311I N G R A N A G G I O Z = 22 R = 2.864P I N I O N Z = 22 R = 2.8646.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LC O N T R A L B E R O/C O U N T E R S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E CO N T R A L B E R O / C O U N T E R S H A F T 132153030011CO N T R A L B E R O CO U N T E R S H A F T 232153030101C A M P A N A F R I Z I O N E C L U T C H D R U M 1 + 232152030021A S S I E M E A L B E R O + C A M P A N A D R U M A N D S H A F T A S S Y 306343037101AN E L L O D I T E N U T A O R OR I N G 406343036681A N E L L O D I T E N U T A O R O R I N G 532153020022DI S C O F R I Z I O N E C L U T C H D I S K 632133020249D I S C O F R I Z I O N E S I N U S S I N U S C L U T C H D I S K 732153020038DI S C O F R I Z I O N E CL U T C H D I S K 806354702061RU L L I N I RO L L E R S 906305131051A N E L L O S E E G E R S E E G E R R I N G 1032133020251A N E L L O A R R E S T O D I S C H I F R I Z I O N E C L U T C H D I S K R E T A I N I N G S P R I N G 1132153024022DI S T A N Z I A L E D .58x 63x 26,2SP A C E R D .58x 63x 26,21206353002002GA B B I A R U L L I N I RO L L E R C A G E 1332153024032RA L L A T H R U S T W A S H E R 1406353020162G AB B I A A S S I E M E R U L L I N I R O L L E RC A G E A S S Y 1532153020231RA L L A T H R U S T W A S H E R 1606353740111C U S C I N E T T I R U L L I C O N I C I T A P E R E D R O L L E RB E A R I N G 1732153030031BU S S O L A BU S I N G 1806305312741A N E L L O S E E G E R S E E G E R R I N G 1906344025382SE G M E N T O S T E E L R I N G 2032153020261G R A N O S P E C I A L E M 10x 10S P E C I A L P L U G M 10x 102106316101211GR A N O M 10x 10PL U G M 10x 102232133020211S P I N A P E R P I S T O N E P I S T O N P I N 2332153020011P I S T O N E P E R F R I Z I O N E C L U T C H P I S T O N 2432153020051M O L L A P E R P I S T O N E F R I Z I O N E C L U T C H P I S T O N S P R I N G 2532153020341AN E L L O A R R E S T O M O L L A S P R I N G R E T A I N I N G R I N G 2606305055291AN E L L O E L A S T I C O EL A S T I C R I N G 2706352901141RA L L A WA S H E R 2806305040033A N E L L O S E E G E R S E E G E R R I N G6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LC O N T R A L B E R O/C O U N T E R S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E CO N T R A L B E R O / C O U N T E R S H A F T 2932153020183VI T E S P E C I A L E M 12SP E C I A L S C R E W M 123006353740111C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 3132153020391I N G R A N A G G I O Z = 40 R = 1.025PI N I O N Z = 40 R = 1.0253232153020401I N G R A N A G G I O Z = 35 R = 1.286P I N I O N Z = 35 R = 1.2863332153020411I N G R A N A G G I O Z = 31 R = 1.581P I N I O N Z = 31 R = 1.5813432153020381I N G R A N A G G I O Z = 26 R = 2.077P I N I O N Z = 26 R = 2.0773532152020321I N G R A N A G G I O Z = 22 R = 2.636P I N I O N Z = 22 R = 2.6363632152020311I N G R A N A G G I O Z = 22 R = 2.864P I N I O N Z = 22 R = 2.8646.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LA LB E R O U SC I T A/O U T P U T S H A F TL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E AL B E R O U S C I T A / O U T P U T S H A F T 132153040431AL B E R O U S C I T A OU T P U T S H A F T 206353750301C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 306353760331C U S C I N E T T O R U L L I C O N I C I T A P E R E D R O L L E R B E A R I N G 432153040081FL A N G I A U S C I T A OU T P U T F L A N G E 532153040441D I S C O A R R E S T O F L A N G I A U S C I T A O U T P U T F L A N G E R E T A I N R I N G 632153040451PI A S T R I N A D I S I C U R E Z Z A SA F E T Y P L A T E 706360200653VI T E M 20x 1,5x 60S C R E W M 20x 1,5x 60832153040101I N G R A N A G G I O Z = 41 R = 1.025P I N I O N Z = 41 R = 1.025932153040201I N G R A N A G G I O Z = 45 R = 1.286P I N I O N Z = 45 R = 1.2861032153040121I N G R A N A G G I O Z = 49 R = 1.581P I N I O N Z = 49 R = 1.5811132153040111I N G R A N A G G I O Z = 54 R = 2.077P I N I O N Z = 54 R = 2.0771232153040141I N G R A N A G G I O Z = 58 R = 2.636P I N I O N Z = 58 R = 2.6361332153040131I N G R A N A G G I O Z = 63 R = 2.864P I N I O N Z = 63 R = 2.8648 + 132152040061A S S I E M E A L B E R O + I N G R A N A G G I O Z = 41S H A F T A N D G E A R Z = 41 A S S Y 9 + 132153040471A S S I E M E A L B E R O + I N G R A N A G G I O Z = 45S H A F T A N D G E A R Z = 45 A S S Y 10 + 132153040481A S S I E M E A L B E R O + I N G R A N A G G I O Z = 49S H A F T A N D G E A R Z = 49 A S S Y 11 + 132153040491A S S I E M E A L B E R O + I N G R A N A G G I O Z = 54S H A F T A N D G E A R Z = 54 A S S Y 12 + 132153040501A S S I E M E A L B E R O + I N G R A N A G G I O Z = 58S H A F T A N D G E A R Z = 58 A S S Y 13 + 132153040511A S S I E M E A L B E R O + I N G R A N A G G I O Z = 63S H A F T A N D G E A R Z = 63 A S S Y6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O P O M P A/P U M P A S S E M B L YL I S T6.3 Po s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U EGR U P P O P O M P A / P U M P A S S E M B L Y 132151060011PO M P A PU M P 232153060071G U A R N I Z I O N E G A S K E T 332153060081G I U N T O T R A S C I N A M E N T O P O M P A P U M P D R I V E R C O U P L I N G 432153060061CO R P O P O M P A PU M P H O U S I N G 506363010131T A P P O M 24x 1,5P L U G M 24x 1,5606359009732BO C C O L A BU S H I N G 732133060111P E R N O PI N 832133060121L I N G U E T T A K E Y 932133060181R O T O R E R O T O R 1006343042291O R D I T E N U T A O -R I N G 1132153060051C O P E R C H I O C O V E R 1206303005046R O S E T T A E L A S T I C A E L A S T I C W A S H E R 1306360105406VI T E T E M 10x 90S C R E W T E M 10x 901406363010061T A P P O M 18x 1,5PL U G M 18x 1,51506363010192T A P P O 1/8 G A S P L U G 1/8 G A S 1632153060101FI L T R O SC R E E N 1732133060061G U A R N I Z I O N E G A S K E T 1832133060051PE R N O PI N 1906303005032R O S E T T A E L A S T I C A E L A S T I C W A S H E R 2006360105402VI T E T E M 8x 75S C R E W T E M 8x 75C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LD I S T R I B U T O R E/C O N T R O L V A L V EL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o n 132153080441CO R P O D I S T R I B U T O R E O L I O OI LD I S T R I B U T O R H O U S I N G 232153080571MO L L A SP R I N G 306354600371S F E R A R B B A L L 432153080571M O L L A S P R I N G 532152080041P I S T O N E P I S T O N 840053060271S P E S S O R E D .10,1x 16x 1,0S H I M D .10,1x 16x 1,0840053060321S P E S S O R E D .10,1x 16x0,50S H I M D .10,1x 16x 0,50840053060331S P E S S O R E D .10,1x 16x 0,40S H I M D .10,1x 16x 0,40840053060341S P E S S O R E D .10,1x 16x 0,30S H I M D .10,1x 16x 0,30840053060351S P E S S O R E D .10,1x 16x 0,20S H I M D .10,1x 16x 0,20932153080541MO L L A SP R I N G 1032093080172G U A R N I Z I O N E G A S K E T 1106360152105V I T E T E M 6x 30S C R E W T E M 6x 301206303005025R O S E T T A E L A S T I C A E L A S T I C W A S H E R 13 32151990511K I T C O P E R C H I O P E R D I S T R I B U T O R E C O N T R O L V A L V E C O V E R 1406305131501AN E L L O S E E G E R SE E G E R R I N G 1532153080591V A L V O L A P E R D I S T R I B U T O R E VA L V E 1606352900262RA L L A T H R U S T W A S H E R 1706353020511G AB B I A A S S I E M E R U L L I N I R O L L E RC A G E A S S Y 1832153080341P E R N O P E RD I S T R I B U T O RE C O N T R O L V A L V E P I N 1906313290691SP I N A PI N 2032153080171L E V A L E V E R 2106305321391A N E L L O S I C U R E Z Z A S N A P R I N G 2206343039551A N E L L O D I T E N U T A O R O -R I N G 2332153080631TA P P O P L U G 2406348010741A N E L L O D I T E N U T A O R O -R I N G 2532153080621MO L L A S P R I N G 2632153080611V A L V O L I N A D I R E G O L A Z I O N E 270636302039TA P P O 1/8"G A S PL U G 1/8"G A S IR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E DI S T R I B U T O R E / C O N T R O L V A L V E 6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LD I S T R I B U T O R E/C O N T R O L V A L V EL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o n 2806348011521AN E L L O D I T E N U T A O R O-R I N G2932013080011MO L L A S P R I N G 3006354600361S F E R A R B B A L L 3132093080071N I P P L O M 20X 1,5N I P P L E M 20X 1,53232133080191FI L T R O SC R E E N 3306363010195T A P P O 1/8"G A S P L U G 1/8"G A S 3406313291352SP I N A PI N 3506360101722V I T E T E M 10x55S C R E W T E M 10x 553606303005045R O S E T T A E L A S T I C A E L A S T I C W A S H E R 3706360101793VI T E T E M 10x 70S C R E W T E M 10x 703832153080601P I A S T R A G R A D U A L E 4006363020211TA P P O M 18x 1,5P L U G M 18x 1,54106348010571A N E L L O D I T E N U T A O R O-R I N G 4432093080373S P E S S O R E D .17,2x 23,8x 0,50S H I M D .17,2x 23,8x 0,504432093080381S P E S S O R E D .17,2x 23,8x 0,15S H I M D .17,2x 23,8x 0,154432093080391S P E S S O R E D .17,2x 23,8x 0,25S H I M D .17,2x 23,8x 0,254432093080402S P E S S O R E D .17,2x 23,8x 1,00S H I M D .17,2x 23,8x 1,004432093080411S P E S S O R E D .17,2x 23,8x 0,10S H I M D .17,2x 23,8x 0,104532153080651GU A R N I Z I O N E GA S K E T 4632151080041D I S T R IB U T O R E O L I OC O M P L E T O O I LD I S T R I B U T O R A S SE M B L Y IR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E DI S T R I B U T O R E / C O N T R O L V A L V E 6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LK I T V A L V O L A T R O L L I N G/T R O L L I N G V A L V E K I TL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o n 16361015841VI T E T C E I M 6x 50SC R E W M 6x 50206361017312V I T E T C E I M 6x 25S C R E W M 6x 25306361018592V I T E T C E I M 6x 60S C R E W M 6x 60432093080172G U A R N I Z I O N E GA S K E T 532153080551C O P E R C H I O C O V E R 632093080321MO L L A S P R I N G 706354600361S F E R A R B B A L L 80631611011G R A N O M 6x 8P L U G M 6x 8932153080581CAM M ACA M 1006313290441S P I N A P I N 1132153080401P E R N O P I N 1206343495331A N E L L O D I T E N U T A O -R I N G 1306370110341D A D O A U T OB L OC C A N T E S E L F -L O C K I N G N U T 1432153080071LE V A LE V E R 1540053060271S P E S S O R E D .10,1x 16x 1,0S H I M D .10,1x 16x 1,01540053060321S P E S S O R E D .10,1x 16x 0,50S H I M D .10,1x 16x 0,501540053060331S P E S S O R E D .10,1x 16x 0,40S H I M D .10,1x 16x 0,401540053060341S P E S S O R E D .10,1x 16x 0,30S H I M D .10,1x 16x 0,301540053060351S P E S S O R E D .10,1x 16x 0,20S H I M D .10,1x 16x 0,201632093080371S P E S S O R E D .17,2x 23,8x 0,50S H I M D .17,2x 23,8x 0,501632093080381S P E S S O R E D .17,2x 23,8x 0,15S H I M D .17,2x 23,8x 0,151632093080391S P E S S O R E D .17,2x 23,8x 0,25S H I M D .17,2x 23,8x 0,251706590645041MI C R O I N T E R R U T T O R E M I C R O S W I T C H E R 1806343038121A N E L L O D I T E N U T A O-R I N G 1932153080081SU P P O R T O S U P P O R T 2032153080641F I L T R O V E R S I O N E T R O L L I N G V A L V E T R O L L I N G V A L V E S C R E E N 2132133080121N I P P L O V E R S I O N E T R O L L I N G V A L V E T R O L L I N G V A L V E N I P P L E IR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E KI T V A L V O L A T R O L L I N G / T R O L L I N G V A L V E K I T 6.3C A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O S C A M B I A T O R E/E X C H A N G E R A S S YL I S TPo s .ZF Co d i c e P a r t n u m b e r Qu a n t i t àQ u a n t i t y De s c r i z i o n e De s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E GR U P P O S C A M B I A T O R E / E X C H A N G E R A S S Y6.3 132153070401TU B O O L I O D A S C A M B I A T O R E A I N V E R T I T O R E OI L T U B E F R O M C O O L E R T O G E A R B O X 206378700202NI P P L O NI P P L E 306348012283G U A R N I Z I O N E S E A L 406378702041GO M I T O E L B O W 506348012423G U A R N I Z I O N E S E A L W A S H E R 606378702013NI P P L O NI P P L E 732153070411T U B O O L I O D I S T R I B U T O R E /S C A M B I A T O R E C O N T R O L V A L V E O I L T U B E T O C O O L E R 806370110342DA D O A U T OB L OC C A N T E M 10SE LF -L O C K I NG N U T 906360152262VI T E T E M 10x 25S C R E W T E M 10x 251032153070316I N S E R T O E L A S T I C O E L A S T I C I N S E R T 1132153070312MO R S E T T O TE R M I N A L 1206360161782V I T E T E M 12x 25S C R E W T E M 12x 251306303020422R O S E T T A E L A S T I C A E L A S T I C W A S H E R 1432153070461S U P P O R T O S C A M B I A T O R E E X C H A N G E R S U P P O R T 1532133070062S C A M B I A T O R E D I C A L O R E HE A T E X C H A N G E R 1606360105682VI T E M 10x 100S C R E W M 10x 1001706348012912G U A R N I Z I O N E S E A L W A S H E R 1832093070252P O R T A G O M M A C O N N E C T O R 1932153070061T U B O P O M P A /D I S T R I B U T O R E O I L T U B E P U M P -D I S T R I B U T O RC A T A L O G O P A R T ID I R I C A M B I O/S P A RE P A R T S C A T A L O G U EI R M350P LG R U P P O P T O C O N F R I Z I O N E/C L U T C H A B L E P T O A S S YL I S TPo s .ZF Co d i c e P a r t n u m b e r Q u a n t i t àQ u a n t i t y De s c r i z i o n e D e s c r i p t i o nIR M 350 P L CA T A L O G O P A R T I D I R I C A MB I O / S P A R E P A R T SC A T A L O G U E6.3 GR U P P O P T O C O N F R I Z I O N E / C L U T C H A B L E P T O A S S Y 1635302051 1GA B B I A A S S .R U L L I N I TR U S T N E E D L E B E A R I N G 206352900262RA L L A A S TR U S T W A S H E R 332153150051P E R N O D I S T R I B .P T O P T O D I S T R I B U T O R P I N 406313290691SP I N A EL A S T I C P I N 506305020151A N E L L O S I C U R E Z Z A S N A P R I N G 606354163301C U S C .R U L L I C I L .N J 208E C P -C 3B A L L S B E A R I N G 732153150111RA L L A T R U S T W A S H E R 8 0635302034 2G AB B I A A S S . R U L L I N I A X K 4060 T R U S T N E E D L E B E A R I N G 932153150091I N G R A N A G G I OC O N M O Z Z O GE A R 10 06352900352RA L L A A S 4060T R U S T W A S H E R 1106352900631R A L L A L S 4060T R U S T W A S H E R 1232153150071C A M P A N A F R I Z .P T O P T O C L U T C HB E L L 1306305020511AN E L L O S I C U R E Z Z A SN A P R I N G 1432093030131D I S C O C O N D O T T O P O S T .T O O T H E D R I N G 15 3210303015 3D I S C O F R I Z I O N E C L U T C H D I S K 16 3210303014 2D I S C O F R I Z I O N E C L U T C H D I S K 1732153150081P I S T O N E F R I Z .P T O PI S T O N 180634304233 1AN E L L O T E N U T A OR 19 0635460006 1SF E R A R B -B A L L 2032133020261G R A N O P L U G 2132153150101B U S S O L A D .45X 58X 78 B U SHI N G 22 0634402167 3SE G M E N T O S E G M E N T 23063630101911TA P P O PL U G 2406353580401C U S C .R A D .O R I E N T .R U L S W I N G I N G B A L L B E A R I N G 2506361011636VI T E SC R E W 26 0634319112 1A N E L L O T E N U T A S E A L R I N G 2732153150271B U S S O L AD .45X 65X 21 B U S H I N G 2806343063001AN E L L O T E N U T A OR 2906361014753VI T E S C R E W。